Experimental investigation on the effect of liquid phase and vapor phase separation over performance of falling film evaporator

Energy, cost, and environmental concerns play a vital role in understanding governing parameters of distributor design in falling film evaporators. Distributor design is a hidden parameter in many experimental papers. The uniform distribution of liquid refrigerant over the tube bundle mostly depends on two-phase liquid refrigerant and vapor refrigerant. This work conducted experiments with two distribution systems with and without separation of liquid-vapor refrigerant after expansion valve for the same evaporator capacity with R134a as a refrigerant. Results reveal that; separating vapor refrigerant has a positive impact on the approach of the evaporator with an open system distributor arrangement. The highest delta T and lowest practice are found at a heat flux of 13.97 kW/m² with an available system distributor compared to a closed system with a heat flux of 14.25 kW/m². The open system arrangement in the distributor is the novel parameter for distributor design, ensuring uniform distribution with minimum pressure drop and dry suction. An open system distributor has an average 16.1% capacity increase over a closed system. The experimental analysis helps to understand different parameters for the design of distributors in falling film evaporators for uniform distribution.     

旋流气浮除油装置预处理含油污水

在河南油田开展旋流气浮除油装置的现场试验,考察进水流量和曝气量对旋流气浮除油装置除油效果的影响。试验结果表明:在进水流量为1.8 m³/h、曝气量为0.5 L/min时,除油率最高达到96.03%;在不添加任何药剂的条件下,装置处理效果稳定;连续运行6 d内,进水含油量为174.57~1 193.15 mg/L时,出水含油量可以保持在137.38 mg/L以下,除油率为58.58%~94.53%。     

纳滤膜分离技术在安全饮用水保障中的应用

纳滤膜分离技术在饮用水制备方面具有独特的作用,是保障安全饮用水生产的有效方法。本文详细综述了国内外纳滤膜技术在饮用水生产中应用研究的最新进展,以及纳滤膜对地表水或地下水中存在的各种无机、有机污染物的分离特性。     

Remediation of arsenic contaminated soil by sulfidated zero-valent iron

• Sulfidation significantly enhanced As(V) immobilization in soil by zerovalent iron. • S-ZVI promoted the conversion of exchangeable As to less mobile Fe-Mn bound As. • Column test further confirmed the feasibility of sulfidated ZVI on As retention. • S-ZVI amendment and magnetic separation markedly reduced TCLP leachability of As. In this study, the influences of sulfidation on zero-valent iron (ZVI) performance toward As(V) immobilization in soil were systemically investigated. It was found that, compared to unamended ZVI, sulfidated ZVI (S-ZVI) is more favorable to immobilize As(V) in soil and promote the conversion of water soluble As to less mobile Fe-Mn bound As. Specifically, under the optimal S/Fe molar ratio of 0.05, almost all of the leached As could be sequestrated by>0.5 wt.% S-ZVI within 3 h. Although the presence of HA could decrease the desorption of As from soil, HA inhibited the reactivity of S-ZVI to a greater extent. Column experiments further proved the feasibility of applying S-ZVI on soil As(V) immobilization. More importantly, to achieve a good As retention performance, S-ZVI should be fully mixed with soil or located on the downstream side of As migration. The test simulating the flooding conditions in rice culture revealed there was also a good long-term stability of soil As(V) after S-ZVI remediation, where only 0.7% of As was desorbed after 30 days of incubation. Magnetic separation was employed to separate the immobilized As(V) from soil after S-ZVI amendment, where the separation efficiency was found to be dependent of the iron dosage, liquid to soil ratio, and reaction time. Toxicity characteristic leaching procedure (TCLP) tests revealed that the leachability of As from soil was significantly reduced after the S-ZVI amendment and magnetic separation treatment. All these findings provided some insights into the remediation of As(V)-polluted soil by ZVI.     

