HRT对固定床厌氧反应器运行效果的影响

为了考察水力停留时间(HRT)对炭纤维载体固定床厌氧反应器运行效果的影响,在进水COD分别为20 000~25 000 mg/L和40 000~45 000 mg/L2个浓度范围下,研究了不同HRT对反应器运行效果的影响。结果表明,通过HRT的调整,在达到相同有机负荷(OLR)下,进水COD为20 000~25 000 mg/L的COD去除率和产气量,明显比进水COD为40 000~45 000 mg/L的运行效果好;进水COD为20 000~25 000 mg/L,HRT为14 h,相应的OLR为41.09 kgCOD/(m3.d)时,COD去除率仍然维持在68%以上,沼气容积产气率达到14.55 m3/(m3.d)。炭纤维载体固定床厌氧反应器具有较高的COD去除率、产气效率以及抵抗低pH、高负荷冲击的能力,运行过程中没有发生反应器堵塞的现象。     

异波折板水解酸化-A~2O一体化反应器实验研究

设计了异波折板水解酸化-A2O一体化反应器,进行生活污水处理的实验研究。10个月的实验结果表明,系统的最佳水力停留时间(HRT)为8 h时,最适COD进水浓度为240~600 mg/L,最佳混合液回流比(r)-污泥回流比(R)为250%~100%。控制反应器于以上运行参数下,25±2℃所对应的COD、TN和TP去除率分别为96.84%、67.55%和81.92%。当温度降至7℃时,其COD、TP和TN分别降至86.35%、50.25%和65.68%。基于实验分析结果,阐明了一体化反应器高效性的机理在于异波折板水解酸化段具有高效传质特性和A2O段具有复合式活性污泥-接触氧化好氧池的特点。     

生物沸石滤池处理富营养化水体的挂膜实验

采用上向流生物沸石滤池处理富营养化水体,考察了挂膜阶段(前30 d)滤池对浊度、COD和TP等的去除效果,重点研究了系统中各形态氮素(NH4+-N、NO2--N、NO3--N和TN)的变化情况。结果表明,对于富营养化水体,生物沸石滤池对浊度、COD和TP的去除率分别约为80%、30%和24%;出水NH4+-N始终保持在0.5 mg/L以下,去除率在90%以上;NO2--N出现峰值(4.98 mg/L,第9 d),第13 d后即一直低于进水值;实验后期出水NO3--N与进水NH4+-N变化趋势基本一致,表明硝化生物膜已成熟,原位再生可行;生物沸石床内可能存在同步硝化反硝化现象。出水NO2-N浓度低于进水可作为生物沸石挂膜成功的一个标志。     

连续流改进A~2/O反应器去污效果及分相培养研究

以生活污水为原水,在常温(25~33℃)条件下采用连续流改进A2/O反应器进行脱氮除磷实验研究。系统内COD降解,TN与TP去除主要在活性污泥段完成,而NH4+-N去除基本在生物接触氧化区完成。从中沉池出水硝态氮影响因素分析可知,选用较高的有机负荷有利于实现系统内分相培养。泥龄对实现系统内微生物异养菌和自养菌的分相培养具有关键影响。当泥龄10 d,可实现系统内异养菌与自养菌的分相培养。     

厌氧氨氧化ASBR中亚硝氮和氨氮降解规律研究

采用生物膜ASBR反应器,研究了厌氧氨氧化反应过程中亚硝氮与氨氮降解速度的变化规律。结果表明,降解过程主要分为2个阶段:速度上升期(0~30 min)和速度下降期(30~150 min)。一阶指数衰减模型的模拟结果表明,20 min以后亚硝氮、氨氮降解速度逐渐减少,亚硝氮降解速度始终高于氨氮降解速度,但是两者差值随时间逐渐减少。     

氧化镁烟气脱硫反应特性研究

利用实验室规模的鼓泡式反应装置,对比了碳酸钙、氧化镁和氧化镁/硫酸镁脱硫剂的反应活性,证实脱硫液中高浓度硫酸镁的存在是保证镁法脱硫效率高于钙法的重要因素,并考察了硫酸镁浓度、脱硫剂(氧化镁)浓度、烟气量、SO2浓度和吸收液温度等因素对脱硫效率的影响。结果表明,脱硫反应可以根据pH分为2个不同阶段;反应过程中脱硫效率随着硫酸镁浓度的增加而显著升高;烟气量增加将会导致脱硫效率有所下降;入口SO2浓度升高,脱硫效率下降;氧化镁浓度、温度对脱硫效率影响不显著。结合实验现象进行推断,氧化镁脱硫的反应过程受SO2在气液两相界面的传质扩散和其水解产物在液相的扩散控制。     

