啤酒废水常温厌氧消化启动及运行实验

采用自行设计的复合式厌氧反应器在常温下对啤酒废水进行了厌氧发酵产沼气的实验研究,将进水COD控制在5 000 mg/L左右,采取逐步缩短HRT的方法来提高进水有机负荷,结果表明,启动运行41 d之后,产气量上升速度加快,反应器成功启动运行;在稳定运行过程中,随着负荷的升高,产气量呈阶梯式渐次上升,COD去除率保持在90%以上,出水pH值维持在7.0左右,TSS去除率达到60%以上,出水水质较好,说明该反应器具有较好的厌氧消化处理有机废水的能力。     

Biodegradation of endosulfan-contaminated soil in a pilot-scale reactor-bioaugmented with mixed bacterial culture

A novel mixed bacterial culture was enriched from an endosulfan (6, 7, 8, 9, 10, 10 – hexachloro-1, 5, 5a, 6, 9, 9a-hexahydro-6, 9-methano-2, 3, 4-benzo (e) dioxathiepin-3-oxide) processing industrial surface soil. The cultures were successful in the degradation of aqueous phase endosulfan in both aerobic and anaerobic conditions. Using the cultures, endosulfan degradation in silty gravel with sand (GM) was examined via pilot scale reactor at an endosulfan concentration of 0.78 ± 0.01 mg g^{? 1} of soil, and optimized moisture content of 40 ± 1%. During operation, vertical spatial variability in endosulfan degradation was observed within the reactor. At the end of 56 days, maximum endosulfan degradation efficiency of 78 ± 0.2% and 86.91 ± 0.2% was observed in the top and bottom portion of the reactor, respectively. Both aerobic and anaerobic conditions were observed within the reactor. However, endosulfan degradation was predominant in anaerobic condition and the total protein concentration in the reactor was declined progressively down the soil depth. Throughout the study, no known intermediate metabolites of endosulfan reported by previous researchers were observed.     

转盘液膜光电催化法处理罗丹明B的反应动力学

采用幂指数方程法建立了转盘液膜光电催化法降解罗丹明B(RhB)废水的动力学方程.结果表明,该反应动力学符合表观一级动力学.在考察的影响因素中,外加偏压对反应速率的影响最大,催化剂用量次之,其次是RhB初始浓度,转盘转速和光强度的影响相对较小.     

滚筒式生物反应器的设计及应力分析

针对城市生活垃圾好氧堆肥的处理工艺,设计一种用于好氧堆肥的滚筒式生物反应器。滚筒式生物反应器的设计主要包括主体结构设计,及反应器主体结构强度模拟分析。应用赫兹接触理论对支承装置中滚圈与托轮之间的接触应力进行计算。同时,结合ANSYS中不分离的接触方式模拟分析支承装置的接触应力,得出支承装置接触应力的分布规律,并将理论计算结果与ANSYS模拟结果进行对比。     

一体式A/O反应器中不同碳硫比对除碳脱臭效率的影响

在污水处理领域同步除碳脱臭研究一直是个难题,本实验开发了一种新型同步除碳脱臭一体式A/O反应器,研究了该一体式A/O反应器处理不同碳硫比有机废水时的同步除碳脱臭功能。结果表明,碳硫比为30∶1时,即进水SO24-浓度为133 mg/L,该反应器总COD去除率可达到95%。在进水SO24-浓度不大于400 mg/L时,中间产物臭气硫化氢气可以完全去除,实现了同步除碳脱臭的功能,减少了在有机废水处理过程中的大量臭气的排放。微生物学角度分析,表明污泥中含有大量的硫细菌。     

SBR处理高浓度养猪废水工艺条件

以养猪场废水作为研究对象,采用序列间歇式活性污泥法SBR,通过实验研究了供气量、pH、排泥量、原水稀释倍数、水力停留时间（HRT）对SBR出水水质的影响。结果表明,供气量为375 L/（min·m³）、pH为8.0,并添加排泥100 mL的操作,可使SBR处理效果明显提高,COD、磷和凯氏氮去除率最高分别可达96.37%、94.14%、99.38%。逐步降低进水稀释倍数有利于培养出处理高浓度有机养猪废水的活性污泥,可将平均COD、磷和凯氏氮含量高达9 161.24、33.41和1 502.77 mg/L的养猪废水处理至出水的490.11、5.35和17.84 mg/L。降低HRT对SBR去除率影响不大。     

