某海洋平台上海水篮式过滤器事故分析

目的研究分析东海某一海上平台海水用篮式过滤器发生的腐蚀和堵塞事故原因。方法从海洋平台海水系统用篮式过滤器的原理、工艺流程、材料选择、滤网精度,滤芯设计、人工操作等多方面进行分析。结果受内压滤芯结构要优于受外压滤芯结构,如果过滤精度选择过高,会增加压差,造成滤芯堵塞。结论篮式过滤器滤芯单元应采用多滤芯的受内压结构,过滤精度应根据下游用户要求来确定。     

Fe-NaA分子筛膜的制备及催化湿式H2O2氧化甲基橙溶液

采用湿法造纸、二次生长和湿法浸渍法合成了一种新型微纤复合Fe-NaA分子筛膜催化剂,并将其用于催化湿式H_2O_2氧化甲基橙溶液.首先通过湿法造纸和烧结工艺制备纸状烧结不锈钢微纤(PSSF)载体,然后采用二次生长法在PSSF上合成NaA分子筛膜,最后以九水硝酸铁(Fe(NO_3)_3·9H_2O)和微纤复合NaA分子筛膜为原料,利用湿法浸渍法制备微纤复合Fe-NaA分子筛膜催化剂.考察了连续固定床反应器中温度、床层高度、进料液流量和甲基橙入口浓度对甲基橙降解性能的影响,并测定了催化剂重复使用3次后的稳定性.结果表明,随温度及床层高度增加,甲基橙转化率先增加然后趋于稳定;随进料液流量增加,甲基橙转化率均大于95%,但COD脱除率略有降低,当流量分别为2、3和4 mL·min~(-1),固定床连续运转5 h时COD脱除率分别为81.9%、76.4%和69.8%;随甲基橙入口浓度增加,其转化率变化幅度很小.在pH=2、催化剂床层高度2.0 cm、温度70℃、进料液流量4 mL·min~(-1)、甲基橙浓度50～200 mg·L~(-1)、固定床连续运转5 h的条件下,甲基橙转化率超过96%,COD转化率大于67%,铁浸出浓度低于4 mg·L~(-1).催化剂被重复使用3次后,甲基橙转化率基本保持不变.     

Performance of the hybrid growth sequencing batch reactor (HG-SBR) for biodegradation of phenol under various toxicity conditions

Hybrid growth microorganisms in sequencing batch reactors have proven effective for treating the toxic compound phenol, but the toxicity effect under different toxicity conditions has rarely been discussed. Therefore, the performance of the HG-SBR under toxic, acute and chronic organic loading can provide the overall operating conditions of the system. Toxic organic loading(TOL) was monitored during the first 7 hr while introducing50 mg/L phenol to the system. The system was adversely affected with the sudden introduction of phenol to the virgin activated sludge, which caused a low degradation rate and high dissolved oxygen consumption during TOL. Acute organic loading(AOL) had significant effects at high phenol concentrations(600, 800 1000 mg/L). The specific oxygen uptake rate(SOUR) gradually decreased to 4.9 mg O_2/(g MLVSS·hr) at 1000 mg/L of phenol compared to 12.74 mg O_2/(g MLVSS·hr) for 200 mg/L of phenol. The HG-SBR was further monitored during chronic organic loading(COL) over 67 days. The effects of organic loading were more apparent at 800 mg/L and 1000 mg/L phenol concentrations, as the removal range was between 22%–30% and 18%–46% respectively, which indicated the severe effects of COL.     

温度和DO对MBBR系统硝化和反硝化的影响

在缺氧/好氧/好氧串联运行的移动床生物膜反应器（MBBR）系统中考察了温度和好氧反应器中溶解氧（DO）水平对生物膜硝化和反硝化过程氮素去除的影响,并通过高通量测序技术探究温度和DO的变化造成的MBBR系统中脱氮功能菌群结构的差异,从而在微观水平解释硝化和反硝化受温度和DO影响的生物学机理.结果表明,系统温度的升高可以同时强化生物膜硝化和反硝化过程,且好氧反应器中DO水平的提高对硝化过程有利,从而提高系统的脱氮效果.本研究中,在系统连续运行阶段,当系统温度和好氧O₁反应器的DO浓度为本研究范围内的最高水平时（即温度=20~22℃、DO=5~8mg O₂/L）,比硝化负荷可达1.60g NH₄⁺-N/（m²·d）以上,而相同温度范围内比反硝化负荷可高达2.84g NO₃^--N/（m²·d）,从而使MBBR系统在该工况条件下获得了最佳的NH₄⁺-N和TN去除率（分别达到了98.7%和85.7%）.温度和DO影响硝化和反硝化的根本原因是温度和DO变化引起了脱氮功能菌群数量和群落结构的改变：当好氧反应器的DO水平下降时,硝化功能细菌的OTUs比例显著降低,尤其是异养硝化细菌的生长受到了严重的抑制;而温度的变化对反硝化细菌的影响主要体现在群落结构的变化.     

