铁尾矿地砖的制备及其机理分析

简要介绍了唐山地区铁矿尾矿制备铁尾矿砖的试验研究，并设计制备铁尾矿砖生产工艺流程和最佳配比。研究结果表明，以铁尾矿为主要材料，通过掺加适量的水泥、粉煤灰、粗骨料和一定的外加剂，经常温常压养护28天后，抗压强度可达到28．30MPa，抗折强度为5．63MPa，同时长期性能研究也表明可以制备出合格的铁尾矿地砖。为铁尾矿大量资源化利用辊供了一条新的徐径．同时还对铁尾砖的微观机理作了初步研究。     

内电解组合工艺处理重度富营养化水体的初步中试试验

采用催化铁内电解-沸石床-生物活性炭组合工艺进行了处理重度富营养化水的中试试验.通过对进水与出水浊度、TP、CODMn、UV254、总铁、NH3-N、和NO2--N的监测,研究了本组合工艺对重度富营养化水体的处理性能.试验期间,水温约在10℃.初步结果表明,本组合工艺对浊度、TP、CODMn和UV254均有较好的去除作用,平均去除率达到50%以上,出水中铁含量均低于进水.由于水温过低,未观察到氨氮和亚硝酸盐氮的明显变化.     

Biological pretreatment of Yellow River water

Bio-ceramic filter(BF) and moving-bed biofilm reactor(MBBR) were used for biological pretreatment of Yellow River water in this study. The BF only had slight advantage over MBBR for TOC and ammonia removal. However, like UV254, the average removal rate of THMFP in the BF was much higher than that in the MBBR. UV254 removal did not show obvious correlation with trihalomethane formation potential(THMFP) removal. Hexachlorocyclohexane could be effectively removed in both BF and MBBR. As for diatom and cyanobateria removal the MBBR had better performance than the BF, which was contrary to the average chlorophyll-a(Chl-a) removal rate. The proposal was made in this study that biological flocculation and sedimentation of sloughed biofilm should play a more important role on algae removal in the MBBR than in the BF. The BF and MBBR could effectively remove microcystins. Moreover, MBBR could be a promising technology for biological pretreatment.     

UBAF与纤维球过滤结合工艺应用于污水回用的试验研究

利用升流式曝气生物滤池 (UBAF)与纤维球过滤相结合的工艺对城市污水进行深度处理 ,使其达到回用的要求。结果表明 :对于经过二级处理后的可生物降解性较差的城市污水 ,应用UBAF和纤维球过滤相结合的处理工艺能够取得很好的效果 ,处理后的污水完全可以达到污水排放的一级标准和城市生活杂用水的标准     

造气含氰废水的生物治理

在塔式生物滤池生产性处理规模上考察了造气含氰废水在挂膜前后的处理效果。比较结果表明，未挂过氰化物的平均处理率仅为７９．２９％，挂膜后的处理率平均为９５．２６％，处理后的废水全部回用于生产，减少了氰化物的排放量，防止了造气废水对环境的污染。     

煤矿矿井水除铁技术

本文从煤矿矿井水中铁的来发布和存在形式入手，剖析了接触氧化过滤除铁的机理，从曝气充氧方式，滤料选择，反冲洗条件及其参数确定等方面介绍含铁矿井水接触氧化除铁的技术关键，并结合工程实际证明该工艺技术的可行性和可靠性。     

Effect of catalyzed diesel particulate filter and its catalyst loading on emission characteristics of a non-road diesel engine

In this study, the effects of a diesel oxidation catalyst (DOC) coupled with a catalyzed diesel particulate filter (CDPF) with different catalyst loadings on the power, fuel consumption, gaseous and particulate emissions from a non-road diesel engine were investigated. Results showed that the after-treatment had a negligible effect on the power and fuel consumption. The reduction effect of the DOC on the CO and hydrocarbon (HC) increased with the engine load. Further reductions occurred coupling with the CDPF. Increasing the catalyst loading resulted in a more significant reduction in the HC emissions than CO emissions. The DOC could increase the NO₂ proportion to 37.9%, and more NO₂ was produced when coupled with the CDPF below 250°C; above 250°C, more NO₂ was consumed. The after-treatment could reduce more than 99% of the particle number (PN) and 98% of the particle mass (PM). Further reductions in the PN and PM occurred with a higher CDPF catalyst loading. The DOC had a better reduction effect on the nucleation particles than the accumulation ones, but the trend reversed with the CDPF. The DOC shifted the particle size distribution (PSD) to larger particles with an accumulation particle proportion increasing from 13% to 20%, and the geometric mean diameter (GMD) increased from 18.2 to 26.0 nm. The trend reversed with the CDPF and the accumulation particle proportion declined to less than 10%. A lower catalyst loading on the CDPF led to a higher proportion of nucleation particles and a smaller GMD.     

唐钢一炼钢厂VD精炼炉直接冷却水系统设计

介绍了VD精炼炉直接冷却水处理常用的工艺流程及设计中应重点考虑的问题 ,如水处理单元的选择 ,供水泵与提升泵的匹配问题等     

Catalytic dechlorination of chlorobenzene in water by Pd/Fe bimetallic system

IntroductionChlorinatedorganiccompoundshavebeenusedonalargescaleinthechemical,petrochemical,andelectronicindustries.Inrecentyears ,worldwideattentionhasbeengiventotheenvironmentalandhealthimpactofthemasaclassofcontaminants .Severalareknowntocauseozonedepletion ,whileothersproduceadverseeffectsonthehumancentralnervoussystemandhavebeenlinkedtodiseasessuchascancer.Almostallofthechlorinatedaromaticcompoundsaretoxicandthermallystable .Oncereleasedintoenvironment,theywillaccumulateinthesurroundings…     

利用硫铁矿渣（灰）制取海绵铁

结合硫酸生产的特点，充分利用废热的方法，提出一种采用流态化技术，还原回收硫铁矿渣（灰）中铁元素的工艺流程，并对流程中的流态化还原炉进行了初步的物料，热理衡算，同时对该工艺流程技术经济比较作了小结。认为此工艺流程技术可靠，有直接经济效益，对综合利用硫铁矿渣（灰）中的铁元素，消除渣（灰）对环境的污染，有着深远的意义。