UASB反应器反硝化处理对氨基二苯胺生产废水

采用UASB工艺处理橡胶助剂对氨基二苯胺（RT培司）生产废水。实验结果表明：UASB启动初期（1~16 d）,COD去除率由60.8%降至24.2% ,TOC去除率由75.6%降至37.2%;UASB运行16 ~50 d,COD去除率逐渐提高;运行50 d时COD去除率为69.4%,TOC去除率高达90.0%。在进水COD负荷不超过6 kg/（m³·d）的条件下,UASB对COD的去除率为42.7%~69.4%,TOC去除率为58.0%~90.0%,NO_{3^--N去除率接近100%。本实验最佳进水TOC 与TN 比为2.0,UASB进水pH可调节为4.5左右,反应温度为18~34 ℃时对UASB反硝化处理效果影响不大。UASB对苯系化合物的去除率从高至低顺序为对硝基酚>苯酚>苯胺。}     

印染废水水解酸化处理中填料式反应器与UASB反应器的比较

根据印染废水的特点和印染废水处理工程实例,从适用性、与其他工艺的衔接、工程造价、运行费用及水解效果等方面对UASB水解酸化反应器和填料式水解酸化反应器进行比较研究。研究表明,UASB水解酸化反应器在适用性和工程造价两个方面具有一定的缺陷;但是UASB水解酸化反应器对印染废水中COD、SS和色度去除率能够分别达到50%、73%和75%,明显高于填料式水解酸化反应器;且UASB水解酸化反应器每降解1 kg COD所需电量为(0.23±0.05)kW·h,优于填料式水解酸化反应器。     

Effects of a gradually increased load of fish waste silage in co-digestion with cow manure on methane production

This study examined the effects of an increased load of nitrogen-rich organic material on anaerobic digestion and methane production. Co-digestion of fish waste silage (FWS) and cow manure (CM) was studied in two parallel laboratory-scale (8 L effective volume) semi-continuous stirred tank reactors (designated R1 and R2). A reactor fed with CM only (R0) was used as control. The reactors were operated in the mesophilic range (37 °C) with a hydraulic retention time of 30 days, and the entire experiment lasted for 450 days. The rate of organic loading was raised by increasing the content of FWS in the feed stock. During the experiment, the amount (volume%) of FWS was increased stepwise in the following order: 3% – 6% – 13% – 16%, and 19%. Measurements of methane production, and analysis of volatile fatty acids, ammonium and pH in the effluents were carried out. The highest methane production from co-digestion of FWS and CM was 0.400 L CH4 gVS^?1, obtained during the period with loading of 16% FWS in R2. Compared to anaerobic digestion of CM only, the methane production was increased by 100% at most, when FWS was added to the feed stock. The biogas processes failed in R1 and R2 during the periods, with loadings of 16% and 19% FWS, respectively. In both reactors, the biogas processes failed due to overloading and accumulation of ammonia and volatile fatty acids.     

序批式膜生物反应器处理猪场沼液中氮的影响因素研究

猪场沼液具有高氨氮、低碳氮比(C/N)和脱氮难度大等特点,实验采用序批式膜生物反应器进行处理。结果表明,为达到较好的脱氮效果,进水COD宜控制在800~1 000mg/L;NH3-N为800mg/L时不会抑制硝化反应,C/N越高脱氮效果越好,C/N从8下降到1时,TN去除率由82.2%下降为16.7%;pH为8.5时脱氮效果最佳;夏天(进水水温25℃)脱氮效果优于冬天(进水水温13℃),TN去除率分别为93.13%、81.31%,进水水温在10~30℃时,进水水温越高脱氮效果越好。