乳状液膜分离法预处理垃圾渗滤液氨氮的试验研究

用span-80表面活性剂制作的乳状液处理垃圾渗滤液中氨氮,考察了表面活性剂span-80用量、膜内相硫酸浓度、膜增强剂用量、油内比、乳水比、外相水pH值因素对氨氮去除率的影响。结果表明,在最佳反应条件下,用乳状液膜分离法预处理垃圾渗滤液中的氨氮,分离速度快,处理效果达到87%以上。     

Pollutants removal and simulation model of combined membrane process for wastewater treatment and reuse in submarine cabin for long voyage

A laboratory scale test was conducted in a combined membrane process (CMP) with a capacity of 2.91 m3/d for 240 d to treat the mixed wastewater of humidity condensate, hygiene wastewater and urine in submarine cabin during prolonged voyage. Removal performance of chemical oxygen demand (COD), ammonia nitrogen (NH4 +-N), turbidity and anionic surfactants (LAS) was investigated under di erent conditions. It was observed that the e uent COD, NH4 +-N, turbidity and LAS flocculated in ranges of 0.19–0.85 mg/L, 0.03–0.18 mg/L, 0.0–0.15 NTU and 0.0–0.05 mg/L, respectively in spite of considerable fluctuation in corresponding influent of 2120–5350 mg/L, 79.5–129.3 mg/L, 110–181.1NTU and 4.9–5.4 mg/L. The e uent quality of the CMP could meet the requirements of mechanical water and hygiene water according to the class I water quality standards in China (GB3838-2002). The removal rates of COD, NH4 +-N, turbidity and LAS removed in the MBR were more than 90%, which indicated that biodegradation is indispensable and plays a major role in the wastewater treatment and reuse. A model, built on the back propagation neural network (BPNN) theory, was developed for the simulation of CMP and produced high reliability. The average error of COD and NH4 +-N was 5.14% and 6.20%, respectively, and the root mean squared error of turbidity and LAS was 2.76% and 1.41%, respectively. The results indicated that the model well fitted the laboratory data, and was able to simulate the removal of COD, NH4 +-N, turbidity and LAS. It also suggested that the model proposed could reflect and manage the operation of CMP for the treatment of the mixed wastewaters in submarine.     

When signal meets noise: immunity of the frog ear to interference

Sound stimulates the tympanic membrane (TM) of anuran amphibians through multiple, poorly understood pathways. It is conceivable that interactions between the internal and external inputs to the TM contribute to the nonlinear effects that noise is known to produce at higher levels of the auditory pathway. To explore this issue, we conducted measurements of TM vibration in response to tones in the presence of noise in the frog Eupsophus calcaratus. Laser vibrometry revealed that the power spectra (n = 16) of the TM velocity in response to pure tones at a constant level of 80 dB sound-pressure level (SPL) had a maximum centered at an average frequency of 2,344 Hz (range 1,700–2,990 Hz) and a maximum velocity of 61.1 dB re 1 μm/s (range 42.9–66.6 dB re 1 μm/s). These TM-vibration velocity response profiles in the presence of increasing levels of 4-kHz band-pass noise were unaltered up to noise levels of 90 dB SPL. For the relatively low spectral densities of the noise used, the TM remains in its linear range. Such vibration patterns facilitate the detection of tonal signals in noise at the tympanic membrane and may underlie the remarkable vocal responsiveness maintained by males of E. calcaratus under noise interference.     

低温时污泥膨胀对MBR中膜污染的影响

通过一体式膜生物反应装置考察了在低温条件下发生污泥膨胀过程中反应器的运行效果和膜污染的情况,并从微生物角度分析了引起膜污染的因素.结果表明,低温时COD上清液和出水平均去除率分别为85%和92%,发生丝状菌污泥膨胀后去除率变化不大.MBR中丝状菌污泥膨胀形成的过程中,污泥沉降性变差,丝状菌丰度（FI）由2增加到5,丝状菌伸出絮体形成网状结构.低温时膜操作压力随时间呈直线变化,膜组件的水力清洗周期为15 d.在丝状菌大量繁殖时缩短到7 d,膜污染严重.通过测定活性污泥的特性,发现膨胀污泥的胞外聚合物（EPS）总量是正常污泥的3倍,污泥絮体相对疏水性（RH）随FI的提高而增大.EPS和RH增大后会引起更多物质沉积到膜表面,使膜污染速率提高,膜的运行周期变短.进一步的分析表明,混合液粘度、Zeta电位、污泥絮体形态也是影响膜污染的因素.     

