Uptake of Ni2+ and rhodamine B by nano-hydroxyapatite/alginate composite beads: batch and continuous-flow systems

Alginate encapsulated nano-hydroxyapatite beads were synthesized and characterized by Fourier transform infrared spectroscopy, Brunauer–Emmett–Teller surface analysis, and X-ray diffraction. Their adsorptive potential for Ni²⁺ and rhodamine B was explored in batch mode and by fixed-bed column passage. In the batch system, maximum uptake capacity for Ni²⁺ was 360 mg g^?1 and 480 mg g^?1 for rhodamine B. In the presence of humic acid, sorption was enhanced. For the continuous-flow system, adsorption was effective at low flow rate. For both pollutants, mass transport resistance increased during adsorption. The overall rates of rhodamine B and Ni²⁺ uptake were found to be controlled by external mass transfer.     

一株好氧反硝化菌的筛选鉴定及固定化研究

从污水处理厂的活性污泥中筛选得到1株好氧反硝化细菌(YS),对其进行分子生物学鉴定和理化性能测试,并考察了该菌株固定化前后反硝化能力的变化.鉴定结果表明,菌株YS为反硝化产碱菌(Alcaligenes denitrificans).菌株经固定化后,其酶活力有所下降,但稳定性增强,在4 ℃下储存50 d后,固定态菌株对硝酸根的去除率仍可维持在80%以上,而游离态菌株仅为15%.在pH 7.0条件下,固定态菌株的反硝化率比游离态菌株低3%左右,但当pH降低至5.0时,固定态菌株对硝酸根的去除率为72.4%,比游离态菌株高2.6%,表明固定态菌株比游离态菌株更适应于弱酸的环境.在不同的工艺条件下,固定态菌株与游离态菌株反硝化能力的变化趋势相同.菌株YS的最适条件为:接种量1.5%左右,pH为6.0,C/N比为11,葡萄糖为碳源.     

海藻酸钠固定化污泥基生物质炭对铜的吸附性能研究

以城市污水厂的剩余污泥为原料制备生物质炭(SC),采用海藻酸钠加以固定使其成为污泥基生物质炭(SASC),通过正交试验确定SASC最佳制备工艺,考察吸附时间、铜离子的浓度、pH值、温度、转速、投加量对SASC吸附Cu~(2+)效果的影响。结果表明制备SASC的最佳条件是:海藻酸钠浓度为1.5%、包炭量为2%、CaCl_2浓度为1%、交联时间为0.5 h。在pH为5.0、温度为30℃、转速为150 r/min、投加量为0.24 g/mg、吸附时间为4 h的条件下Cu~(2+)去除率高达98.73%。SASC对Cu~(2+)的吸附机理服从准二级动力学方程,吸附等温线服从Freundlich方程,Cu~(2+)在SASC上的吸附为多层吸附。     

固定化三维电极-生物膜法去除污水中硝酸盐氮

本研究将固定化细胞技术用于三维电极-生物膜反应器的阴极微生物挂膜,对现有的三维电极-生物膜反应器进行了改进。同时,以城市污水二级生化处理系统的出水为研究对象,利用自制的固定化三维电极-生物膜反应器进行了反硝化深度脱氮试验。考察了电流强度、HRT、不同C/N值等因素对硝态氮和COD去除率的影响,并通过对比试验证实了固定化细胞技术的使用可提高反应器的反硝化性能。试验结果表明,在电流强度30mA,进水流量9mL/min时,COD的去除率为50%,硝态氮的去除率可达82.03%,反应器NO3--N负荷为0.297mg NO3--N(/cm2.d);同等操作条件下,采用固定化方法挂膜的反应器的脱氮效率可比普通反应器提高20%以上。     

固定化泛菌对底泥中孔雀石绿的降解

用2%海藻酸钠对孔雀石绿高效降解菌Pantoea sp.EF192586菌株进行固定化包埋,研究固定菌对底泥中孔雀石绿的降解情况。研究结果表明:固定菌对底泥中不同浓度孔雀石绿均有降解,且0.45和0.95μg/g干重降解率更好,达80%。增加固定菌的投菌量可提高降解速率和降解率,但当投菌量增至1.5g后降解率不再增加。泥水系统中水量减少可以提高固定菌起始阶段的降解速率。当固定菌和光照联合作用时可以提高降解率。     

