浓硫酸低温分解废弃稀土抛光粉工艺研究

采用浓硫酸低温分解回收废弃稀土抛光粉,考察了硫酸用量、分解温度和反应时间对分解效果的影响,结果显示,较佳实验条件下,稀土收率可达95%以上。通过热重-差热与红外光谱联用技术实时在线监测技术,表明分解过程分为2个阶段,分别在270℃和300℃温度范围附近,稀土氧化物和稀土氟氧化物与硫酸发生反应。     

Residual congener pattern of dioxins in human breast milk in southern Vietnam

This study evaluated residual congener patterns of dioxin/furan (=PCDD/DF) related to tactical herbicides aerially sprayed over the regions of southern Vietnam through Operation Ranch Hand. The study focused on Cam Chinh (CC) commune, Quang Tri province (an area sprayed with tactical herbicides), and the Cam Phuc (CP) commune, Ha Tinh province (a non-sprayed area). Breast milk samples for analysis were collected in September 2002 and July 2003 from lactating primiparous and multiparous mothers born after the war (<31 years old). We found the levels of each congener in the CC commune were higher than in the CP commune, and determined specificity in the PCDD/DF congener pattern in CC commune samples by cluster analysis. The congener pattern is characterized by higher (the hexa-, the hepta-, and the octa-) chlorinated PCDD/DFs; this appears to be the same profile as that presented by pentachlorophenol (PCP), rather than 2,4,5-trichlorophenoxy acid (2,4,5-T) contaminated with 2,3,7,8-TCDD. A GC/MS study in the 1970s detected the chlorophenols 2,4-di and 2,4,6-trichlorophenol in some Agent Orange samples, which contained, like PCP, a wide variety of PCDD/DF congeners. In this context, it may be expected that certain tactical herbicides contaminated with various chlorophenol impurities, have a unique congener pattern when compared with pure 2,4,5-T formulations.     

Organochlorine pesticide in fresh and pasteurized cow's milk from Kampala markets

Fresh and pasteurized milk samples from Kampala markets were analyzed for organochlorine pesticides using a gas chromatograph equipped with an electron capture detector. Five organochlorine pesticides, namely; aldrin, dieldrin, endosulfan, lindane, DDT and its metabolites were detected in the milk samples and confirmed with a gas chromatograph equipped with a mass spectrometer [GC-MS]. The mean values are expressed in mg kg⁻¹ milk fat (mf) basis. The mean concentration in the fresh milk (n = 54) were: 0.026 ± 0.003 mg kg⁻¹ mf; 0.002 ± 0.0003 mg kg⁻¹, below the detection limit; 0.007 ± 0.003 mg kg⁻¹, 0.009 ± 0.002 mg kg⁻¹ milk fat for lindane, endosulfan dieldrin and aldrin, respectively. The mean concentrations of p,p′-DDE; p,p′-DDT and o,p′-DDT were 0.009 ± 0.002 mg kg⁻¹; 0.033 ± 0.007 mg kg⁻¹ and 0.008 ± 0.001 mg kg⁻¹ mf, respectively in the fresh milk samples.In the pasteurized milk samples (n = 47), the mean concentrations recorded were: 0.008 ± 0.003 mg kg⁻¹, 0.025 ± 0.004 mg kg⁻¹, and 0.007 ± 0.001 mg kg⁻¹, respectively for p,p′-DDE; p,p′-DDT and o,p′-DDT.Alpha and beta-endosulfan recorded the concentration below the detection limit and the mean of 0.022 ± 0.001 mg kg⁻¹ mf, 0.005 ± 0.002 mg kg⁻¹ mf, and 0.006 ± 0.0002 mg kg⁻¹ mf, respectively for lindane, dieldrin and aldrin. Although, most of the residues detected were above the residue limits set by the FAO/WHO (2008), bioaccumulation of these residues is likely to pose health risks to the consumers of milk in Uganda.     

