柴油机机外净化技术发展现状及展望

汽车柴油化已成为一个国际趋势,柴油机的气体净化得到越来越多的关注,面对欧洲Ⅳ/Ⅴ排放标准,开发适用于高标准的排放控制技术成为迫切需要解决的问题,而机外净化是这一技术的关键。对当前国内外研究和应用较多的柴油机机外净化技术进行了综述,分析了各种方法的原理、特点、处理效果及应用前景,并对其发展的趋势进行了展望。     

介质阻挡放电净化硫化氢气体的实验研究

采用介质阻挡放电等离子体技术净化恶臭气体硫化氢。考察了电压、频率、硫化氢初始浓度以及停留时间对硫化氢净化效果的影响。结果表明,介质阻挡放电可以有效消除硫化氢污染,硫化氢净化率随电压、频率以及停留时间的增加而升高,随硫化氢初始浓度增加而下降。当电压≥19kV,频率为300Hz,停留时间为1.56s,硫化氢初始质量浓度为30.1mg/m3时,硫化氢净化率接近100%。     

等离子体协同MnOx/SBA-15催化降解正己醛的研究

采用浸渍法制备了MnOx/SBA-15催化剂,利用BET、XRD和SEM等对催化剂进行表征。考察了介质阻挡放电等离子体协同MnOx/SBA-15催化剂对正己醛的降解性能。结果显示,负载MnOx后的SBA-15仍然保持介孔结构,且MnOx均匀地分散在SBA-15中;等离子体与催化剂表现出较好的协同作用,干燥条件下7.5 kV的放电电压结合10%MnOx/SBA-15时降解效果最佳,正己醛去除率达99%;相比干燥条件,相对湿度低于20%时正己醛去除率变化不明显,但高于20%时催化效果明显下降;该催化剂具有很强的O3分解能力,O3在催化剂表面的分解不仅促进了正己醛的氧化,同时也提高了CO2的选择性。     

非热平衡等离子体协同催化脱除挥发性有机化合物的研究进展

单纯运用非热平衡等离子体(NTP)技术脱除挥发性有机化合物(VOCs)的效率和能量利用率并不高,而且在降解过程中可能会产生某些有害副产物。为了克服NTP技术在VOCs治理方面的缺陷,可将NTP和化学催化方法组合运用,结合两者的优势使系统的VOCs脱除率、能量利用率和CO2选择率显著提高。从催化反应器结构、NTP与催化剂协同作用的原理等方面总结了近年来NTP协同催化技术在VOCs脱除方面的应用状况。最后指出,NTP协同催化技术在VOCs脱除方面有良好的应用前景,但要真正实现其工程应用,仍有很多问题亟待研究和解决。     

脉冲电弧液相放电等离子体污水消毒灭菌

采用某污水厂的出水,利用脉冲电弧液相放电等离子体技术,研究了放电脉冲次数、放电电压、放电极间距对大肠杆菌灭杀的影响。结果表明:随着放电脉冲次数的增加,灭菌率升高。当放电脉冲次数为400时,灭菌率高达99.1%。随着放电电压的升高,大肠杆菌的去除率升高,其中电压为3 kV最高,灭菌率为96.7%。在相同的电压下,放电极间距越小,灭菌效率越高,放电间距0.5 mm时最佳。利用扫描电镜观察等离子体处理前后大肠杆菌细胞的形貌变化,并根据灭菌的结果对等离子体的灭菌机理进行了分析,发现了灭菌消毒与等离子体中所含的活性粒子成分有密切的关系。     

新型等离子体同时脱除多种烟气污染物净化系统

燃煤电厂烟气中各种污染物一般是混合在一起的,针对此实际情况将等离子体技术与传统静电除尘器相结合,改传统电除尘器电源为高压直流＋高频高压交流使之达到产生等离子体要求的电源,研制一种同时脱除烟气中PM2.5~PM10和多种气体污染物的新型烟气净化系统。该系统不仅可以同时脱除多种污染物,且不产生二次废弃物,其改造和运行费用均在接受范围内,因此是一种具有应用潜力的系统。     

