冶金高炉高温熔融处理垃圾飞灰

为了探讨冶金高炉处理垃圾飞灰的可能性,将一定量的垃圾飞灰作为造球原料通过快凝水泥固化制备冷固飞灰球团,模拟高炉温度、气氛条件对飞灰球团进行高温冶金性能实验研究,并采用X射线衍射仪对飞灰球团中物相变化进行了研究。结果表明:在造球原料里配入5%左右的飞灰通过水泥固化造出的球团能达到入炉要求;配入10%飞灰球团的高炉炉料的高温冶金性能变化不大,且能够保持高炉内的工作环境相对稳定,符合当前冶炼要求的炉内工程条件;在高温下飞灰中的重金属能有效还原固封,二恶英能有效分解,为垃圾飞灰的资源化处理开辟了新的途径。     

湿法烟气脱硫反应过程的实验研究

在石灰石/石膏湿法烟气脱硫中试台上,系统开展了浆液pH值、飞灰浓度、液气比、入口SO2浓度、烟气速度和氧化方式等对脱硫反应过程影响的实验研究。实验表明,脱硫效率随着石膏浆液pH值、液气比的升高而增加,且入口SO2浓度越高,液气比越低,影响效应越明显;脱硫效率随着烟气速度、烟气温度和入口SO2浓度的增加而下降;石膏浆液中飞灰含量对系统脱硫效率具有一定的促进作用:pH值>5.6,飞灰浸出液中Fe3+含量相对较低,Fe3+对脱硫反应过渡态催化氧化影响程度较轻,不同工况脱硫效率差别不大。pH值<5.6,飞灰浸出液中Fe3+含量随pH值降低而增大,增效效果逐渐显著;氧化方式对脱硫反应过程有明显的影响,强制氧化工艺的脱硫效率比自然氧化的高5%左右。     

Influence of arbuscular mycorrhizal fungi on the growth and nutrient status of bermudagrass grown in alkaline bauxite processing residue

A nursery experiment was conducted to evaluate the potential role of arbuscular mycorrhizal (AM) fungi in encouraging the vegetation cover on bauxite residue (red mud) sites. An alkali tolerant bermudagrass (Cynodon dactylon) adapted to local conditions were grown in red mud with different amendments with and without AM fungi to assess mycorrhizal effects on plant growth, mineral nutrition, metal uptake and neutralization of bauxite residue. Inoculation of AM fungi significantly increased the plant growth, nutrient uptake and reduced Fe, Al accumulation in plant tissue and also improved the soil physico-chemical and biochemical properties. Gypsum and sludge amended treatments inoculated with AM fungi had maximum biomass, nutrient uptake and reduced accumulation of metals. The neutralization of red mud was significant in presence of AM fungi than control. The experiment provided evidence for the potential use of bermudagrass in combination with AM fungi for ecological restoration of bauxite residue sites.     

粉煤灰合成NaX型分子筛的表征及其对Fe~（2＋）离子的吸附研究

以高温碱熔融处理粉煤灰合成了NaX型沸石分子筛,考察了不同水热晶化温度对产物结果的影响,用粉末XRD、XRF、SEM和FT-IR等手段对产品进行了表征,结果表明,以粉煤灰为原料用水热合成法合成微孔分子筛时,在晶化温度为90℃时能得到晶形较好的NaX型分子筛。同时考察了NaX分子筛的用量、时间和pH值等因素对Fe2＋离子的吸附影响,在25 mL Fe2＋离子浓度为2×103 mg/L的溶液中,当吸附剂用量为0.2 g,吸附时间为2 h,吸附效率达到最大值（36.41%）,而随着溶液pH值的升高其吸附效率显著增大。     

新型复合混凝吸附药剂对无铅皮蛋废水的处理

皮蛋废水水质相当复杂,既属于含重金属离子废水,又属于中等浓度含盐有机废水.针对皮蛋废水特点,采用混凝+吸附方法预处理皮蛋废水,将PAC与粉煤灰按2:5的投加比混合复制成一种新型复合混凝吸附剂,通过正交实验考察了复合药剂的较佳处理条件.结果表明,在投加量为5 g/L,pH为6.5左右,搅拌时间约为14 min,处理温度为...     

