旋流场超细颗粒聚集实验研究

不同粒径分布和浓度的催化裂化(FCC)三旋回收超细催化剂颗粒在旋流场中经过50 h循环回流,颗粒中值粒径变化明显。物料中分散相越多、颗粒粒径越小时,颗粒碰撞越频繁,其聚集趋势越明显。颗粒聚集体在旋流场内不够稳定,通过对比不同进料速率下的旋流场聚集效果,得到最适合颗粒聚集的旋流场雷诺数为20 000。颗粒聚集体存在聚集极限粒径,其最佳聚集时间约为40 h,颗粒聚集后的旋流分离效率提高近5%。     

某装药弹振动特性的安全分析

为分析某装药弹的振动特性,并为该弹提供必要的力学数据,建立某装药弹模态方程。采用ANSYS软件对该弹振动特性进行了数值模拟,利用Block Lanczos法求解,得到前10阶振动固有频率和振型。分析结果表明:低阶频率主要以摆动和转动为主,高阶频率主要以弯曲扭动为主,低阶频率对该弹的影响比较小,高阶频率对该弹的影响比较大,尤其是7～10阶频率,该弹的主振频率为1053.8 Hz,为该弹的优化设计提供科学依据,在加工、储存、运输和使用条件下应低于该频率;为验证该方法可信度,采用某小型装药弹进行了实验验证,实验结果和仿真结果偏差小于1%;同时证明该有限元数值分析的方法是经济可靠的。     

安全生产与经济社会发展关系理论研究

对美、英、加、日、澳等发达国家的安全生产状况近百年的统计数据进行了分析研究,发现大都经历了从事故频发到达高峰.逐步下降到平稳发展的"驼峰"过程,安全生产状况与经济社会发展阶段存在着相互制约、相互影响的联系,这是建立安全生产状况与经济发展水平的理论模型的事实依据.安全生产状况随经济社会发展而呈现出阶段性的变化趋势.影响一个国家的职业安全健康水平的直接原因有经济上的(安全投入)、科学技术方面、管理制度方面以及教育文化水平方面的,其中经济发展水平是各种原因的根本.重点揭示了安全生产与经济社会发展关系的内在规律,建立了相应的理论模型.并把所建立的理论模型应用到我国的煤矿安全领域.理论模型与实际统计数据基本吻合.     

大气压力对细水雾灭火系统泵组流量特性及效率的影响

柱塞泵是泵组式细水雾灭火系统的关键部件,它是细水雾喷头实施喷雾的供水源和压力驱动源.为研究大气压力,特别是高海拔低气压环境对柱塞泵流量特性及效率的影响,通过在合肥及拉萨两地的对比试验,给出了环境压力与柱塞泵流量特性及效率的关系.结果表明,大气压力减小使柱塞泵的流量减小,因此,在高原低气压环境下使用柱塞泵,应采用增加柱塞泵进口压力的措施,以保证泵组式细水雾灭火系统的设计性能;不同大气压力下泵组的效率无明显变化,即大气压力对泵组的效率无明显影响.     

SMBR内气液两相流三维CFD模拟

应用CFD软件Fluent对浸没式膜生物反应器(submerged membrane bioreactor,SMBR)内气液两相流进行数值模拟研究,重点考查曝气系统的改变对气液两相流态的影响,并结合PIV实验验证模拟结果,从而为反应器的优化设计及膜污染的控制提供理论依据。模拟结果表明,SMBR内曝气强化了气液两相紊动,膜表面液相速度沿反应器高度增加且形成循环流动,有利于膜面污染物的脱落;反应器内气含率分布不均匀,出现死区,不利于微生物的生长;经实验验证,模拟结果吻合良好。     

不同粒径炉渣对磷的静态吸附

研究了不同粒级炉渣对含磷废水的静态等温吸附性能,为其在污水处理领域的有效利用和合理级配提供理论依据。经筛分得到<0.2 mm、0.2~0.45 mm、0.45~0.9 mm、0.9~2 mm、2~4 mm、4~6 mm、≥6 mm的7个粒级的供试炉渣,其中0.9~4 mm粒级占总量的64.54%。XRD、XRF分析显示,各粒级炉渣物相组成相似,<0.2 mm粒级炉渣中活性铝含量最高。静态吸附实验表明,炉渣对磷素的最大吸附量为4 021 mg/kg,最佳吸附时间为24 h;Langmuir和Freundlich吸附等温线可较好地拟合各粒级炉渣对溶液中磷素的吸附,而小于0.9 mm粒级炉渣具有更高的拟合度;炉渣粒径越小,吸附能力越强,<0.2 mm粒级炉渣的理论饱和吸附容量达14 084 mg/kg,≥6 mm粒级炉渣吸附磷素能力差;受粒径、溶液含磷浓度等因素影响,炉渣的平均理论吸附容量为1 142.4 mg/kg。     