Concentrations of polychlorinated dibenzo-p-dioxins, polychlorinated dibenzofurans, and polychlorinated biphenyls in blood and breast milk collected from pregnant women in Sapporo City, Japan

We measured the concentrations of polychlorinated dibenzo-p-dioxins (PCDDs), polychlorinated dibenzofurans (PCDFs), dioxin-like polychlorinated biphenyls (PCBs), and non-dioxin-like PCBs in paired samples of blood and breast milk collected from 67 secundiparas in Sapporo City, Japan, and combined this data with those of the 30 secundiparas previously measured. The arithmetic mean total toxic equivalents (TEQ-WHO) concentrations of PCDDs, PCDFs, non-ortho PCBs, and mono-ortho PCBs in blood and breast milk of the 97 secundiparous subjects were 3.0-23 (mean: 13, median: 14) and 2.7-20 (mean: 8.6, median: 8.5) pg TEQ g⁻¹ lipid, respectively. The sums of the concentrations of 56 non-dioxin-like PCB congeners that were measured in the subjects’ blood and breast milk were 16-326 (mean: 107, median: 100) and 12-252 (mean: 73, median: 67) ng g⁻¹ lipid, respectively. The partitioning ratios of individual congeners of PCDDs, PCDFs, dioxin-like PCBs, and non-dioxin-like PCBs from blood to breast milk in secundiparas were almost the same as those of primiparas that have been recently reported, suggesting that the partitioning ratios of these compounds from maternal blood to breast milk in women is little affected by delivery. Furthermore, the partition of PCB congeners with chlorine at the 2-, 3-, 4′-, and 5-positions or the 2-, 4-, 4′-, and 5-positions of the biphenyl ring from the blood to the breast milk tended to occur at a higher level than that of other congeners. In particular, the levels of tetraCB-74 and hexaCB-146 in the breast milk for both primiparous and secundiparous mothers were slightly higher than those in the blood.     

Triclosan in individual human milk samples from Australia

Triclosan is a chlorinated phenol ether that has been in widespread use as a broad-spectrum antibacterial agent for four decades. When compared to the limited international data available on human body burden of triclosan, results from a pooled blood study suggested that triclosan concentrations in Australia were a factor two higher than observed in Sweden. This study determined triclosan levels in individual human milk samples (n = 151) collected between 2002 and 2005 from primiparous Australian mothers. It provided the first report of population triclosan levels and individual variation in Australia and gave a measure of infant exposure via breast feeding. The distribution of triclosan concentration was positively skewed, with 7.2% of the samples below the LOQ, 66% with a concentration of less than or equal to 1.0 ng g⁻¹ fresh weight and the remaining samples above 1 ng g⁻¹ reaching a maximum concentration of 19 ng g⁻¹ fresh weight. The mean and median triclosan concentrations were 1.3 ± 2.7 ng g⁻¹ f.w. and 0.26 ng g⁻¹ f.w., respectively. The results of this study showed high variability in triclosan concentrations between individuals and no correlations with maternal age (p = 0.094), maternal weight (p = 0.971) or infant age at the time of sample collection (p = 0.621). A large number of samples contained low or non-quantifiable concentrations of triclosan and so, in Australia, ubiquitous background exposure due to environmental sources is low. This means that body burden can be influenced by an individual’s use of triclosan containing product. Given that triclosan containing product use is continuing, it is important that monitoring in both humans and the environment is continued and that triclosan containing products are adequately labeled so that an individual can choose to avoid exposure.     

National survey of the levels of persistent organochlorine pesticides in the breast milk of mothers in China

The occurrence of persistent organochlorine pesticides (OCPs) in breast milk samples collected from mothers from twelve provinces in mainland China was investigated. Dichlorodiphenyltrichloroethanes (DDTs) were the most prevalent agent, followed by HCHs and HCB, whereas levels of chlordane compounds, drins and mirex were lower. The relatively lower DDE/DDT ratio in the Fujian rural area suggested more recent exposure to DDT than in other areas. The mean level of DDTs in breast milk from the southern China was higher than those from northern China (p < 0.05). A positive correlation was observed between concentration of DDTs in human milk and consumption of animal-origin food, suggesting that this parameter could play an important part in influencing OCPs burdens in lactating women. The mean estimated daily intakes of different OCPs for breastfed infants were lower than the tolerable daily intake.     

