气-水联合反冲洗膜污染防治技术研究

采用气水联合反冲洗技术,考察了气水比(Qg/Ql)、反冲洗周期及其对膜污染的防治效果。结果表明,气水联合反冲洗较单独气或水反冲洗效果好;在过滤周期20min,反冲洗时间1min,气水比1.5时,气水联合反冲洗能够恢复膜通量到膜清水通量的80%以上。此法可大幅度清除沉积在膜表面的泥饼层,恢复膜通量,维持膜过滤性能的稳定,是一种较为有效的膜污染防治技术。     

Investigation on the influence of methanol on adsorption and leaching of pesticides with soil column liquid chromatography

The effect of methanol of low concentration on adsorption and leaching of atrazine and tebuconazole was studied in this paper. The adsorption coefficients and the retardation factors (R^m) of pesticides on EUROSOIL 3# log-linearly decreased as volumetric fraction of methanol (f^c) was increased in the binary solvent mixtures of methanol and water. These data are consistent with solvophobic theory formerly outlined for describing the adsorption and transport of hydrophobic organic chemicals from mixed solvents. Nevertheless, the adsorption of these pesticides in soil–water system slightly increased when the soil was pre-washed with methanol in comparison with that pre-washed with water (pure water system). Furthermore, their adsorption coefficients were still higher in binary solvent systems with methanol of very low concentrations, i.e. f^c<0.03 for atrazine and f^c<0.01 for tebuconazole, than those in pure water system. The adsorption coefficients (logK^w) of atrazine and tebuconazole predicted by solvophobic theory were 0.5792 and 1.6525, respectively, and their experimental logK^w were 0.3701 and 1.6275 in pure water system. Obviously, the predicted logK^w of the two pesticides was higher than the experimental log K^w in pure water system. The predicted K^w and the retardation factor (R^w) in pure water system by solvophobic theory are thus possibly inaccurate.     

Fenton试剂在乳化液废水处理中的应用

用Fenton试剂处理乳化液废水，通过试剂在不同配比条件下对废水处理效果的实验比较，选择了最佳反应条件，废水处理后的COD测量结果表明，反应处理在实验室可行。     

可张孔曝气器曝气能耗试验研究

通过试验研究,总结出可张孔曝气阻力损失的影响因素,以优化产品的结构设计参数,降低产品在工程应用中的能耗,获取更好的经济效益。     

粉末活性炭对膜过滤性能的影响

向一体式膜生物反应器中投加粉末活性炭(PAC),可以显著提高膜的过滤性能,有效缓解膜的污染.研究结果表明:投加PAC的吸附作用减少了由于胞外聚合物(EPS)而引起的膜污染;膜表面PAC颗粒的存在减小了浓差极化层的厚度和水力边界层的厚度,提高了过滤物质的传递速率;膜表面形成的PAC层还可过滤微生物和胶体颗粒,减少了它们到达膜表面的数量.     

厌氧平板膜生物反应器连续处理猪场废水研究

本研究以实际猪场废水为原料,在中温（37±1）℃条件下利用浸没式平板膜生物反应器进行180d连续厌氧发酵试验,以水力停留时间5,3和2d的梯度变化逐渐增加容积负荷,研究反应器运行性能,污泥比产甲烷活性,膜过滤特性和膜的清洗效果.试验结果表明,随水力停留时间的缩短,反应器的容积产沼气率分别达到0.68,1.03和1.12L/（L·d）,稳定运行期间出水的总挥发性脂肪酸分别为（169±41）mg/L,（15±3）mg/L和（114±45）mg/L,以乙酸为主.反应器中厌氧污泥的乙酸比产甲烷活性测试表明,以2000mg/L的乙酸为基质,HRT 3d时具有最大比产甲烷活性1.127g-COD/（g-VSS·d）.本试验发生膜污染的周期约4个月.采用2%的柠檬酸浸泡3h,可以恢复膜的过滤性能.在较低通量下,反应器中7~32g/L的污泥浓度并不会明显的影响平板膜的过滤性能.本研究结果显示,厌氧膜生物反应器有处理猪场废水的可能性.     