Computational Fluid Dynamics (CFD) Simulations on the Effect of Rough Surface on Atmospheric Turbulence Flow Above Hilly Terrain Shapes

The behavioral distribution of the atmospheric turbulence flow over the terrain with changes in a rough surface has become one of the most important topics of air pollution research, among such other topics as transportation and dispersion pollutants. In this study, a computational model on atmospheric turbulence flow over a terrain hill shaped with rough surface was investigated under neutral atmospheric conditions. The flow was assumed to be 2D and modeled using computational fluid dynamics (CFD) models, which were numerically solved using Reynolds-averaged Navier-Stokes equations. Rough surface conditions were modeled using a number of windbreak fences regularly spaced on the hill. The mean velocity and turbulent structures such as turbulence intensity and turbulent kinetic energy were investigated in the upwind and downwind regions over the hill, and the numerical models were validated against the wind-tunnel results to optimize the turbulence model. The computational results agreed well with the results obtained from the wind tunnel experiments. The computational results indicate that the mean velocity was observed to increase dramatically around the crest of the upwind slope of the hill. A thick internal boundary layer was observed with a fence on the crest and downwind region of the hill. The reversed flow and recirculation zone were formed in the wake region behind the hill. It was thus determined that turbulent kinetic energy decreases as the mean velocity increases.     

内循环厌氧反应器多相流流场的三维数值分析简

利用数值模拟的方法,引入欧拉双流体多相流模型及标准k-ε紊流模型,模拟计算内循环厌氧反应器的三相流三维流场,并通过改变污泥颗粒密度及进水流量,针对固相流速及固含率的变化情况,分析条件的改变对流场的影响。研究结果表明,应用数值模拟方法可以获得内循环厌氧反应器内的流场特征;污泥颗粒密度及进水流量的改变对于反应器内污泥颗粒的流速及分布的均匀性有较为明显的影响。模拟结果对反应器的应用及优化设计具有一定的参考价值。     

连续流砂过滤器深度处理市政污水的中试研究

采用好氧/缺氧连续流砂过滤器中试实验研究深度处理北京某污水处理厂二级出水。实验结果表明,当连续流砂过滤器好氧段聚合氯化铝投量为20 mg/L,缺氧段碳源投量为32 mg/L时,COD、NH+4-N、TN和TP的平均去除率分别为34.77%、86.54%、66.94%和84.10%,最终出水均达到北京市新(改、扩)建城镇污水处理厂排放A标准(DB11/890-2012)。克隆文库法分析石英砂表面生物膜中的细菌群落结构表明,其优势菌群为β-proteobacteria,其中大部分能以废水中碳源为电子供体还原硝酸盐。     

Effects of cadmium on the activities of photosystems of Chlorella pyrenoidosa and the protective role of cyclic electron flow

Cadmium (Cd) shows high toxicity to aquatic microalgae. Many studies showed that Cd inhibited activities of photosystem II (PSII) but the effects of heavy metals on photosystem I (PSI) and cyclic electron flow (CEF) were still controversial and unclear. The effects of CdCl₂ on the activities of PSI, PSII and CEF in Chlorella pyrenoidosa was measured simultaneously in the present study. In presence of 200 μM of Cd, ultrastructure of some cells was strongly modified. Cd exposure led to decrease of the activities of photosynthetic oxygen evolution and respiration. PSII was more sensitive to Cd treatment than PSI. Cd treatment showed significant inhibition on the photochemical quantum yield and electron transport rate of PSII. Cd increased the quantum yield of non-light-induced non-photochemical fluorescence quenching, indicating the damage of PSII. The activity of PSI showed tolerance to Cd treatment with concentration less than 100 μM in the experiment. Linear electron flow (LEF) made significant contribution to the photochemical quantum yield of PSI of the untreated cells, but decreased with increasing Cd concentration. The contribution of CEF to the yield of PSI increased with increasing Cd concentration. The activation of CEF after exposure to Cd played an essential role for the protection of PSI.