曝气强化非离子表面活性剂洗涤法修复柴油污染土壤

采用异位修复法,利用非离子表面活性剂洗涤柴油污染土壤,并在洗涤过程中曝气强化。考察了洗涤效果的影响因素,并通过表面张力和接触角的测定探讨了洗涤机理。实验结果表明:曝气对污染土壤中柴油的洗脱有强化作用,可提高洗脱率10%~20%;3种非离子表面活性剂的洗脱效果优劣次序为聚氧乙烯月桂醚(Brij-35)曲拉通X-100(TX-100)吐温-80(Tw-80);在表面活性剂浓度为1倍临界胶束浓度、曝气量为7.5 L/min、洗涤时间为60 min、洗涤液pH为11.0的优化条件下,Brij-35对柴油的洗脱率达77.4%,污染土样的含油率从7.0%降至1.6%,接触角从24.12°降至6.65°,可基本恢复土壤的亲水性;洗涤液的表面张力随表面活性剂浓度的增加而降低,但不受洗涤液pH的影响。     

旋风除尘器筒体倾斜角的仿真与优化

旋风除尘器结构简单、造价低廉、能耗极低,故得以长期应用,但其除尘效率因设计方法比较粗糙一般在60%以下,从而限制了其使用范围。很多结构参数均影响除尘器的效率,其中除尘器筒体的倾斜角度对效率的影响程度最高。以有限元理论为基础,以Fluent软件为工具,对关于除尘效率与倾斜角度依赖关系进行了系列仿真和优化,得出结论:若空气中颗粒物直径大于2.5μm,除尘器倾斜角为12.4°时,其除尘效率理论上可达到97%以上。通过实验初步验证了上述结果的可信度。     

磨料浆液除锈机理的研究

本文将冲蚀机理引入金属除锈工艺。通过分析冲蚀的单元作用机理、冲击过程中能量平衡及影响冲蚀的诸因素，阐明了金属除锈的机理。利用刚性粒子冲击塑性材料的模型推导出了除锈效率较高的最佳射流入射角。在钢板除锈应用过程中先以９０°入射角冲击钢板，使钢板上的脆性表层很快形成赫兹裂纹，并且容易脱落，再以１６．４８°的入射角冲蚀钢板，效果理想。     

高效磁化斜板除油沉淀器技术的应用

介绍了济南第三炼钢厂高效磁化斜板沉淀器技术,实践表明,采用该工艺及技术,连铸水处理系统运行稳定,处理后悬浮物含量≤20mg/L,油含量≤5mg/L,可实现闭路循环,全部回用,无污水外排,操作管理方便、安全、能耗低,是一套成熟完善、经济合理的工艺技术.     

B级钢侧架圆角细节耐久性力学模型研究

根据Paris公式推导出适用于B级钢圆角细节耐久性分析的 ,在一定裂纹尺寸范围内的裂纹扩展速率公式及其检验方法 ,笔者模拟货车B级钢转 8A侧架的导框弯角内侧 (A区 )的圆角细部进行耐久性实验 ;以试验数据的检验证明 ,在 0 .4～ 4mm的尺寸范围内 ,选用的断裂力学模型是合理的 ;同时为建立合理的检修周期和寿命体系提供理论模型和安全评价基础。     

Airborne Dust Particle Counting Techniques

The paper briefly describes an electro-optical system for counting of dust particles, which is based on the scattering phenomena.Utilizing the scattering of light by various size particles present in the environment, various particle counting techniques have been developed in order to measure the scattered intensity of light. Light scatters in all directions but much more in the so-called near forward direction 17^∘ off axis, at 163^∘ from the light source in the visible range.On the basis of two techniques, the right angle and forward angle scattering, opto-mechanical systems have been developed which measure scattered intensity and particulate matter. The forward scattering Nephelometer is more sensitive and therefore is more suitable for pollution monitoring than the right angle scattering Nephelometer. Whereas the right angle scattering Nephelometer has the utility in extremely low concentration in ppb level owing to the excellent light trap efficiency in comparison to forward scattering Nephelometer. In this paper measurement techniques and measurement results associated with design and development of a real time particle analyser are also discussed.     

抽水蓄能电站输水系统斜井开挖施工安全管理

在抽水蓄能电站中斜井开挖施工历来是一个难点。为保证高水头,斜井段多数采用50°倾角,一般都较长。陡倾角长斜井施工由于施工环境特殊,施工难度大,存在诸多不安全因素。斜井开挖安全管理是施工过程中的全过程安全生产监督、检查管理、安全控制。     

Studying soil organic matter using 13C CP-MAS NMR: the effect of soil chemical pre-treatments on spectra quality and representativity

¹³C CP-MAS NMR spectroscopy is a technique that has proved to be useful in studying soil organic matter (SOM). Nevertheless, NMR spectra exhibit a weak signal and have very low resolution due to: the low natural abundance of ¹³C (1.1 % of C) in SOM, the generally low SOM content of soils, and the presence of paramagnetic impurities. This paper studies the effects of soil chemical pre-treatments on ¹³CP-MAS NMR spectra quality and spectra representativity i.e. soil C mass balance.

After chemical pre-treatment to increase total organic carbon (TOC) content and C/Fe ratio, eight soils characterized by different levels of organic carbon content and C/Fe ratios were studied using ¹³CP-MAS NMR. Moreover, where chemical treatments were not applicable due to high carbon losses, the number of ¹³CP-MAS NMR scans was increased in order to obtain satisfactory spectra.

Results show that chemical pre-treatment of soils with C/Fe > 1 caused high C losses. Bulk soils were therefore studied by increasing the number of ¹³CP-MAS NMR scans. Acceptable spectra were obtained from 8K scans (1K = 1024 transient). On the other hand, even when a large number of scan (32K) are used, soil with C/Fe < 1 cannot be studied. As these soils are characterized by low C losses after HCl treatments (range of 2.9–25.4%), a pre-treatment of at least 1.39 mol l⁻¹ HCl removes excess Fe and at the same time increases C/Fe ratio resulting in 32K scans providing good spectra.