矿山振动机械本质安全技术研究及应用

目前矿山开采领域所使用的振动机械(包括振动磨、振动筛等)的振动负荷都无一例外地传递给弹簧、机架、基础,对机器相关零部件及周围会造成不同程度的安全影响,安装要求也较高。从设备的安全性角度来说,无法达到本质安全要求。按照传统振动机械的设计理论,振动负荷向外传递无法避免,无法实现本质安全。提出振动机械设计理论,可以实现本质安全化设计。实际应用结果表明,外传的振动负荷降低95%以上,且可达到节能50%以上。     

污染场地健康风险评价中多介质模型的优选研究

综合考虑了参数不确定性、模型不确定性对风险评价结果可信度的影响差异和国内实际污染场地健康风险评价中对已有模型的不当选择可能带来的负面效应,提出相对于参数不确定性的控制,针对目标情景的适当模型选择应成为提高风险评价结果可信度的更重要环节.本研究选取了模型理论架构上符合案例情景的美国环境保护署研发的3MRA、MMSOILS和美国劳伦斯伯克力国家实验室研发的CalTOX 3个被广泛使用的污染场地健康风险评价多介质模型,并与蒙特卡洛模拟相结合,载入污染厂址案例,并对特定受体进行了风险评价,由此定量分析了参数不确定性和模型选择不确定对评价结果可信度的影响程度,并通过对比3个模型的内在架构分析了不确定性的可能来源,最后总结提出了“6步综合评价模式”,该模式能有效提高污染场地健康风险评价的可信度及经济可行性.     

太湖湖滨湿地降解有机物兼性厌氧菌群的筛选及其降解效果

利用梯度间歇曝氧新技术,从太湖湖滨湿地沉积物中筛选出高效降解有机物的土著兼性厌氧菌群,分离纯化、鉴定出优势菌,并研究了接种兼性厌氧菌对湖滨湿地微生物群落结构及有机物降解效果的影响.结果表明,筛选出的兼性厌氧菌群中没有严格好氧菌或严格厌氧菌混杂,筛选后期对沉积物中TOM的去除率为21%.分离出优势菌FA4,FA10和FA14,其16S rDNA鉴定结果分别为Pseudomonas sp.,Flavobacteriaceae bacterium和Haematobacter sp..分别接种优势菌及混合菌群后的湖滨湿地沉积物中兼性厌氧菌数和菌活性ETS值比对照组显著增高.对照组兼性厌氧菌菌群数〔lg(MPN/g),以干质量计,其中MPN为最大概率可能数量〕和ETS(以INTF计,干质量)值分别为4.9和85 μg/(g·2 h),而试验组的兼性厌氧菌菌群数都在5.4以上,ETS值都在240 μg/(g·2 h)以上.筛选出的兼性厌氧菌及菌群能很好地适应环境,有效降解有机物,7 d内将湖滨湿地沉积物中的BOD₅降低了90%以上,而未接种的对照组仅减少了56%;其TOM去除率是对照组的2.0～2.6倍,3 d内对照组TOM去除率为5%,而FA4,FA10,FA14和菌群(FAG)试验组TOM去除率分别为10%,13%,10%和12%.      

丁二腈高效降解菌的筛选及其降解性

以丁二腈为唯一碳源和氮源,从石化腈纶废水及其处理构筑物的生物膜中,分离、筛选出2株高效降解丁二腈的菌株:J-1-3和J-13-1.经形态学观察和生理生化特征研究,两者均被鉴定为假单胞菌(Pseudomonas spp.).通过摇瓶试验得出2菌株的最适生长条件:温度为30℃,摇床转速(间接反映通气量)为250 r/min,接种量为0.1%,初始pH为6.在最适生长条件下,分别对不同初始浓度丁二腈进行降解率试验.结果表明,2菌株对丁二腈的降解能力强,尤以J-13-1更为显著.当丁二腈的初始浓度约为6000mg/L、8000mg/L和10000mg/L时,J-13-1菌株对丁二腈的降解率分别在12.5h、14h和16h时达到100%.     

