40吨转炉除尘水循环使用技术

承钢炼钢一厂4座40吨转炉采用湿法除尘,产量由20吨转炉改造扩产,但除尘水系统没有进行相应改造,系统能力一直不足,系统结垢严重。通过优化冷却水系统,进行适宜的水质稳定处理,解决了除尘水系统结垢问题。     

磁场对静态纳滤过程的膜通量及CaCO3结晶的影响

使用NF270型和NF型纳滤膜研究了经磁化预处理的钙溶液的静态纳滤过程,并与未经磁化预处理钙溶液的静态纳滤结果相比较.结果表明,当水样中Ca²⁺ 浓度为3.6 mmol/L,硬度等于碱度,初始水样体积为300 mL,体积浓缩倍数为2时,普通溶液的膜通量随滤出液体积呈现单调递减趋势;但处理磁化溶液时,膜通量随滤出液的体积先下降后上升,然后才下降,且平均膜通量比普通溶液的高,表明磁化预处理可以改善纳滤膜的部分操作性能.对膜的扫描电镜分析表明,处理磁化溶液的纳滤膜膜面上生成的晶体相对较多.综合纳滤膜通量和膜面晶体生成量的观察,认为磁场的引入可使膜表面结晶速率增加,致使膜面溶质浓度降低,通量上升,同时因生成的晶体全部留在膜面上,运行一段时间后有效膜面积减少,又导致通量下降.晶体生成量较多的膜,通量却相对较高,这与平常对膜污染的认识相矛盾.通过对结晶过程的理论分析,认为一定程度的结晶对膜操作性能有改善作用.     

新型膦磺酸阻垢缓蚀剂SEDMP的性能评定

对自制的新型膦磺酸阻垢缓蚀剂SEDMP对CaCO3和Ca3(PO4)2的阻垢性能进行评定。在SEDMP加入量为4 mg/L、浓缩至水溶液中Ca2+质量浓度为500 mg/L时,SEDMP对CaCO3的阻垢率为90.6%,对CaCO3的阻垢效果大大优于其他有机膦类阻垢剂。当SEDMP加入量为10 mg/L时,对Ca3(PO4)2的阻垢率为96.0%。SEDMP作为缓蚀剂单独使用时具有一定的缓蚀效果,与磺酸盐共聚物、锌盐复配后效果更佳。SEDMP与常用杀菌剂同时使用时仍可保持良好的对CaCO3的阻垢性能,且不影响杀菌剂的杀菌率。     

绿色阻垢剂聚天冬氨酸的制备与性能研究

采用马来酸酐与氨水进行溶液聚合的方法制备聚天冬氨酸,利用静态阻垢法评价了聚天冬氨酸的阻垢性能。结果表明:聚天冬氨酸对ρ(Ca2+)=300mg/L,ρ(HCO3-)=300mg/L的水样阻垢率可以达到90%以上;在ρ(HCO3-)低于400mg/L时,药剂的阻垢率可达到100%;当ρ(HCO3-)大于400mg/L后,药剂阻垢性能降低明显。聚天冬氨酸具有良好的生物降解性,生物降解率可以达到70%。     

Assessment and mapping of environmental quality in agricultural soils of Zhejiang Province, China

Heavy metal concentrations in agricultural soils of Zhejiang Province were monitored to indicate the status of heavy metal contamination and assess environmental quality of agricultural soils. A total of 908 soil samples were collected from 38 counties in Zbejiang Province and eight heavy metal （Cd, Cr, Pb, Hg, Cu, Zn, Ni and As） concentrations had been evaluated in agricultural soil. It was found 775 samples were unpolluted and 133 samples were slightly polluted and more respectively, that is approximately 14.65% agricultural soil samples had the heavy metal concentration above the threshold level in this province by means of Nemerow＇s synthetical pollution index method according to the second grade of Standards for Soil Environmental Quality of China （GB15618- 1995）. Contamination of Cd was the highest, followed by Ni, As and Zn were lower correspondingly. Moreover, Inverse Distance Weighted （IDW） interpolation method was used to make an assessment map of soil environmental quality based on the Nemerow＇s pollution index and the soil environmental quality was categorized into five grades. Moreover, ten indices were calculated as input parameters for principal component analysis （PCA） and the principal components （PCs） were created to compare environmental quality of different soils and regions. The results revealed that environmental quality of tea soils was better than that of paddy soils, vegetable soils and fruit soils. This study indicated that GIS combined with multivariate statistical approaches proved to be effective and powerful tool in the mapping of soil contamination distribution and the assessment of soil environmental quality on provincial scale, which is beneficial to environmental protection and management decision-making by local government.     

