The culture of compound bioflocculant and the analysis of its activated components

利用农业固体废弃物秸秆类纤维素为原料制备复合型生物絮凝剂（CBF）,优化了CBF的培育条件。同时解析了CBF活性物质在发酵液中的分布,并对CBF的活性组分进行了研究。结果表明,在高效纤维素降解菌HIT-3的作用下,秸秆类纤维素发酵3天产糖量达到高峰,此时接入CBF产生菌于灭菌后的纤维素发酵液中,在30℃、140r/min的旋转式摇床上培养36h,整个过程中只需将纤维素发酵培养基的pH值调节到7.2。在上述条件下CBF可获得较优的絮凝效果;多糖是CBF的主要组成成分,CBF的热稳定性良好。其絮凝活性物质主要分布在上清液中。     

固定化白地霉处理高硬度及高矿化度岩溶水的研究

为了使白地霉固定化小球处理太原市地下岩溶水达到最佳絮凝效果,分别研究了白地霉菌体的最佳扩大培养条件.同时,分别选用海藻酸钠(SA)、聚乙烯醇-海藻酸钠(PVA-SA)及聚乙烯醇-海藻酸钠-明胶(PVA-SA-明胶)作为固定化剂,固定化白地霉菌体,进行絮凝性能分析.最后,确定了固定化小球处理岩溶水的最佳搅拌时间及投加量,并与六水合氯化铝、自制三元复合吸附剂及壳聚糖的5%冰醋酸溶液的絮凝效果进行了比较.结果表明,将白地霉种子培养基按3%的接种量接入白地霉扩大培养基3中进行扩大培养,可在第2d获取活性较好的大量白地霉菌体进行固定化.处理岩溶水时应选用PVA-SA-明胶固定化的白地霉小球,并在其投加量为4g·L-1、搅拌时间为60min时,对岩溶水矿化度、硬度的最大絮凝率分别为96.88%、50.00%.经与化学混凝剂絮凝性能对比发现,微生物絮凝剂具有操作简便、无二次污染、絮凝效果较好的优点.     

絮凝剂聚硅酸锌铁(PZFSiC)的研制和性能

在高模数水玻璃溶液中加入酸制备出聚硅酸,再引入适量的金属离子M(Zn、Fe),研制出一种新型的无毒无机复合高分子絮凝剂聚硅酸锌铁(PZFSiC).探讨了M与SiO2不同浓度比和不同pH值对PZFSiC的絮凝效果的影响,通过正交实验找出了最佳的制备工艺条件.在此基础上,进一步对两种不同的水样进行了絮凝实验,确定出水处理中最佳絮凝工艺条件.结果表明,PZFSiC具有较好的贮存稳定性,在使用PZFSiC时,适应的pH范围广.在实验过程中形成大而致密的絮体,沉降迅速,浑浊度去除率超过98%,COD去除率达93%.处理后的废水,出水水质好,水样澄清透明.在与同类絮凝剂对比实验中,效果优于PZSiC和PFSiC.     

絮凝条件对絮体分形结构的影响

在85kg/m³的含沙高浊水中投加阳离子高分子聚合物,借助图像分析技术与沉降技术分析探讨了不同絮凝条件下泥沙絮凝形态学参数:絮体粒径、絮体有效质量密度、絮体自由沉速、浑液面沉速与上清液余浊等的变化规律.利用表征参数“分维”定量控制不同絮凝条件(如搅拌速率、搅拌时间、高分子浓度等)对含沙高浊水絮体结构分形特性的影响.实验证明,不合适的絮凝条件将导致絮体分形构造疏松脆弱,分维值低.絮凝条件合适时(快速絮凝强度为:r₁=300r/min,t₁=10s;慢速絮凝强度:r₂=120r/min,t₂=180s;CP浓度:0.1%),絮体分形结构处于最佳状态.该状态下的絮体具有粒径较大、沉速快、有效质量密度高、粒度分布均匀,分维值最高(D₃=2.16)的特点.而且,由静沉实验测得浑液面沉速高,上清液余浊也低.泥沙絮体分形结构达最佳时的混凝性能、沉降性能与结构密实性均较理想.     