废旧天然胶胶粉应用研究

以80目的废天然胶胶粉为研究对象,处理后将其分别以20%,30%的比例添加到天然混炼胶(NR)中,制备废胶粉/NR共混硫化胶;同时,通过邻苯二甲酸酐(PA)和高芳烃油对胶粉进行处理改性,制备了全胶粉弹性体。拉伸强度测试表明,对于共混胶弹性体,NR混炼胶空白样的拉伸强度为19.21 MPa,添加20%,30%比例的胶粉/NR共混硫化胶的拉伸强度可以分别达到18.03 MPa,17.23 MPa;改性后制备的全胶粉混炼胶硫化样品拉伸强度达到8.12 MPa,超过了再生胶的国标标准。同时应用扫描电子显微镜SEM分析、比较了各试样断裂面的微观结构,应用比表面仪BET和SEM表征了胶粉的表面形貌与结构,发现胶粉表面呈现"绒球"状,具有较好的表面性能。     

我国废橡胶粉用于沥青改性的研究及应用

从道路建设与防水卷材制造两方面,描述了我国废橡胶粉在沥青改性用途中的研究及应用现状。大量国内试验及应用实例表明,与普通石油沥青相比,胶粉改性沥青的针入度、延度、软化点、温度敏感性、稳定性和抗老化性等性能均得到了改善。此外,较之其他种类的沥青改性剂,废橡胶粉成本低,具有环保与资源节约的优点,对我国循环经济的发展具有重要意义。     

Zeolite powder addition to improve the performance of submerged gravitation-filtration membrane bioreactor

In this study, the effect of zeolite powder addition on submerged membrane bioreactor （SMBR） on membrane permeability, and the removals for COD, NH3-N, TN were investigated. Through the parallel operation of control and test systems, it was found that the zeolite powder addition could alleviate the ultra-filtration membrane fouling and enhance the membrane permeability. On the basis of experimental investigations, a concept of ＂protection coating layer＂ was proposed to illustrate the phenomenon of UF membrane fouling. In addition, the removal for COD in test system was more stable, a little higher compared to the control system. Due to the combination of nitrification and ion exchange, a more excellent removal for NH3-N in test system was obtained regardless of influent NH3-N loading rate. It was also found that a mean 25% higher TN removal took place in the test system, and ion exchange and simultaneous nitrification and de-nitrification were analyzed to be main factors. During the stable operation period, the SOURs of test zeolite powder added sludge and control activated sludge were measured to be 75 mgO2/（gMLVSS, h） and 24 mgO2/（gMLVSS, h） respectively, it meant that the zeolite powder addition could enhance the microorganism activity significantly.     

GP/APP膨胀阻燃体系对硅橡胶复合材料阻燃及抑烟性能的影响

为了探究石墨粉 (GP) 与聚磷酸铵 (APP) 膨胀阻燃体系对硅橡胶复合材料的阻燃及抑烟特性的影响,采用锥形量热仪 (CCT)、热重分析仪 (TG) 及极限氧指数测试仪 (LOI) 对阻燃硅橡胶复合材料进行表征。研究结果表明:与单独添加膨胀阻燃剂APP的阻燃硅橡胶相比,添加GP/APP膨胀阻燃体系可有效提升燃烧过程中形成的膨胀碳层的致密度,降低阻燃硅橡胶复合材料的热释放速率及总烟释放量,提高阻燃硅橡胶复合材料高温阶段的热稳定性,提升阻燃硅橡胶复合材料的燃烧成炭率和质量保持率; 使阻燃硅橡胶复合材料的氧指数值增大。