从全混流反应器热稳定性的角度探讨高危工艺的危险性

通过对全混流反应器(CSTR)热平衡条件下多态的分析,探讨热稳定性条件,并对一级不可逆反应在CSTR中的热稳定性进行定性分析;探讨不同反应热和活化能对反应过程热稳定性的影响,及其对反应器发生"飞温"事故要求紧急停车时的控制要求的影响,进而从反应工程的角度对高危工艺的界定提出新的思路。分析结果表明,工艺的危险性不仅与工艺的种类相关,更与工艺本身的热力学、动力学特征密切相关。通过对高危工艺的热稳定状况的分析,能够动态地揭示其在温度扰动下发生"飞温"或"熄火"的过程,从本质上把握高危工艺潜在的危险性,并能有针对性地制定自动化改造方案,提高化工企业的本质安全度。     

Emission modelling and validation of VOCs' source strengths in air-conditioned office premises

An emission model for indoor volatile organic compounds (VOCs) based on mass balance considerations has been presented and validated under steady state conditions. Comparison were made for the measured and predicted concentrations of 37 selected VOCs and TVOC through a case intervention study on the filters of the ventilation system in a new commercial air-conditioned office building. The intervention involved replacing media filters with electronic and carbon filtration. TVOC and 37 compounds selected for their health and comfort impact, representation of major chemical classes that occur in indoor air and their utility as markers of pollution sources were studied. The concentration levels predicted by the model were compared with actual measurements. Twenty-five target compounds and the TVOC were adequately described by the model where the measured concentrations were in agreement with the predicted concentrations. Modeling of the remaining 12 compounds was found to be affected by the emission rates that were occupant related.     

某厂办公楼裂缝原因分析及安全监测

对某厂办公楼裂缝产生的原因进行了分析 ,并对其沉降情况和墙体裂缝发展情况进行了监测 ,指出了某办公楼现状及其隐患发展的趋势     

构建松辽流域水质监测信息系统可行性分析

随着2011年中央一号文件的提出,水利部对流域机构水质监测工作提出了更高的要求。为落实水利部水文局“七项制度”的要求,全面提升科学管理、数据准确、客户满意的质量方针,及时准确地提供监测数据,急需建立一套松辽流域水质监测信息管理平台,实现松辽流域水环境监测中心由传统的手工管理模式转向自动化、信息化管理的跨越,本文对构建松辽流域监测信息平台进行系统论述。     

湿热环境下配电自动化终端的腐蚀失效分析

目的解决配电自动化终端在湿热环境下的腐蚀失效问题,保障配网自动化系统的安全运行,延长配电自动化终端的使用寿命。方法分别选用三台架空终端FTU作为研究对象,研究配电自动化终端在湿热环境下的腐蚀失效特点,并提出针对性防护措施。采用SEM和EDS表征方法展开配电自动化终端的腐蚀失效分析。结果由EDS数据结果发现,相比较于轻微腐蚀区域,腐蚀区域的氧含量均大幅增加,且出现硫元素和氯元素,表明腐蚀环境主要是含硫和氯的潮湿环境。航空插头表面覆盖镍和铜两层镀层,腐蚀后的试样表面不仅检测到铜,有的甚至检测到基材铁,说明腐蚀后镀层已逐步失效,部分基材裸露,且已开始腐蚀。结合SEM发现,样品表面有大量颗粒粗大的腐蚀产物,且明显看出镀层已被破坏。结论材料腐蚀失效主要是由于高温度、湿度、含氯及硫等大气环境加速终端设备腐蚀,以及镀层被破坏或漏镀等问题造成基材裸露,腐蚀进一步深入发展。因此,根据湿热环境下配电自动化终端的腐蚀特点,提出针对性的防护措施。保障配网自动化系统的安全运行的同时,延长配电自动化终端的使用寿命,为今后的实证测试提供可靠依据。     

全自动气体自燃温度测试系统设计及应用

为降低气体自燃温度测试中的操作危险,减少繁琐的手工操作,参照ASTM E659-78(2005),GB/T21791—2008及GB/T21860—2008标准,设计一套全自动气体自燃温度测试系统。采用操作微机软件控制炉体升降温、配气、进气、温度采集、现象拍摄、抽滤尾气等过程,实现气体自燃温度测试从开始进气到吹扫尾气全流程的自动化;利用设计系统测试一氧化碳、乙烷等4种易燃气体的自燃温度。结果表明,该系统操作方便快捷、安全,4种气体自燃温度测试结果与文献值的相对标准偏差不超过1.5%,验证了系统的实用性及准确性。     

工业酸洗废水全自动化学处理过程的控制

酸洗工艺过程产生的酸洗废水的直接排放,将会导致受纳水体的水质恶化,造成环境污染.经过入水→预沉淀→氧化(含中和、曝气、搅拌、混凝)→沉淀→出水等物理,化学处理之后,排出口的废水基本上能符合国家的工业废水排放标准,可以达标排放.整个化学和物理处理工艺流程全部采用香港中能电化学设备公司自行研制的先进设备进行自动化控制;所需的关键控制仪器如ORP值测定仪、pH值测定仪和耐酸碱处理的泵等设备则全部采用西方先进国家进口.因此,一个污水处理厂只需要一个熟练的技术工人就完成了整个污水处理过程.     

Reducing Musculoskeletal Discomfort: Effects of an Office Ergonomics Workplace and Training Intervention

Effects of an office ergonomics workplace and training intervention on workers’ knowledge and self-reported musculoskeletal pain and discomfort were investigated. An instructional systems design process was used to develop an office ergonomics training program and the evaluation tools used to measure the effectiveness of the training program on workers’ office ergonomics knowledge and skills. It was hypothesized that the training and workplace intervention would allow the worker to more effectively use their workplace through increased office ergonomics knowledge and skills. Following the intervention, there was a significant increase in workers’ office ergonomics knowledge and awareness. Self-reported work-related musculoskeletal disorders significantly decreased for the group who had a workplace change and received ergonomic training relative to a workplace change-only group and a no intervention control group.     

A Quasi-Experimental Study of the Effects of the Erggi Action Model of Musculoskeletal Symptoms and VDU Working Conditions Among University Staff

Purpose. The aim of this study was to investigate musculoskeletal symptoms and working conditions of university workers with and without contact with an Erggi action model. Methods. A quasi-experimental and longitudinal field study design examined effects of the Erggi action model with 3 types of questionnaires filled by 1000 university workers. The statistical analyses used logistic regression. Results. Subjects who had contact with the Erggi action model had a higher probability of weekly musculoskeletal symptoms impairing their work, perceived more possibilities to influence their musculoskeletal symptoms and had lower risk for sick leave compared to those without contact with the Erggi action model. Conclusions. The Erggi action model increases the probability of influencing workers’ musculoskeletal symptoms, decreases the number of sick leave and increases awareness of musculoskeletal symptoms and working conditions.     

液桥凝聚用于办公废纸脱墨的研究

研究了混合办公废纸脱墨的选择性凝聚技术,在废纸浆中添加分散在水中并不与水相溶的长链烷作凝聚剂,这些凝聚剂选择性地将印刷墨粉通过液桥连结在一起,且形成大颗粒的球形聚团,再分选脱除.研究表明只需要加入占纸重量4%的廉价长链烷,即可获得95%以上的脱墨率.因此在混合办公废纸脱墨时加入凝聚剂进行液桥凝聚,可降低脱墨浆中的尘埃度并增加产品的白度.