ACP1000除气塔液体冷却器抗震分析设计

目的对除气塔液体冷却器进行抗震分析,以确保其在地震下必要的安全功能。方法以福清5/6号核电工程为背景,通过有限元软件ANSYS建立除气塔液体冷却器有限元模型,采用反应谱法进行设备的抗震分析与评定。结果通过抗震分析评定,发现设备鞍座为设计薄弱区域,故修改鞍座的结构形式,包括新增筋板、增加壁厚,使该设备的设计满足了相关规范的要求。结论通过修改鞍座的结构形式,确保其必要的安全功能得以实现,满足实际工程的需要。     

O池溶解氧水平对石化废水A/O工艺污染物去除效果和污泥微生物群落的影响

以实际石化废水为处理对象,研究溶解氧浓度对A/O反应器生物降解特性的影响.A、B两组反应器平行运行以进行对比,O段的溶解氧浓度分别控制在2~3 mg·L-1和5~6 mg·L-1.反应器稳定运行近半年的结果表明:在HRT为20 h时,A组反应器出水的COD(72.5 mg·L-1±14.8 mg·L-1)略高于B组(68.7 mg·L-1±14.6 mg·L-1),COD平均去除率分别为67.0%和68.8%;出水氨氮的平均浓度和去除率为0.8 mg·L-1和95%左右.出水的BOD5均低于5 mg·L-1.表明A/O反应器对有机物的生物降解比较彻底,溶解氧浓度对其没有显著影响.对O段污泥进行454高通量测序结果表明:变形菌门、浮霉菌门和拟杆菌门细菌所占比例较高,在A、B组反应器中的比例分别为58.7%和59.2%、14.7%和12.7%以及10.8%和12.4%.高溶解氧运行的反应器B具有较高的菌群丰度和多样性,氨氧化菌Nitrosomonas、亚硝酸氧化菌Nitrospira和专性好氧菌如Planctomyces的比例较高.厌氧反硝化菌如Azospira和Acidovora在反应器A中的含量较高.在属的水平,鉴定出的Novosphingobium、Comamonas、Sphingobium和Altererythrobacter属细菌具有降解多环芳烃、氯代硝基苯、农药和石油化合物的功能,有利于石化废水的降解.     

Concentrations of inorganic elements in 20 municipal waters in Sweden before and after treatment – links to human health

The water chemistry of 20 municipal water treatment plants in southern Sweden, representing various bedrock situations, and water qualities, were investigated. Four water samples, raw and treated, were collected from each plant and analyzed by predominantly ICP-OES and ICP-MS at four occasions from June to December, 2001. The concentrations of Ca, Mg, K, Na, HCO₃ and a number of micronutrients, varied considerably in treated waters from the studied plants (ranges; Ca: 9.1–53.7 mg L⁻¹, Mg: 1.4–10.9 mg L⁻¹, K: 1.1–4.8 mg L⁻¹, Na; 5.4–75.6 mg L⁻¹, HCO₃: 27–217 mg L⁻¹). The elimination of Fe and Mn from raw water was efficient in all treatments investigated, giving concentrations in treated waters below the detection limits at some plants. Softening filters gave waters with Ca-concentrations comparable to the softest waters in this study. Adjustment of pH by use of chemicals like lye, soda or lime, modified the consumer water composition significantly, besides raising the pH. It was estimated that drinking water contributed to approximately 2.2–13% of the daily Ca uptake, if the gastrointestinal uptake efficiency from food and water was estimated to be around 50%. The corresponding figures for Mg was 1.0–7% and for F 0–59%. None of the studied elements showed any significant time trends in raw or treated waters during the follow-up period. The concentrations of potentially toxic metals such as Al, Pb and U were low and did not indicate risks for adverse health effects (ranges; Al: 0.5–2.3 μg L⁻¹, Pb: 0–0.3 μg L⁻¹, U: 0.2.5 μg L⁻¹).     

新型聚乙烯填料生物滴滤床净化硫化氢气体的启动研究

研究了新型高密度聚乙烯改良型拉西环填料生物滴滤床净化硫化氢气体的启动过程,重点比较了启动过程中不同的挂膜方式对启动时间及效能的影响.结果表明,采用液相连续流强化挂膜法成膜时间短,在环境温度20～28℃时7 d可以挂膜成功.在启动过程中,随着工艺参数的突然改变(GRT缩短)和入口浓度波动,液相连续流强化挂膜后反应器的硫化氢去除率更稳定.在进气浓度最高为343 mg/m³时硫化氢去除率稳定在95%以上.试验过程中还发现,将SO₄^2-浓度作为活性污泥驯化完成的监测指标、液相S^2-去除率作为挂膜完成的监测指标更合理.启动结束后,通过2种途径减去喷淋液中的碳源并未影响硫化氢的去除率,这进一步表明生物滴滤床中硫化氢的净化主要由自养菌完成.     

鱼体甲基汞的萃取富集和测定

研究了苯萃取和半胱氨酸滤纸富集再用苯洗脱的方法,使鱼肉中甲基汞得到富集和提取。建立了气相色谱测定甲基汞的方法并对所建立的方法进行评价。结果表明:加标回收率为87.10%～105.69%;变异系数为2.93%。符合要求,大量样品实验表明,该方法适用于痕量甲基汞的提取和分析。     

金隆公司烟尘输送系统的改造

介绍了金隆公司烟尘输送系统的改造过程,着重论述了A烟尘中问仓及双螺旋运输机、布袋收尘器的运行状况、存在的主要问题及改造经过;A、C烟尘系统对接的原因及实施过程。