“混凝沉淀+纳米零价铁”处理印刷电路板生产废水中试研究

提出一种新纳米零价铁反应器(Nanoscale Zero-Valent Iron Reactor,简称NIR)及"混凝沉淀+纳米零价铁"处理工艺,通过实际生产废水进行中试,考察和研究该工艺和NIR技术处理江苏省某市印刷电路板(Printed Circuit Board,简称PCB)工业园区废水的效果。结果表明,此工艺对PCB生产废水中Cu、TP及COD Cr去除率分别可达到97.3%、73.7%、26%,其中Cu处理效果最佳;XRD结果表明,纳米零价铁(Nanoscale Zero-Valent Iron,nZVI)与PCB生产废水反应后含有γ-Fe2O3、Fe3O4、γ-FeOOH、CuO、Cu2O、Cu0等产物。"混凝沉淀+纳米零价铁"工艺处理废水时具有处理效果好、工艺耐冲击性能好、产泥量小、不易造成二次污染等优点。     

Steady performance of a zero valent iron packed anaerobic reactor for azo dye wastewater treatment under variable influent quality

Zero valent iron (ZVI) is expected to help create an enhanced anaerobic environment that might improve the performance of anaerobic treatment. Based on this idea, a novel ZVI packed upflow anaerobic sludge blanket (ZVI-UASB) reactor was developed to treat azo dye wastewater with variable influent quality. The results showed that the reactor was less influenced by increases of Reactive Brilliant Red X-3B concentration from 50 to 1000 mg/L and chemical oxygen demand (COD) from 1000 to 7000 mg/L in the feed than a reference UASB reactor without the ZVI. The ZVI decreased oxidation-reduction potential in the reactor by about 80 mV. Iron ion dissolution from the ZVI could buffer acidity in the reactor, the amount of which was related to the COD concentration. Fluorescence in situ hybridization test showed the abundance of methanogens in the sludge of the ZVI-UASB reactor was significantly greater than that of the reference one. Denaturing gradient gel electrophoresis showed that the ZVI increased the diversity of microbial strains responsible for high efficiency.     

运用三维荧光光谱解析高温厌氧产氢反应过程对温度变化的响应

为建立反应器运行状态的荧光光谱快速监测方法,应用三维荧光光谱表征了高温厌氧反应器的出水,采用平行因子分析方法分析后得到3种荧光组分——蛋白质、辅酶NADH和核黄素,并获得它们的激发发射光谱图及相对浓度.结果表明,当温度从50 ℃上升到60 ℃的过程中,3种荧光物质的相对浓度均呈现相应的变化,它们与反应器的运行参数呈现明显相关性.进一步研究表明,核黄素是高温厌氧产氢反应中的特有荧光物质,采用标准加入法和二阶校正方法可以测定其实际浓度,出水中核黄素浓度变化范围为0.04~0.13 mg·L^-1.该研究为厌氧产氢反应器的运行监控提供了理论基础.     

基于响应曲面法袋式除尘器清灰性能的数值研究

利用计算流体动力学（CFD）方法,采用二维、可压缩、非稳态流动数学模型,对袋式除尘器脉冲喷吹过程中滤袋内的清灰流场进行了数值模拟,比较了滤袋壁面压力峰值的模拟值和试验值.同时,利用该模型,基于响应曲面法并使用统计软件MinitabV15研究了喷嘴直径、喷吹高度、文丘里管喉管直径、文丘里管及布袋长度对袋式除尘器清灰性能的影响,并得出了这5个影响因子的二次多项式预测模型.结果表明,滤袋表面压力峰值的模拟值与试验值变化趋势基本上是一致的,误差在10%左右,从而验证了本文数值计算模型的可靠性.在上述5个影响因素中,喷嘴直径（d）、文丘里管喉管直径（de）及布袋长度（L）对清灰性能影响显著,其中,清灰性能随着喷嘴直径和文丘里管喉管直径的增大而提高,随着布袋长度的增大先提高后降低.在本文所研究的尺寸范围内,当d=20mm、de=60mm及L=3360mm时,清灰效果分别达到最优.所得结论有助于进一步改善袋式除尘器的清灰性能.     