磁性铁基改性生物炭去除水中氨氮

氨氮的过度排放是水体富营养化的一个重要原因.然而,随着环境法规的日益严格,传统方法处理效果难以达到要求.吸附法因高效、安全等优点近年来开始应用于去除水中的氨氮.本研究中以共沉淀法将磁性铁基材料负载到市政污泥生物炭上,结果表明其对水中氨氮有良好的去除效果.80℃下合成的材料（MB₈₀）在293 K下对氨氮的饱和吸附量可达17.52 mg·g^-1.动力学与热力学结果表明,MB₈₀吸附氨氮的过程更符合伪二级动力学和Langmuir等温线.MB₈₀对氨氮的吸附机制可归纳为静电吸引、孔隙填充、离子交换和氢键结合.且5次循环后对氨氮的吸附量仍十分理想,可达3.18 mg·g^-1.本研究的结果可以为高效去除水中氨氮提供一种行之有效的方法,并为市政污泥的处理提供新的出路.     

套管损伤磁记忆检测信号定量研究

在油气生产过程中,井下套管损伤会造成井况恶化,致使正常井转变为套损井。为了防止套损井的出现和安全事故的发生,有必要对套管进行早期损伤检测。采用金属磁记忆检测技术,开展了实验研究。实验中,通过对套管内壁环切,将套管壁厚设计为等值递增和不等值递增两种形式;根据实验数据,对磁记忆检测信号梯度值、信号梯度波峰值及信号梯度峰宽值等特征参量与壁厚、壁厚变化量的定量关系进行拟合。结果表明:磁记忆检测信号梯度值、信号梯度波峰值及信号梯度峰宽值等特征参量,可以很好的表征套管壁厚的变化情况;信号梯度值与套管壁厚呈线性递增关系;信号梯度波峰值和信号梯度峰宽值均与套管壁厚变化量呈线性递增关系。该试验结果有助于完善磁记忆检测技术的定量化研究和利用磁记忆原理检测套管损伤的评价体系。     

可变径管道漏磁检测有限元仿真与实验研究

为了更好地支持压力管道检验,降低事故率,本文基于漏磁检测原理,利用有限元分析软件建立了管道外漏磁检测模型,对管道漏磁检测进行了仿真计算,得到了缺陷处漏磁场特征曲线,模拟了圆柱形缺陷对管道外壁漏磁场的影响,得出了不同参数缺陷对漏磁场的影响规律,并且基于理论和有限元计算结果试制了可变径管道外漏磁检测仪的样机,利用该检测仪对壁厚为8mm的带有人工缺陷的管道进行扫描检测,研究不同参数缺陷对漏磁场信号的影响规律。结果表明,所得结果与有限元仿真的结果吻合良好,且缺陷检测精度及效果满足要求,另外,检测装置对内外壁缺陷检测同样可行有效,适合特种设备（压力管道）检测的工程应用。     

Preconcentration of cadmium and copper ions on magnetic core–shell nanoparticles for determination by flame atomic absorption

Magnetic core–shell nanoparticles modified by (3-aminopropyl) trimethoxy silane were prepared and used as adsorbent for the extraction and preconcentration of cadmium and copper ions. The ions were desorbed with nitric acid followed by determination with flame atomic absorption spectrometry. The extraction conditions were investigated systematically. The method was applied for the determination of Cd(II) and Cu(II) ions in different water samples. The accuracy was also evaluated through analysis of certified reference material.     

磁载纳米TiO2复合光催化材料的研究进展

磁载纳米TiO2复合光催化剂是一种无污染,制备成本低,催化活性高,在外加磁场下可迅速分离回收和重复使用的光催化材料,在废水的光催化降解中有着诱人的应用前景.本文综述了不同类型磁载纳米TiO2复合光催化材料的制备方法和光催化性能,总结了其在染料、农药、芳香烃及其衍生物、有害无机离子和有毒气体等各种环境污染物处理中的应用,并展望了磁载纳米TiO2复合光催化剂的发展方向.     

用高精度磁测圈定煤田自燃区的应用效果

煤田自燃在中国北方非常普遍,每年都给中国的煤炭资源以及生态环境造成重大损失。为控制和监测煤田自燃,须对其自燃边界进行圈定。煤层自燃后产生“热剩磁”,基于这一理论,运用高精度磁测圈定了西北某煤田自燃区的边界范围,并建立了“倾斜磁化有限延伸的板状体”模型进行正演。由钻孔验证的结果来看,高精度磁测圈定煤田自燃区边界范围的应用效果良好。