微波辅助酸预处理玉米秸秆水解条件研究

玉米秸秆由叶子、皮和髓组成, 这些组分含有不同的纤维素、半纤维素和木质素, 因而可以成为生产燃料乙醇的原料. 采用微波辅助的酸水解来脱除与纤维素和木质素紧密结合的半纤维素, 使得纤维素结构发生变化有利于后续酶解是值得探讨的. 本研究通过将玉米秸秆叶子、皮和髓分离, 分别对它们进行了微波(2450MHz, 1000W)酸预处理, 确定了玉米秸秆不同部分的最优水解条件, 并对其进行了生产燃料乙醇的潜力对比, 以选出最适合做燃料酒精原料的部分. 同时, 在实验中, 选取硫酸浓度、温度、处理时间、料水质量体积比及搅拌速度5个因素分别进行单因素试验和正交试验. 结果表明, 5个因素对微波酸预处理玉米秸秆叶子的影响顺序依次为: 硫酸浓度>温度>料水质量体积比>时间>搅拌速度, 最佳条件是硫酸浓度5.0%, 温度75 ℃, 时间30min, 料水质量体积比1∶15, 搅拌速度800 r·min-1; 对玉米秸秆髓的影响顺序依次为: 硫酸浓度>搅拌速度>预处理时间>料水质量体积比>预处理温度, 最佳条件是硫酸浓度4.0%, 温度75 ℃, 时间25min, 料水质量体积比1∶20, 搅拌速度1000 r·min-1; 对玉米秸秆皮的影响顺序依次为: 硫酸浓度>预处理时间>料水质量体积比>预处理温度>搅拌速度, 最佳条件是硫酸浓度9.0%, 温度72 ℃, 时间30min, 料水质量体积比1∶17.1, 搅拌速度2000 r·min-1. 通过实验可以进一步得出, 玉米秸秆叶子和髓更适合用于生产燃料乙醇. 该研究结果对玉米秸秆的燃料化利用有一定的指导意义.     

Microwave thermal remediation of crude oil contaminated soil enhanced by carbon fiber

Thermal remediation of the soil contaminated with crude oil using microwave heating enhanced by carbon fiber (CF) was explored. The contaminated soil was treated with 2.45 GHz microwave, and CF was added to improve the conversion of microwave energy into thermal energy to heat the soil. During microwave heating, the oil contaminant was removed from the soil matrix and recovered by a condensation system of ice-salt bath. The experimental results indicated that CF could e ciently enhance the microwave heating of soil even with relatively low-dose. With 0.1 wt.% CF, the soil could be heated to approximately 700°C within 4 min using 800 W of microwave irradiation. Correspondingly, the contaminated soil could be highly cleaned up in a short time. Investigation of oil recovery showed that, during the remediation process, oil contaminant in the soil could be e ciently recovered without causing significant secondary pollution.     

微波混凝技术处理甲基橙模拟废水研究

采用微波混凝技术处理甲基橙模拟偶氮染料废水,对比Fe2(SO4)3、AlCl3、CaCl2、PAC四种混凝剂在有无微波作用条件下,对甲基橙模拟废水的色度去除率效果,表明Fe2(SO4)3的效果最佳,可提高21.4%.重点考察了微波强化混凝剂Fe2(SO4)3,在不同因素,如微波功率、微波辐射时间、pH值、Fe2(SO4...     

微波联合活性炭纤维处理剩余污泥的研究

利用活性炭纤维吸波能力强,重复利用的性能,以其为催化剂,联合微波辐射对剩余污泥进行催化氧化预处理.结果表明,当微波功率700W,辐照时间60s,活性炭纤维投加量0.32 g/g SS,污泥分解率可达30.9％,与单独微波辐照相比,污泥分解率增大一倍.由于微生物胞外聚合物(EPS)被分解、胞内物质释放到液相中,使污泥上清...     

