聚丙烯超滤膜的低温等离子体改性方法比较

为了研究低温等离子体对中空纤维膜的改性效果,对聚丙烯(PP)中空纤维膜进行了4种等离子体改性处理,以接枝率、力学性能、膜面官能团变化以及膜面形态为评价指标,比较了不同改性方法的改性效果。FT-IR特征分析发现,以同时照射法改性后的膜面官能团变化最大,且接枝率高,力学性能好。元素能谱分析表明,处理后的膜表面的N、O含量均有不同程度的变化,且与接枝率成正相关。SEM照片及力学性能反映出:改性后膜面存在损失,柔韧性变差。综合各指标的比较发现,同时照射法是一种最佳的改性方法。因此,特别考察了同时照射改性膜的清水通量的变化,结果表明,该方法能够大幅度提高膜的清水通量。     

V_2O_5共混制备改性活性焦的脱硫性能及机理

以煤为原料、V2O5为添加剂共混制备新型活性焦(V/AC),研究了该活性焦的物理化学特征和脱硫性能,并探讨了改性活性焦脱硫机制。研究表明,改性活性焦的得率随V2O5负载量增加而增加,其脱硫性能均比未改性的活性焦高。当V2O5负载比例为12%时,碘值达到最大,为415 mg/g;其脱硫性能也最高,穿透硫容达到136.42 mg/g炭,比未改性活性焦增加约38.23%。BET结果表明,改性活性焦主要以微孔为主;红外光谱分析显示活性焦表面存在醇、羧酸、酚或醚类官能团。改性活性焦的脱硫机制包括:V2O5在活性焦表面主要以V2O3存在,脱硫时在氧气的存在下转化为V2O5;V/AC吸附、氧化SO2形成具有VOSO4结构的中间体,此中间体与O2反应生成V2O5和SO3,SO3或与H2O结合所成的H2SO4迁移到V2O5周围的微孔中。     

非均相催化臭氧氧化深度处理炼油废水

采用非均相催化剂催化臭氧氧化处理炼油废水,考察了催化剂负载率、p H、催化剂投加量和臭氧投加量及反应时间对处理效果的影响。结果表明,组合工艺最佳工艺条件为:催化剂负载率2.1%、p H 9、催化剂投量80 g/L、臭氧投量8.1 mg/L、反应时间60 min,COD、石油类、NH3-N、硫化物和SS去除率分别为91.3%、92.7%、80.5%、34.5%和59%。处理炼油废水过程中组合工艺存在明显协同效应,协同因子为1.47。中间臭氧氧化和催化臭氧氧化在最优工艺条件下对炼油废水COD的降解均符合准一级动力学规律。基于叔丁醇的实验结果,结合降解动力学可以推测,降解炼油废水过程中非均相催化剂催化臭氧产生高活性羟基自由基是降解效率提高的主导因素。     

烟气组分对低温等离子体协同TiO_2光催化工艺氧化Hg~0的影响

采用介质阻挡放电低温等离子体协同TiO2光催化工艺氧化烟气中Hg0,考察了烟气组分对氧化效果的影响。实验结果表明:低温等离子体放电会产生大量近紫外光;在6 k V电压下,低温等离子体协同TiO2光催化工艺时N2/Hg0氛围下Hg0的氧化率达86%,显著高于单一等离子体时的30%;O2和H2O产生的活性粒子会使Hg0氧化率进一步提高,在5 k V电压下,N2/Hg0氛围中添加5%(φ)O2或5%(φ)H2O,低温等离子体协同TiO2光催化工艺时可分别获得96%和94%的氧化率;NO与Hg0的竞争关系会导致作用于Hg0的活性粒子减少,抑制低温等离子体对Hg0的氧化,而在低温等离子体协同TiO2光催化时,抑制作用减弱;在复杂烟气氛围下,低温等离子体协同TiO2光催化对Hg0仍保持了较高的氧化率,3次重复实验的Hg0氧化率均接近92%。     

等离子体与光催化复合空气净化技术研究

尝试了一种新的等离子体一光催化复合方式,研究表明该种复合方式具有较显著的协同促进效应,通过改变等离子体发生单元与光催化单元的距离以及在两者之间放置网状物,可消除等离子体单元产生的负电荷对光催化单元的不利影响,进一步提高其复合效应。还对这一复合方式下协同效应产生的机理进行了分析。     