粉煤灰基质滤料生物过滤处理生活污水研究

将粉煤灰基质滤料用于曝气生物滤池,该滤料具有较高的比表面积和孔隙率,吸附性能良好,挂膜后生物相丰富。对于中等浓度的生活污水,当水力负荷和COD有机物负荷分别控制在1.53 m3/(m2.h)、3.68 kg/(m3.d)以下时,该曝气生物滤池COD和NH3-N去除率能稳定在85%以上,出水COD和NH3-N达到排放标准要求。该曝气生物滤池对进水水质水量的变动具有较强的抗冲击负荷能力。     

厌氧序批式反应器预处理垃圾渗滤液的碳平衡研究

为初步了解垃圾渗滤液中有机物降解过程的物质和能量转化,对渗滤液实际处理工程提供借鉴,在最优工艺参数条件下,分别用处于中温(35±1)℃和常温状态的厌氧序批式反应器(ASBR)对垃圾渗滤液进行预处理。通过对反应器内的液相、气相和固相碳素进行全面的分析测定,结果表明:中温(常温)条件下,整个反应周期内约有86.4%(77.6%)的碳进入气相,约有1.7%(1.4%)的碳进入固相,其余约11.7%(22.3%)的碳仍存于液相中;其中,进入气相部分的碳有77.6%(71.3%)以甲烷形式存在,8.8%(4.7%)以二氧化碳形式存在,这说明ASBR预处理垃圾渗滤液过程中产生的甲烷资源化利用潜力较大。另外,反应器在中温状态下较常温状态处理效果更佳。     

诱导喷嘴改进滤筒脉冲清灰效果的实验研究

改善清灰效果是提高滤筒除尘效率的关键和难点问题。运用自制脉冲喷吹实验台,采用诱导喷嘴(超音速引流喷嘴和气流散射器)对325 mm×660 mm滤筒进行脉冲喷吹清灰实验研究,并与采用普通喷吹孔的实验结果进行比较分析,得出采用诱导喷嘴时侧壁正压力峰值平均值是普通喷吹孔的1.465倍;且采用诱导喷嘴时各测点的不均衡系数为0.768～1.336,普通喷口为0.270～2.251,而不均衡系数越接近于1,其清灰效果越好;同时,采用诱导喷嘴时各测点基本在同一时刻达到正峰值。实验充分表明采用诱导喷嘴确保了滤筒长度方向上内壁清灰压力的均匀性,且对滤筒清灰效果有明显的改善作用。     

袋式除尘器进气均布板结构参数对气流分布的影响分析

针对袋式除尘器的进气均布板主要结构参数对气流分布影响的问题,采用正交试验方法进行CFD模拟试验设计,并以气流速度相对均方根σ值作为气流均匀性的评价指标。研究结果给出了σ与板数n、板长L、挡板上端距灰斗顶部截面高度ΔH、挡板前后偏角θ及过滤风速v之间的函数关系式。表明适当增加n、增大ΔH和θ、减小L、降低v,可以提高进气流分布均匀程度,影响进气均匀分布程度的排序为L>θ>n>ΔH>ΔL。     

Biological sulfate removal from acrylic fiber manufacturing wastewater using a two-stage UASB reactor

A two-stage UASB reactor was employed to remove sulfate from acrylic fiber manufacturing wastewater. Mesophilic operation (35±0.5℃) was performed with hydraulic retention time (HRT) varied between 28 and 40 hr. Mixed liquor suspended solids (MLSS) in the reactor was maintained about 8000 mg/L. The results indicated that sulfate removal was enhanced with increasing the ratio of COD/SO₄^2-. At low COD/SO₄^2-, the growth of the sulfate-reducing bacteria (SRB) was carbon-limited. The optimal sulfate removal efficiencies were 75% when the HRT was no less than 38 hr. Sulfidogenesis mainly happened in the sulfate-reducing stage, while methanogenesis in the methane-producing stage. Microbes in sulfate-reducing stage performed granulation better than that in methane-producing stage. Higher extracellular polymeric substances (EPS) content in sulfate-reducing stage helped to adhere and connect the flocculent sludge particles together. SRB accounted for about 31% both in sulfate-reducing stage and methane-producing stage at COD/SO₄^2- ratio of 0.5, while it dropped dramatically from 34% in sulfate-reducing stage to 10% in methane-producing stage corresponding to the COD/SO₄^2- ratio of 4.7. SRB and MPA were predominant in sulfate-reducing stage and methane-producing stage respectively.     

厌氧生物滴滤法脱除冷煤气中硫化氢的研究

水煤气中硫化氢在燃烧时会转变成二氧化硫,对环境产生污染。文章采用厌氧生物滴滤塔法对冷煤气进行脱硫处理。因煤气对氧的严格限制,通过设计生物滴滤塔,经挂膜驯化后在厌氧条件下对浓度在1~5 g/m3左右的硫化氢进行脱除处理,考察滴滤塔运行条件对脱除效果的影响。结果表明,生物挂膜25 d后,生物滴滤塔达到稳定,喷淋液pH值为2.23,ORP值为283 mV,溶解氧为0.4 mg/L,对溶液中硫离子氧化效率达到94%。滴滤塔在液气比0.15,空塔气速0.088 m/s,pH值5.0~7.0,填料高度为82 cm,塔温为25~30℃左右时,达到较优的运行条件,此时该滴滤塔对以CO、CO2、H2和1 940 mg/m3H2S组成的模拟水煤气的脱硫效率达91.2%。