优选粉煤灰制备人工合成沸石及去除氨氮研究

7种粉煤灰样品的物理化学性质,如元素组成、结晶相组成、比表面积、灼失量、阳离子交换容量和pH得到表征。采用熔融法提取硅铝效率作为粉煤灰原料优选的依据,并通过L9（34）正交实验研究氢氧化钠投加量、熔融温度、氢氧化钠提取液浓度和体积对于硅铝提取效果的影响。结果表明,湿式除尘技术收集的低品位粉煤灰比电除尘技术所收集粉煤灰更...     

Compressive strength and resistance to chloride ion penetration and carbonation of recycled aggregate concrete with varying amount of fly ash and fine recycled aggregate

Construction and demolition waste has been dramatically increased in the last decade, and social and environmental concerns on the recycling have consequently been increased. Recent technology has greatly improved the recycling process for waste concrete. This study investigates the fundamental characteristics of concrete using recycled concrete aggregate (RCA) for its application to structural concrete members. The specimens used 100% coarse RCA, various replacement levels of natural aggregate with fine RCA, and several levels of fly ash addition. Compressive strength of mortar and concrete which used RCA gradually decreased as the amount of the recycled materials increased. Regardless of curing conditions and fly ash addition, the 28 days strength of the recycled aggregate concrete was greater than the design strength, 40 MPa, with a complete replacement of coarse aggregate and a replacement level of natural fine aggregate by fine RCA up to 60%. The recycled aggregate concrete achieved sufficient resistance to the chloride ion penetration. The measured carbonation depth did not indicate a clear relationship to the fine RCA replacement ratio but the recycled aggregate concrete could also attain adequate carbonation resistance. Based on the results from the experimental investigations, it is believed that the recycled aggregate concrete can be successfully applied to structural concrete members.     

Modeling batch leaching behavior of arsenic and selenium from bituminous coal fly ashes

Correctly predicting the leaching potential of arsenic (As) and selenium (Se) is critical for assessing the environmental impact of coal fly ash. This study investigated the impacts of several key environmental factors, including pH, leaching time, and ash washing on the batch leaching behavior of As and Se from bituminous coal fly ashes. The experimental results demonstrated that As and Se leaching from fly ash increased beyond the minimal leaching pH ranges. Increasing leaching time increased As leaching but decreased Se leaching in the alkaline pH condition. A speciation-based adsorption model was used to quantify the batch leaching data, and determine the intrinsic leaching parameters including the total batch leachable mass and the adsorption constant of As or Se. The modeling approach was validated by correctly predicting the independent batch leaching data in a broad pH range and a different L/S condition. Experimental and modeling results also demonstrated that ash washing and ash aging (longer leaching time) did not change the adsorption constants of As and Se on the ash surface. However, ash washing could increase the availability of As and Se for leaching.     

Utilization of washed MSWI fly ash as partial cement substitute with the addition of dithiocarbamic chelate

The management of the big amount of fly ash as hazardous waste from the municipal solid waste incinerator (MSWI) has encountered many problems in China. In this study, a feasibility research on MSWI fly ash utilization as partial cement substitute in cement mortars was therefore carried out. MSWI fly ash was subjected to washing process to reduce its chlorine content (from 10.16% to 1.28%). Consequently, it was used in cement mortars. Ten percent and 20% replacement of cement by washed ash showed acceptable strength properties. In TCLP and 180-day monolithic tests, the mortars with washed ash presented a little stronger heavy metal leachability, but this fell to the blank level (mortar without washed ash) with the addition of 0.25% chelate. Therefore, this method is proposed as an environment-friendly technology to achieve a satisfactory solution for MSWI fly ash management.     

生物质气化灰的肥效试验研究

通过试验对生物质气化发电的副产物--生物质气化灰的肥效进行研究.结果表明,在施肥量相同的条件下,添加生物质气化灰的试样,除黄瓜外,空心菜、油麦菜、樱桃萝卜、上海青试样的发芽时间都略早于单施化学肥料的试样; 后期长势也明显优于单施化学肥料的试样,叶片厚而有光泽; 前者在生长过程中没有虫害现象,后者有虫害现象.在生物质气化灰中添加氮、磷的试样比施单一肥料的试样长势好.研究表明,生物质气化灰具有替代钾肥的广阔市场前景.