CO2+MEA反应在CaCO3催化下Eley-Rideal模型及混合胺溶液体系协同效应的机理研究

研究混合胺溶液吸收二氧化碳(CO₂)的反应机理对低碳环保具有重要意义.本文以碳酸钙(CaCO₃)为催化剂,在Eley-Rideal模型下通过Gaussian09软件模拟计算乙醇胺(MEA)+CO₂反应机理,,同时计算混合胺溶液体系乙醇胺(MEA)+二乙醇胺(DEA)/2-氨基-2-甲基-1-丙醇(AMP)/N-甲基二乙醇胺(MDEA)吸收CO₂中经实验证明的协同效应.本文在CCSD(T)/6-311++G(d,p)水平上计算在两性离子机理下中间步骤的自由能和几何振动频率.模拟结果表明,在固体催化剂CaCO₃作用下,反应活化能降低了14.9%,但是自由能没有降低.混合胺盐能量(MEA-DEA-CO₂,MEA-AMP-CO₂)低于MEA-CO₂-MEA能量,差距分别为-18.25%和-14.5%,而MEA-MDEA-CO₂体系能量与单一溶液体系差距仅为-5.88%.这表明二级胺,空间位阻胺的协同效应大于三级胺.     

Application of heterogeneous catalysis to biodiesel synthesis using microalgae oil

• Microalgae oil application for biodiesel synthesis is discussed. • Catalytic effectiveness of ferment preparations and chemical catalyst is disputed. • Application of heterogeneous catalysts for biodiesel synthesis is reviewed. • Possibilities of catalyst regeneration is shown. Recently, there is a growing interest in the use of microalga in various fields. Microalgae have properties such as rapid reproduction and high biomass accumulation, and under certain conditions, some are able to accumulate a large amount of oil. However, microalgae oil often contains more free fatty acids than the vegetable oil and is therefore unsuitable for biodiesel synthesis using alkaline catalysts. For this reason, some authors suggest the application of heterogeneous catalysis. A particular interest in the use of immobilized enzymes has developed. Other solid substances can also be used as heterogeneous catalysts are usually metal oxides, carbonates or zeolites. The use of these catalysts results in simpler biodiesel synthesis, especially purification processes, a cleaner end product and a less polluted environment. The molar ratio of alcohol to oil is lower during enzymatic transesterification, and more than 90% ester yield is obtained using a molar ratio of alcohol to oil of 3:1 to 4.5:1. The alcohols do not have a negative effect on the effectiveness of chemical catalysts, so it is possible to use alcohols in molar ratio from 4:1 to 12:1. The optimal temperature of enzymatic process is 30℃‒50℃. An ester yield of more than 95% was obtained in 12‒48 h. Using chemical catalysts, greater than a 95% yield of esters was obtained at higher temperatures in a shorter time. Material costs of enzymatic catalysis can be reduced by reusing the catalysts directly or after regeneration.     

A review on application of dielectric barrier discharge plasma technology on the abatement of volatile organic compounds

• Applications of non-thermal plasma reactors for reduction of VOCs were reviewed. • Dielectric barrier discharge (DBD) plasma was considered. • Effect of process parameters was studied. • Effect of catalysts and inhibitors were evaluated. Volatile organic compounds (VOCs) released from the waste treatment facilities have become a significant issue because they are not only causing odor nuisance but may also hazard to human health. Non-thermal plasma (NTP) technologies are newly developed methods and became a research trend in recent years regarding the removal of VOCs from the air environment. Due to its unique characteristics, such as bulk homogenized volume, plasma with high reaction efficiency dielectric barrier discharge (DBD) technology is considered one of the most promising techniques of NTP. This paper reviews recent progress of DBD plasma technology for abatement of VOCs. The principle of plasma generation in DBD and its configurations (electrode, discharge gap, dielectric barrier material, etc.) are discussed in details. Based on previously published literature, attention has been paid on the effect of DBD configuration on the removal of VOCs. The removal efficiency of VOCs in DBD reactors is presented too, considering various process parameters such as initial concentration, gas feeding rate, oxygen content and input power. Moreover, using DBD technology, the role of catalysis and inhibitors in VOCs removal are discussed. Finally, a modified configuration of the DBD reactor, i.e. double dielectric barrier discharge (DDBD) for the abatement of VOCs is discussed in details. It was suggested that the DDBD plasma reactor could be used for higher conversion efficiency as well as for avoiding solid residue deposition on the electrode. These depositions can interfere with the performance of the reactor.     

低温等离子体和催化剂协同作用处理有害气体

低温等离子体和催化剂协同作用技术具有分解效率高、能耗低、副产物少的优点而逐渐成为处理低浓度、大流量有害气体的重要方法。文章对反应机理、反应器的结构和在处理挥发性有机污染物(VOCs)、氮氧化合物等方面的研究进展做了概括,指出了该技术在环境治理方面的应用前景和发展方向。     

Fe~(3+)离子催化与微生物代谢在烟气脱硫中的协同作用

在酸性条件下(pH=2.0~2.8),Fe3+对SO2显示了良好的催化氧化作用。Fe2+对反应有较强的抑制作用。电院微生物1在其繁殖过程中,以Fe2+为能源,能有效地将Fe2+转化为Fe3+。将这一功能与上述反应相结合,能够维持Fe3+浓度,使反应持续进行。