微波萃取-气相色谱/质谱测定底泥中多溴联苯醚

文章建立微波萃取,复合硅胶氧化铝层析柱净化,气相色谱-负化学离子源质谱(GC-NCI-MS)检测对环境底泥样品中七种多溴联苯醚(PBDEs)单体定量分析的方法。底泥样品经25 mL正己烷:丙酮(1:1)萃取剂微波萃取10 min,过复合层析柱净化,70 mL正己烷:二氯甲烷(1:1)洗脱和浓缩后,加入内标物PCB-103后进行内标定量分析,7种PBDEs单体的平均基质加标回收率均值为88.6%~96.7%,相对标准偏差为1.9%~9.3%,方法检出限均小于0.06 ng/g,方法具有良好的重现性,较好的回收率和较高的灵敏度。所建立的分析方法体系已用于长江口近岸沉积物中7种PBDEs残留量的检测,四个实际样品中添加回收率指示物PCB-209,其回收率范围为79.5%~109.6%,相对标准偏差为5.2%~16.5%。     

石油石化海外项目员工心理健康管理初探

分析了海外项目员工的心理状态,提出了相应的心理健康管理方法。     

微波改性高炉瓦斯泥吸附特性研究

以马鞍山钢铁公司高炉瓦斯泥为对象,采用微波改性方法对高炉瓦斯泥的粒度分布、微观形貌及化学变化进行表征分析,揭示了微波作用对瓦斯泥吸附特性的影响.结果表明,高炉瓦斯泥的主要组分为含铁烧结矿和焦炭颗粒,经微波改性的瓦斯泥颗粒,在形貌上显示出粗糙度增大,孔隙结构明显,比表面积增大和活性点增多的特征.通过对亚甲基蓝的吸附测试,...     

Examining driver behavior using data gathered from red light photo enforcement cameras

INTRODUCTION: To develop an effective driver assistance system that can prevent red light violations, it is important to have a thorough understanding of contributing factors and circumstances surrounding such violations. METHODS: Red light violation behavior was examined using about 47,000 violation records that were captured by photo enforcement cameras from 11 signalized intersections in the city of Sacramento, California, over a four-year period. This examination identified factors with strong correlation to red light running behavior. RESULTS: Key findings based on Sacramento's red light violation records include: (a) younger drivers showed a higher tendency of running the red light and were more likely to commit such a violation at speeds above the posted speed limit; (b) off-peak time period between 8 p.m. to 5 a.m. had lower violation counts, but red light violators in this time frame had a higher propensity of racing through intersections at high speeds; (c) also during the time period between 8 p.m. to 5 a.m., violators showed a higher probability of entering intersections two or more seconds after the onset of red light; and (d) violators were less likely to cross high traffic-volume intersections with speeds greater than the posted speed limit. DISCUSSION: Sacramento's data suggest that some red light violators might have committed such an offense unintentionally. The top three violation speeds were all below 20 mph and more than 94% of red light runners crossed intersections within 2 seconds after the onset of the red light. IMPACT ON INDUSTRY: In the next several years, studies will be executed to assess whether a red light violation warning system can reduce "unintentional red light running" such as drivers who made incorrect judgment regarding the adequate time to clear the intersection and inattentive motorists who fail to observe the presence and status of the red light.     

微波消解石墨炉原子吸收法测定空气中的锑及其化合物研究

建立了用微孔滤膜采集空气样品,经硝酸-双氧水混合液微波消解,以硝酸镁溶液为基体改进剂,热解涂层石墨管,塞曼扣背景,石墨炉原子吸收法测定空气中锑的方法.方法线性范围为3.00～20.0μg/L,当采样体积为100 L,锑的最低检出质量浓度为0.000 5 mg/m3,加标回收率在93.0％ ～ 105.0％间,相对标准偏差均小于3％.该方法具有操作简便、快速、准确度高和用酸量少等优点,适用于空气中微量锑及其化合物的测定.     

石墨炉原子吸收法测定土壤中痕量锑研究

建立了微波消解土壤样品,硝酸镍作为基体改进剂,热解涂层石墨管,塞曼效应扣除背景,石墨炉原子吸收法测定土壤痕量锑的方法.锑在1.00 μg/L～15.0 μg/L浓度范围内呈良好线性关系,方程相关系数为0.9992,方法的最低检出浓度为0.01 μ上g/g(以取样质量0.250 0 g,定容体积50 mL计),实际样品的加标回收率为93.7％～104.1％.本方法前处理操作过程简单快速、酸用量少,土壤标准物质测定结果令人满意,能满足环境监测分析的要求.