Destruction of PCDD/Fs by gliding arc discharges

PCDD/Fs have been become a serious issue because of their toxicological effects and associated adverse health implications.In this study,the gliding arc plasma was tested for treatment of polychlorinated dibenzo-p-dioxins(PCDDs)and polychlorinated dibenzofurans (PCDFs),which was synthesized from pentachiorophenol in atmospheric condition at 35℃with or without the catalysis of CuCl_2. From the experiment,we found that the destruction efficiency of PCDD/F homologues after gliding was discharge ranged from 25% to 79%.This result demonstrates that gliding arc plasma is an effective technology to decompose PCDDs/Fs in flue gas.A plausible degradation mechanism for PCDD/Fs by gliding arc was discussed.Finally,a multistage reactor structure of gliding arc was proposed to upgrade removal efficiency for PCDD/Fs.     

低温等离子体协同催化降解含硫恶臭污染物

采用共沉淀—喷涂法制备了（Cu5Mn7Zr1O22）0.08/（γ-Al2O3）0.1/堇青石蜂窝陶瓷催化剂。表征结果显示：催化剂孔隙率较高,表面均匀分散着粒径介于20~100 nm的晶体颗粒。以硫化氢和乙硫醇为典型含硫恶臭污染物进行了低温等离子体协同催化降解实验,结果表明：污染物的降解率随着输入功率的增加而提高;与单纯低温等离子体相比,低温等离子体协同催化能获得更好的降解效果。降解机理可能为：在高能电子和活性粒子作用下,H2S或C2H5SH分子中键能较弱的H—S、C—S和C—C键断裂形成·SH、·C2H5、·CH2SH、·CH3等小碎片基团,这些小碎片基团进一步发生聚合、氧化或自由基链式反应,最终降解为CO2、SO2、SO3、H2O等无毒小分子。     

脉冲电晕放电低温等离子体分解NH_3的动力学及机理研究

探讨了脉冲电晕放电低温等离子体分解NH_3的反应动力学及机理。采用比色法和离子色谱法分析了反应产物。考察了低温等离子体分解—水吸收联合工艺对含NH_3气体的处理效果。实验结果表明:低温等离子体分解NH_3符合准一级动力学经验模型kt=ln(ρ0/ρt)=-ln(1-D),其中k=0.007 9P-0.190 3(P≥24.08);NH_3的去除主要通过高能电子作用直接分解或与中间产物反应生成NH_4NO_3和NH_4NO_2两种方式;该联合工艺不仅可去除NH_4NO_3、NH_4NO_2等水溶性降解产物,同时臭氧遇水生成的·OH还可进一步分解水溶液中溶解性NH_3。     

Inhalation of two putative Gulf War toxins by mice

We employed our inhalation methodology to examine whether biomarkers of inflammation and oxidative stress would be produced in mice following inhalation of aerosols containing carbonaceous particles or the vapor of pesticides prevalent during the first Gulf War. Exposure to two putative Gulf War Illness toxins, fine airborne particles and the pesticide malathion, increased biomarkers of inflammation and oxidative stress in Friend virus B (FVB) female mice. Mice inhaling particles 24 h before had increased lung lavage and plasma Leukotriene B4 (LTB₄) (a biomarker of inflammation) and PGF_2α (a biomarker of oxidative stress) levels, lung lavage protein and lung lavage lactic dehydrogenase (LDH) levels. These changes were a function of particle density and exposure time. Compared to particle inhalation, mice inhaling malathion 24 h before had small increase in plasma LTB₄ and PGF_2α levels but no increase in lung lavage LTB₄, lung lavage protein, lung lavage LDH, and lung lavage alveolar macrophage (AM) levels compared to unexposed control mice. AM from particle-exposed mice contained phagocytosed particles, while AM from malathion-exposed mice showed no abnormalities. Our results indicate that inhaling particles or malathion can alter inflammatory and oxidative biomarkers in mice and raise the possibility that these toxins may have altered inflammation and oxidative stress biomarkers in Gulf War-exposed individuals.