连续流反应器中培养好氧颗粒污泥的运行效能研究

在连续流完全混合反应器(CSTR)中,采用不同进水方式,以乙酸钠作为碳源配制的人工配水作为原水,对好氧颗粒污泥的运行效能进行了试验研究。研究表明,采用不同进水方式运行的2个反应器在颗粒污泥出现后,运行效能差别不大;好氧颗粒污泥反应器运行高效稳定,在水力停留时间为1.5h、COD容积负荷为1.0kg/(m3·d)的条件下,对COD、TP、NH4+-N和TN的去除率分别为90%、85%、95%和60%,并具有明显的脱氮除磷效果;反应器中存在同步硝化反硝化现象。     

聚磷生物膜的快速启动及微生物特性研究

在同步去除并富集磷的基础上,探究采用前期不排泥、后期排泥的挂膜方式对聚磷生物膜反应器的运行效能、微生物特征及群落结构的影响.结果表明,经过驯化运行,聚磷生物膜的蓄磷能力明显提升.在挂膜阶段,生物膜厚度及EPS含量出现一定程度的增长;PN/PS上升至3.12,PN/PS比值增加有利于微生物粘附在填料上.在好氧出水达标的情况下,富集液中磷酸盐浓度提升至89.5 mg·L~(-1),达到了鸟粪石回收标准.高通量测序结果表明,经过富集培养,微生物群落多样性呈下降趋势,群落组成变化明显.优势菌门为变形菌门(Proteobacteria),其丰度从33.6%增长至75.3%;反应器中的聚磷菌属丰度明显增加,从11.8%上升至23.2%,红环菌属(Rhodocyclaceae)、UKL 13-1为反应器中的优势聚磷菌.     

Insights into sludge granulation during anaerobic treatment of high-strength leachate via a full-scale IC reactor with external circulation system

In this study, a full-scale internal circulation(IC) reactor coupled with an external circulation system was developed to treat high-strength leachate from a municipal solid waste(MSW)incineration plant, in which anaerobic sludge granulation was intensively investigated. Results showed that the IC reactor achieved excellent treatment performance under high organic loading rates(OLR) of 21.06–25.16 kg chemical oxygen demand(COD)/(m3? day). The COD removal efficiency and biogas yield respectively reached 89.4%–93.4% and 0.42–0.50 m3/kg COD.The formation of extracellular polymeric substances(EPS) was closely associated with sludge granulation. Protein was the dominant component in sludge EPS, and its content was remarkably increased from 21.6 to 99.7 mg/g Volatile Suspended Solid(VSS) during the reactor operation. The sludge Zeta potential and hydrophobicity positively correlated with the protein/polysaccharide ratio in EPS, and they were respectively increased from-26.2 m V and 30.35% to-10.6 m V and 78.67%, which was beneficial to microbial aggregation. Three-dimensional fluorescence spectroscopy(3 D-EEM) and Fourier transform infrared spectroscopy(FT-IR)analysis further indicated the importance of protein-like EPS substances in the sludge granulation. Moreover, it was also found that the secondary structures of EPS proteins varied during the reactor operation.     

Diffusion mechanism of lindane into wood charcoal

Abstract

The wood charcoal treated by 1N HNO₃ (WCT) was used to remove toxic chlorinated pesticide lindane (y‐HCH) residue from water by the sorption process. Using a simple first order reversible kinetics constants and half time equations, the film and pore diffusion coefficients were determined. Film diffusion was found to be rate limiting step in sorbing lindane by WCT. This was further authenticated by kinetics studies at different initial sorbate concentrations, different sorbent sizes, and different agitation speeds besides interruption test. A pore diffusion model was used to fit the data of kinetics in continuously mixed batch reactors (CMBR), and the tortuosity, external resistance, and surface diffusion effects on lindane sorption by WCT were noticed. The tortuosity values of 15 to 28 were obtained for WCT‐lindane system.