Al13形态在混凝中的作用机制

从铝的水解形态转化角度考察了铝盐在高碱度和高有机物浓度水体中的混凝行为.结果表明,铝盐的混凝效能是与混凝过程中的Al₁₃含量成正比.高投药量时氯化铝(AlCl₃)既可以有效调节水体pH值又能在混凝过程中原位水解产生较多的Al₁₃形态,因而混凝效能要高于聚合氯化铝(PACl).在铝盐混凝中,调节pH值到6～7之间可以控制铝形态分布从而达到提高混凝效能和减少残留铝的目的.在调节pH值强化混凝的方法中使用传统铝盐的效果要好于无机高分子絮凝剂.     

微生物絮凝剂处理含油废水

对用一种用发酵法制备的生物絮凝剂的絮凝性能进行了研究。结果表明,试验所得生物絮凝剂具有较好的耐温性和较好的絮凝能力。对试验用乳浊液絮凝除油效率达95%以上,优于商品破乳剂E-3453的絮凝性能。将生物絮凝剂用于含油废水的处理,出水含油量小于5mg/L。     

铝盐最佳混凝形态及最佳pH范围研究

本文从理论上分析了铝盐的水解聚合过程,预测了铝盐混凝过程进行时的最佳混凝形态及最佳ｐＨ范围,并且通过实验手段分析说明了铝盐的最佳混凝形态,混凝特征及最佳ｐＨ范围,得到了较为一致的结果。     

城市污水回用三种处理工艺的选择

本文针对我国城市二级出水的特点,研究了污水深度处理的三种工艺:絮凝沉淀过滤、微絮凝过滤和直接过滤.装置采用网格反应池、翼片斜板沉淀池、气水同时冲洗粗砂滤池.药剂选用聚合硫酸铁,试验规模120m~3/d.     

A Biosurfactant-Enhanced Soil Flushing for the Removal of Phenanthrene and Diesel in Sand

In order to examine the potential of biosurfactants in soil remediation, and to investigate the effects of several operating conditions, such as flow rate, biosurfactant concentration and surfactant type, biosurfactant-enhanced soil flushing was conducted. In the biosurfactant-enhanced soil flushing process, the removal efficiency increased as the flow rate decreased. Rhamnolipid showed no effect on the removal efficiency of phenanthrene and diesel from sand in the concentration range 0.3-0.5%. However, rhamnolipid showed higher efficiencies for the removal of phenanthrene and diesel from sand than Tween 80. Based on total recovery, following an equivalent pore volume flush, it was more difficult to remove diesel than phenanthrene. In order to obtain the specific removal efficiency, more pore volumes of surfactant solution may be required in field applications. Under optimum conditions, the biosurfactant removed as much as 70% of the phenanthrene and 60% of the diesel in the sand. These results indicate that the use of biosurfactants in the flushing process is favorable, not only with respect to the environment, but also on removal efficiencies.     

Nutrients Can Enhance Phytoremediation of Copper-Polluted Soil by Indian Mustard

An orthogonally designed experiment was conducted to study the single and combined effects of N, P and K on phytoremediation of Cu-polluted soil by Indian mustard. Addition of fertilizer N and P significantly increased Indian mustard shoot yield. Two high treatments combined with N resulted in the highest yields, followed by low-P combined with N. In contrast, high P with no N gave no yield increase and K had no effect on yield of Indian mustard. Nitrogen and P increased the amount of chlorophyll in the leaves, indicating that the yield increases were due to enhanced photosynthesis. Nitrogen application had no effect on plant Cu concentrations but addition of P slightly decreased plant Cu concentrations, likely a dilution effect resulting from the increase in yield. Among the treatments, N and P applied at 100 and 200 mg kg^–1 respectively with no K application resulted in the highest Cu uptake. Thus, a combination of low N and high P produced a yield increase in Indian mustard that was more than adequate to compensate for a slight decrease in Cu concentration, resulting in the highest Cu removal from the contaminated soil.