Screening and degradation characteristics of a tetracycline-degrading bacterial strain北大核心CSCD

Tetracycline is widely used in livestock and poultry breeding industry, which can cause serious problems to the environment. Antibiotic pollution has become an important environmental issue. This study aimed to isolate and identify a well-functioning tetracycline-degrading bacteria strain from activated sludge and to investigate its optimum degradation conditions. The strain was identified through morphological features, Gram staining, and the sequence analysis of 16S rRNA. Furthermore, the temperature, initial pH of the medium, inoculation amount, and type of metallic salt were analyzed to investigate the tetracycline degradation performance of the isolated strain. Based on the single factor test, the method of response surface analysis was adopted to optimize the degradation condition. The strain was named TTC-1 and identified as Klebsiella pneumoniae. The optimum condition for tetracycline degradation was determined as follows: temperature of 34.4 °C, pH of 7.22, and MnSO4 concentration of 0.32 g/L. Under this optimum condition, the predicted tetracycline degradation rate was 93.77%, whereas the observed value was 94.26%. The experimental results showed that the proposed model had high accuracy. TTC-1 showed a good performance in degrading tetracycline, which can provide reference for the bacteria during the biological treatment of tetracycline containing wastewater. © 2018 Science Press. All rights reserved.     

Screening on oil-decomposing microorganisms and application in organic waste treatment machine

As an oil-decomposable mixture of two bacteria strains ( Bacillus sp. and Pseudomonas sp. ), Y3 was isolated after 50 d domestication under the condition that oil was used as the limited carbon source. The decomposing rate by Y3 was higher than that by each separate individual strain, indicating a synergistic effect of the two bacteria. Under the conditions that T = 25-40℃, pH = 6--8, HRT (Hydraulic retention time) = 36 h and the oil concentration at 0.1%,Y3 yielded the highest decomposing rate of 95.7 %. Y3 was also applied in an organic waste treatment machine and a certain rate of activated bacteria was put into the stuffing. A series of tests including humidity, pH, temperature, C/N rate and oil percentage of the stuffing were carried out to check the efficacy of oil-decomposition. Results showed that the oil content of the stuffing with inoculums was only half of that of the control. Furthermore, the bacteria were also beneficial to maintain the stability of the machine operating. Therefore, the bacteria mixture as well as the machines in this study could be very useful for waste treatment.     

上海市浅层地下水在线监测技术要点

地下水在线监测技术可以实现地下水水质的高频监测,是未来发展的重要趋势。梳理国内外地下水在线监测技术研究进展,以上海市典型水文地质特征与环境质量状况为例,探讨地下水在线监测点位布设、指标筛选、监测方式及监测井设计等技术要点。首先,优化监测点位布设,对需要开展高频监测的区域或重点风险源开展在线监测,以代表性点位反映总体地下水环境质量状况。其次,综合筛选监测指标,除常规参数外,优先选取水体中的氨氮、高锰酸盐指数等作为在线监测指标,在具有潜在有机污染的区域,选取水中有机物、水中油等作为有机污染指示性指标。应进一步加强指标之间的相关性分析,为指示性指标的确立提供依据。再次,合理确定监测方式,根据取样方式以及污染源风险等级,设置相应的微型站和小型站。最后,优化监测井设计技术方案,进一步研究不同井管材质对地下水中无机或有机污染物的长期吸附(解吸)作用。     

Evaluation of a fluorometric screening method for predicting total PAH concentrations in contaminated sediments

A fluorometric screening method was used to estimate total polycyclic aromatic hydrocarbon (t-PAH) concentrations in sediments collected from the St. Louis River Area of Concern (AOC) in northeastern Minnesota. Sediments were collected as part of a Regional Environmental Monitoring and Assessment Program (R-EMAP) study to assess sediment quality in the AOC. The screening method was calibrated using a PAH surrogate standard consisting of eight PAHs commonly found in the St. LouisRiver system, at their approximate proportions. Estimated PAHconcentrations were compared to GC/MS measured `true' PAH concentrations to evaluate the overall predictive power of thescreening method. Regression analysis of log transformed estimated versus true PAH concentration yielded an r² of 0.72 (n = 86). In addition, the rates of false positive and false negative predictions associated with the screening methodwere determined relative to different sediment effects concentrations (SECs) for total PAHs. In general, the rate of false positive predictions was shown to increase as the SEC criteria value decreased, while false negative rates remainedconsistently low (below 7%). Methodological recommendations which led to a three-fold reduction in false negatives, and theimproved prediction of both high and low PAH samples, are presented.