泥水预分离MBR膜污染缓减效能研究

通过长期运行实验,进行了泥水预分离膜生物反应器（sludge/water pre-separation membrane bioreactor, S/W-MBR）与传统淹没式膜生物反应器（submerged membrane bioreactor, SMBR）对比研究,考察了污泥浓度、胞外聚合物含量（extracellular polymeric substances, EPS）及过膜阻力（trans-membrane pressure, TMP）随运行时间的变化规律及其对膜污染的缓减作用.结果表明,S/W-MBR与SMBR生物区的污泥浓度基本一致,而S/W-MBR膜区的污泥浓度较SMBR有显著降低.两者生物区的EPS含量均随运行时间的延长而增加,而S/W-MBR膜区的单位质量污泥的EPS含量始终保持在15 mg/g左右的较低水平.S/W-MBR比SMBR具有更好的缓减膜污染能力,在近90d的连续运行过程中,前者的膜组件仅需清洗2次,后者的膜组件清洗了5次.     

膜生物反应器亚硝化性能的影响因素研究

利用膜生物反应器成功启动了亚硝化工艺处理人工合成废水.为了确定影响亚硝化工艺效果的因素,先后对温度和溶解氧浓度进行了研究,结果表明,在温度35℃并且NH4+-N负荷平均0.45 kg.(m3.d)-1和溶解氧0.5 mg/L的条件下,可使出水中NO3--N的浓度低于20 mg.L-1,而ρ(NO2--N)∶ρ(NH4+-N)接近1.0.同时发现反应器运行期间,在低溶解氧的情况下,膜组件的污染并不严重.荧光原位杂交分析发现,在膜生物反应器中氨氧化菌成为优势菌种,亚硝酸盐氧化菌的活性受到了抑制.微生物群落分析则进一步提供了实现亚硝化工艺所必需的生物信息.     

Dynamic contact angle effects on gas-liquid behaviors in the cathode of proton exchange membrane fuel cell with stirred tank reactor design

Liquid water management is still a critical issue in the improvement of proton exchange membrane fuel cell (PEMFC) performance. In this work, for the first time, the liquid water behavior and transport inside the cathode of a PEMFC with a stirred tank reactor (STR) design, rather than the conventional PEMFC flow channel design, are numerically studied. The dynamic contact angle (DCA) is applied to multiple wall boundaries in the numerical model through a user-defined-function (UDF) code, i.e., STR-DCA model. Another numerical model with the static contact angle (SCA) and same operating conditions, i.e., STR-SCA model, is also developed for comparison. The volume of fluid (VOF) method is employed in the simulation to track the gas-liquid interface. The results show that the liquid water distribution and transport are significantly different between these two models, indicating the remarkable effects of DCA on the simulation results. It is also verified the capability of STR-PEMFC to reduce the liquid water flooding, showing the potential of this channel-less type fuel cell in the further development.     

TMBR+NF/RO组合工艺处理垃圾渗滤液的工程应用

采用TMBR+NF/RO组合工艺对湖北省宜昌市某垃圾卫生填埋场渗滤液进行处理,介绍了组合工艺的流程、特点、设备规格、技术参数。TMBR系统对可生化降解COD处理后,COD平均质量浓度为822 mg/L,平均去除率为95.8%,对NH_3-N平均去除率为94.9%;经过NF/RO出水的COD平均值为45 mg/L,NH_3-N均小于25mg/L,达到《生活垃圾填埋场污染控制标准》(GB 16889—2008)的排放标准。组合工艺处理成本为29.5元/m3。     

外置浸没式超滤膜处理垃圾焚烧发电厂渗滤液

结合外置浸没式超滤膜处理垃圾渗滤液的中试试验,对垃圾焚烧厂渗滤液SBR出水进行处理,主要研究结果如下:外置浸没式超滤膜(膜孔径0.1μm)对COD_(Cr)去除率为36.86%,出水SDI为1.87~3.69,可以作为纳滤预处理工艺使用,选取10 L/(m~2·h)的运行通量较为合理。     

微波协同氧化预处理垃圾渗滤液NF膜滤浓缩液研究

针对城市生活垃圾填埋场垃圾渗滤液NF膜处理后产生的浓缩液处理难问题,采用微波协同氧化技术对其进行预处理,探讨了pH值、预反应时间、药剂用量、微波反应时间等因素对浓缩液CODcr及色度去除率的影响.结果表明:当pH=4,预反应时间60 min,药剂用量1g/l、微波反应时间3 min时,CODcr、色度的去除率分别为71.2%,80%.预处理后的出水CODcr及色度指标达到垃圾渗滤液现有生化处理系统的进水要求.