湿式高效除尘脱硫装置的试验研究

本文介绍了一种高效除尘脱硫装置三相流化床的性能和原理，并对三相流化床除尘脱硫工业中试系统的试验结果进行了分析。试验表明三相流化床除尘效率可达９５６脱硫效率达７０％，运行安全可靠。     

国际土地利用/覆盖变化模型研究综述

国际上对土地利用/覆盖变化的研究由来已久,近年由于土地利用/覆盖变化对全球变化的贡献及响应,预测土地利用/覆盖变化成为必然。由此,越来越多的科学家致力于研究土地利用/覆盖变化模型,并取得了积极进展。论文介绍了目前国际上土地利用/覆盖变化模型的一些相关问题:①土地利用/覆盖变化模拟的尺度依赖性;②土地利用/覆盖变化模拟的数据问题;③预测土地利用/覆盖变化的位置与数量。回顾了已有的5种主要的土地利用/覆盖变化模型:①基于行为者的土地利用/覆盖变化模型;②经验统计模型;③最优化模型;④混合/综合模型;⑤动力模拟模型。最后总结了现有模型中存在的问题,并探讨了今后土地利用/覆盖变化模型发展的方向。     

生物堆修复城市多环芳烃污染土壤的调控研究

土壤多环芳烃(PAHs)污染已成为一种严重的全球性城市环境问题。以通风时间、绿肥、无机营养剂和疏松剂含量为调控因素,利用现场规模的正交试验进行了生物堆修复城市多环芳烃污染土壤的调控研究。结果表明,所有生物堆处理对土壤PAHs的去除均有一定促进作用,75 d时平均降解率为30.63%~80.41%,且深层土壤降解率比表层土壤高8.55%;运行期间各调控因素对不同深度土壤PAHs降解的影响程度和作用规律各不相同,其中通风时间始终是主导因素,且通风时间越长,降解效果越好;生物堆的最佳运行条件总体上为通风时间3 h、绿肥3.5%、营养剂0.2%、疏松剂18%(表层土壤)或14%(深层土壤)。因此,利用生物堆修复城市PAHs污染土壤是有效的,且增加通风时间是提高其修复效率的优先调控方式。     

Feasibility and simulation model of a pilot scale membrane bioreactor for wastewater treatment and reuse from Chinese traditional medicine

The lack and pollution of water resource make wastewater reuse necessary. The pilot scale long-term tests for submerged membrane bioreactor were conducted to treat the effluents of anaerobic or aerobic treatment process for the high-strength Chinese traditional medicine wastewater. This article was focused on the feasibility of the wastewater treatment and reuse at shorter hydraulic retention time （HRT） of 5.0, 3.2 and 2.13 h. MLSS growth, membrane flux, vacuum values and chemical cleaning periods were also investigated. The experimental results of treating two-phase anaerobic treatment effluent demonstrated that the CODfilt was less than 100 mg/L when the influent COD was between 500-10000 mg/L at HRT of 5.0 h, which could satisfy the normal discharged standard in China. The experimental results to treat cross flow aerobic reactor effluent demonstrated that the average value of CODfilt was 17.28 mg/L when the average value of influent COD was 192.84 mg/L at HRT of 2.13 h during 106 d, which could completely meet the normal standard for water reuse. The maximum MLSS and MLVSS reached 24000 and 14500 mg/L at HRT of 3.2 h respectively. Membrane flux had maximal resume degrees of 94.7% at vacuum value of 0.02 MPa after cleaning. Chemical cleaning periods of membrane module were 150 d. A simulation model of operational parameters was also established based on the theory of back propagation neural network and linear regression of traditional mathematical model. The simulation model showed that the optimum operational parameters were suggested as follows： HRT was 5.0 h, SRT was 100 d, the range of COD loading rate was between 10.664-20.451 kg/（m3.d）, the range of MLSS was between 7543-13694 mg/L.     

燃煤火电厂闭路除灰系统结垢及其防治的研究现状

对燃煤火电厂闭路除灰系统结垢及其防治的研究现状进行了叙述和分析，对该领域的研究和发展动向提出了自己的见解