CMC固定化烟曲霉活菌体小球中活性染料的解吸研究

考察了吸附在CMC(羧甲基纤维素纳)固定化烟曲霉活菌体小球中活性艳蓝KN-R和活性艳红K-2BP的解吸,并在此基础上提出了吸附-回收染料的技术思路。结果表明:pH值为12.0的75%乙醇对CMC固定化烟曲霉活菌体小球中的活性艳红K-2BP和活性艳蓝KN-R的解吸效果较好。30min内,对CMC固定化烟曲霉活菌体小球中的活性艳蓝KN-R和活性艳红K-2BP的解吸率分别为60.8%和50.4%。CMC固定化烟曲霉活菌体小球中的活性艳红K-2BP的解吸动力学符合一级指数衰减模型。CMC固定化烟曲霉活菌体小球能重复利用三次以上。     

Removal of ammonium-N from ammonium-rich sewage using an immobilized Bacillus subtilis AYC bioreactor system

A self-design bioreactor system employing a fixed bed operation process with immobilized Bacillus subtilis AYC beads for NH4 +-N removal from slightly polluted water was proposed. Polyvinyl alcohol and Na-alginate were used as a gel matrix to entrap Bacillus subtilis AYC to form the immobilized beads. The NH4 +-N removal process was studied in a intermittent operation mode to examine the start-up and steady state behaviors of the immobilized AYC in the reactor. The results indicated that the reactor was in the start-up state during the first week. NH4 +-N began to be steadily removal since the second week, and the nitrogen removal rate was between 84.61% and 96.19% when the hydraulic retention time (HRT) was 30 min. To apply Bacillus subtilis AYC to develop a practical nitrogen removal system and further understand its nitrogen removal ability, the bioreactor was continuously operated under different experimental perameters. The results showed that under the optimum conditions of an HRT of 20 min and DO of 3.77–5.80 mg/L, the NH4 +-N removal rate reached 99.55%. The NH4 +-N removal rate increased as the C/N ratio increased. However, a high C/N may cause a high residual carbon level in the effluent, therefore, the most suitable C/N ratio was 10. In addition, the results showed that the bioreactor system could remove many types of nitrogen such as NH4 +-N, NO3??-N and organic-N, and had a good performance for inorganic nitrogen removal from sewage.     

Nitrification characteristics of nitrobacteria immobilized in waterborne polyurethane in wastewater of corn-based ethanol fuel production

A technology to achieve stable and high ammonia nitrogen removal rates for corn distillery wastewater (ethanol fuel production) treatment has been designed. The characteristics of nitrifying bacteria entrapped in a waterborne polyurethane (WPU) gel carrier were evaluated after acclimation. In the acclimation period, nitrification rates of WPU-immobilized nitrobacteria were monitored and polymerase chain reaction (PCR) was also carried out to investigate the change in ammonium-oxidizing bacteria. The results showed that the pellet nitrification rates increased from 21 to 228 mg-N/(L-pellet. hr) and the quantity of the ammonia oxidation bacteria increased substantially during the acclimation. A continuous ammonia removal experiment with the anaerobic pond effluent of a distillery wastewater system was conducted with immobilized nitrifying bacteria for 30 days using an 80 L airlift reactor with pellets at a fill ratio of 15% (V/V). Under the conditions of 75 mg/L influent ammonia, hydraulic retention time (HRT) of 3.7--5.6 hr, and dissolved oxygen (DO) of 4 mg/L, the effluent ammonia concentration was lower than 10 mg/L and the ammonia removal efficiency was 90%. While the highest ammonia removal rate, 162 mg-N/(L-pellet.hr), was observed when the HRT was 1.3 hr.     

固定化微生物技术对养殖水体脱氮的研究进展

固定化微生物技术是一种有效去除养殖水体中氨氮等污染物质的生物处理新技术.对微生物固定化方法进行了分类,归纳了微生物固定化的主要特征以及反应器类型,讨论了影响微生物固定化的重要因素.综述了固定化微生物技术在养殖水体脱氮中国内外的研究现状,并针对相关问题提出了今后的研究和发展方向.     

一株低温高效植物油降解菌的驯化筛选及固定化研究

为了解决因低温而导致的废水中油脂难以处理的问题,从冬季重庆大学餐厅排污管道的底泥中分离出1株可低温降解植物油的菌株DJ-1。将此菌株多次驯化培养后,在5℃条件下利用其对含20g/L菜籽油复筛培养基的模拟含油废水进行处理。经过3 d处理,可去除废水中70.63%的植物油。经16S rDNA测序分析,该菌株为假单胞菌的一个未定种属(相似度为99%)。使用泥炭和木屑作为固定化载体,按照m(泥炭)∶m(木屑)∶m(菌液)=1∶4∶20的比例将扩培后的DJ-1菌剂制作成细菌固定化菌粉。在5℃条件下利用菌粉对含20 g/L菜籽油复筛培养基的模拟含油废水进行处理,菌粉投加量为0.15 g/L。经过3 d处理,废水中植物油的降解率达到77.34%,5 d后达到85.22%。