Performance and fouling mechanism of direct contact membrane distillation (DCMD) treating fermentation wastewater with high organic concentrations

In this study,direct contact membrane distillation(DCMD)was used for treating fermentation wastewater with high organic concentrations.DCMD performance characteristics including permeate flux,permeate water quality as well as membrane fouling were investigated systematically.Experimental results showed that,after 12 hr DCMD,the feed wastewater was concentrated by about a factor of 3.7 on a volumetric basis,with the permeate flux decreasing from the initial 8.7 L/m~2/hr to the final 4.3 L/m~2/hr due to membrane fouling;the protein concentration in the feed wastewater was increased by about 3.5 times and achieved a value of 6178 mg/L,which is suitable for reutilization.Although COD and TOC in permeate water increased continuously due to the transfer of volatile components from wastewater,organic rejection of over 95%was achieved in wastewater.GC–MS results suggested that the fermentation wastewater contained 128kinds of organics,in which 14 organics dominated.After 12 hr DCMD,not only volatile organics including trimethyl pyrazine,2-acetyl pyrrole,phenethyl alcohol and phenylacetic acid,but also non-volatile dibutyl phthalate was detected in permeate water due to membrane wetting.FT-IR and SEM–EDS results indicated that the deposits formed on the membrane inner surface mainly consisted of Ca,Mg,and amine,carboxylic acid and aromatic groups.The fouled membrane could be recovered,as most of the deposits could be removed using a HCl/Na OH chemical cleaning method.     

悬浮填料对厌氧氨氧化MBR运行的影响特性及机理

向厌氧氨氧化（anammox）膜生物反应器（MBR）投加悬浮填料,考察其对反应器脱氮性能和膜污染的影响特性,并探究了相关机理.试验结果表明,投加填料后,反应器脱氮性能良好.当进水氨氮（NH₄⁺-N）160mg/L、亚硝态氮（NO₂^--N）180mg/L时,出水NH₄⁺-N和NO₂^--N均在15mg/L以下,硝态氮（NO₃^--N）在30mg/L以下,总氮去除率可达90%.投加填料显著减轻了膜污染,跨膜压差（TMP）稳定在8kPa左右.混合液中溶解性微生物产物（SMP）和胞外聚合物（EPS）成分分析结果表明,在第67~149d,蛋白质总量、多糖总量和总有机碳总量分别下降了49%、43%和61%,它们浓度的下降有利于延缓膜污染;此外,悬浮填料对膜组件的机械碰撞也起到了物理清洗作用.高通量测序结果显示,悬浮填料生物膜在anammox菌相对丰度方面显著高于混合液污泥,说明anammox菌更适宜于附着生长,投加填料可以为其提供更加稳定的生长环境.     

基于BP神经网络的二元混合液体自燃温度预测

为了给工业界提供一种快速预测二元混合液体自燃温度的有效途径,将试验所测不同组分及配比的168个二元混合液体的自燃温度作为期望输出,将基于电性拓扑状态指数(ETSI)理论、引入混合ETSI概念而计算出的9种原子类型所对应的混合ETSI作为输入,采用三层BP神经网络技术建立了根据原子类型混合ETSI来预测混合液体自燃温度的BP神经网络模型,并应用改进的Garson算法进行多参数敏感性分析。经模型评价验证及稳定性分析,得到训练集的决定系数R2为0.965,平均绝对误差MAE为11.892 K,测试集的交叉验证系数Q2ext为0.923,平均绝对误差MAE为15.530 K,发现该模型的预测性能优于已有的多元非线性回归(MNR)模型,表明BP神经网络模型具有较好的拟合能力和预测能力,对烷、醇类混合体系自燃温度的预测精度最佳。     

在沸石对高放废液水泥固化体中Cs~+浸出率的影响

文章主要研究模拟高放废液加入沸石预处理经碱矿渣水泥固化后Cs+的浸出性能。实验结果表明,处理含Cs+高放废液固化体中加入沸石,能使Cs+浸出率降低";两步法"掺入沸石固化体抗Cs+浸出性能更有所提高;pH值升高Cs+的吸附比增大。