Gasification of dried sewage sludge: status of the demonstration and the pilot plant

The disposal of sewage sludge from municipal waste water treatment plants is suffering from raising costs.The gasification is an alternative way of treatment, which can reduce the amount of solid residues that must be disposed from a water treatment plant. The produced gas can be used very flexible to produce electrical energy, to burn it very cleanly or to use it for upgrading.The gasification in the fluidised bed and the gas cleaning with the granular bed filter has shown successful operation. A demonstration plant in Balingen was set up in 2002 and rebuilt to a larger throughput in 2010. As a next step a demonstration plant was built in Mannheim and is now at the end of the commissioning phase. Nowadays the product gas is blended with biogas from sludge fermentation and utilized in a gas engine or combustion chamber to produce heat. In the future the process control for a maximized efficiency and the removal of organic and inorganic impurities in the gas will be further improved.     

三相生物流化床处理含油废水的试验研究

我国油田含油废水利用传统的隔油、混凝、过滤（老三套）处理工艺,出水指标达不到国家的二级排放标准。为提高含油废水处理水平,在“老三套”基础上添加了生物处理部分,即三相生物流化床。为强化生物处理,采取了投加漂浮填料和悬浮填料的强化处理措施,出水能达到国家二级排放标准。     

SAMPLING FRAME FOR IMPROVING PEBBLE COUNT ACCURACY IN COARSE GRAVEL‐BED STREAMS1

ABSTRACT: Improved sampling techniques are needed to increase the accuracy of pebble‐count particle‐size distributions used for stream studies in gravel‐bed streams. However, pebble counts are prone to operator errors introduced through subjective particle selection, serial correlation, and inaccurate particle‐size measurements. Errors in particle‐size measurements can be minimized by using a gravel template. Operator influence on particle selection can be minimized by using a sampling frame, 60 by 60 cm, in which sampling points are identified by the cross points of thin elastic bands. Serial correlation can be minimized by adjusting the spacing between the cross points and setting it equal to the dominant large particle size (=D₉₅). In a field test in a cobble‐bed stream, the sampling frame developed in this study produced slightly coarser size distributions, particularly in the cobble range, than the traditional heel‐to‐toe walk that selects particles with a blind touch at the tip of the boot. The sampling frame produced more similar sampling results between two operators than heel‐to‐toe walks. The difference between the two sampling methods is attributed to an unbiased selection of fine and coarse particles when using the sampling frame.     

常温循环流化床烟气脱硫床料的扫描电镜分析

用扫描电镜对循环流化床排烟脱硫实验装置的床料进行了分析研究,得出了床料的能谱图、床料中的元素百分含量以及床料的外观形貌。反应后床料硫含量的增加和反应后床料外缘所形成的一层氢氧化钙和硫酸盐膜说明流化床中的床料起了脱硫剂载体的作用,证实了循环流化床烟气脱硫装置中的脱硫反应。      

煤灰预处理-好氧生物技术处理有机废水的研究

介绍了煤灰预处理-好氧生物技术对有机废水的处理研究。结果表明,当有机废水中COD_Cr为1162mg/L,SS为382mg/L时,该技术对有机废水COD_Cr的去除率达96.9%,悬浮物的去除率达91.5%,处理废水的运行费用为0.22元/t。      

厌氧流化床反应器处理含硫废水毒性的实验

采用多孔聚合物载体固定化微生物在厌氧流化床（AFB）反应器中处理含硫废水,研究反应器抗硫化物（S^2－）毒性抑制和抗硫酸盐毒性抑制的能力;探索解除 S^2－毒性的方法．研究表明,当进料基质 COD浓度为 5000mg/L,HRT为5.2－5.4h,S^2－＜200mg/L时,反应器去除 COD效果不受影响,S^2－350mg/L时,厌氧消化受到明显抑制,反应器可容忍530mg/L S^2－浓度而未造成消化系统的破坏;SO₄^2－浓度高达3521mg/L,COD去除率仍可达77％－80％,但SO₄^2－去除率明显下降;当COD/SO₄^2－的比值大于1.45时,硫酸盐还原菌和产甲烷菌的生长未受到明显抑制,此时容积负荷为22－24kgCOD/（m³>·d）,COD去除率为80％,SO₄^2－去除率为58.8％;向反应器投加适量FeCl₂可很好地解除S^2－的抑制．     

喷消石灰脱除垃圾焚烧炉尾气中HCl和SO2的试验研究

在日处理200t进口流化床垃圾焚烧炉上,进行烟气喷水降温加上喷消石灰粉末脱除尾气中的酸性气体HCl和SO2的试验研究,HCl和SO2浓度由布袋除尘器出口的在线气体分析仪测得,结果表明HCl和SO2的去除率在Ca/Cl摩尔比等于9时分别为80%和20%,说明该法消石灰利用率较低,宜改为半干法脱除HCl和SO2酸性气体,以便降低吸收剂用量,提高运行的经济性.     

气-固流化床光催化氧化甲苯的研究

在自制的流化床光催化反应装置中研究了中低浓度(28~140mg/m3)甲苯的气相光催化降解过程,考察了光照时间、初始浓度、表观气速和催化剂负载量等因素对甲苯光催化降解率的影响规律。结果表明,紫外灯照射约1·5h,甲苯的转化率达最大值,甲苯初始浓度越低,维持此最大值的时间越久;在一定低浓度范围内(28~55mg/m3),甲苯的转化率不随浓度变化,符合一级反应动力学,浓度进一步增加,则甲苯的转化率下降;表观气速和催化剂负载量的最佳值分别为3·3Umf和0·19gTiO2/gSiO2。     

氮磷在阶式水生植物床中的去除效果及组成变化

利用串联运行的阶式水生植物床净化富营养化河水。考察了不同形态的氮磷在处理前后的浓度变化,在此基础上阐述水生植物床去除富营养化水体中氮磷的过程与机理。在水力负荷为74cm/d的条件下,总磷和总氮的去除率分别达73.1%和64.5%。植物根系对悬浮物的截留对去除河水中的氮磷起关键作用。采用多级串联的运行方式能有效克服一般湿地运行一段时间后因沉积物释放作用而引起处理水溶解性营养盐浓度上升的难题。     

HCl emission characteristics and BP neural networks prediction in MSW/coal co-fired fluidized beds

IntroductionWiththedepletionofspaceforlandfillingofmunicipalsolidwasteandtherisingpricesforrawmaterials ,moreandmorefluidizedbedincineratorshavebeenusedtotreatMSWduetotheprimaryadvantagesofhygieniccontrol,volumereductionandenergyrecovery .BecausetheMSWhas…