溶解氧对HLB-MR反应器内有机物的生物絮凝影响

为了研究溶解氧（DO）对高负荷生物絮凝-膜反应器（HLB-MR）内有机物生物絮凝规律的影响,采用平行对比实验,考察了不同DO条件下反应器内有机物的生物絮凝效果、胞外聚合物（EPS）含量、金属阳离子浓度和微生物群落结构.结果表明：DO浓度分别为1~2mg/L和6~8mg/L时,HLB-MR反应器的絮凝效率分别为83%和89%,两反应器内上清液的浊度差别也进一步证实,较高的DO浓度下,反应器的生物絮凝效果更好.DO浓度在6~8mg/L时,HLB-MR反应器内结合态EPS和自由态EPS的含量分别为15.64mg/（g·VSS）和8.71mg/L,两者均显著高于DO为1~2mg/L时的11.83mg/（g·VSS）和6.56mg/L,反应器浓缩液中镁和铝的浓度也均明显高于低DO浓度时所对应的值,这说明在高DO条件下,有更多的EPS与金属阳离子结合而固定在污泥基质中,促进了生物絮凝.高通量测序表明,DO浓度分别为1~2mg/L和6~8mg/L时,HLB-MR反应器内细菌的群落结构差异明显,高DO浓度反应器底泥中Actinobacteria和Saccharibacteria的相对丰度较高,可能对生物絮凝有促进作用.     

基于常规处理的微污染水源水处理工艺改进措施简

我国大部分给水处理厂主要采用混凝-沉淀-过滤-消毒的常规处理工艺,该工艺对有机物、氨氮等去除效果有限,同时存在消毒副产物残留等问题。根据我国经济发展现状,分析了常规处理工艺的改进措施,包括对常规工艺进行强化,在常规处理工艺之前增加预吸附和预氧化,在常规处理工艺之后增加臭氧-生物活性炭吸附、膜处理等。这些措施在保留原处理工艺的基础上,通过调整操作条件或增加处理设施来改善出水水质,具有投资少、见效快的特点。     

Pervaporation of ethanol produced from banana waste

Banana waste has the potential to produce ethanol with a low-cost and sustainable production method. The present work seeks to evaluate the separation of ethanol produced from banana waste (rejected fruit) using pervaporation with different operating conditions. Tests were carried out with model solutions and broth with commercial hollow hydrophobic polydimethylsiloxane membranes. It was observed that pervaporation performance for ethanol/water binary mixtures was strongly dependent on the feed concentration and operating temperature with ethanol concentrations of 1–10%; that an increase of feed flow rate can enhance the permeation rate of ethanol with the water remaining at almost the same value; that water and ethanol fluxes was increased with the temperature increase; and that the higher effect in flux increase was observed when the vapor pressure in the permeate stream was close to the ethanol vapor pressure. Better results were obtained with fermentation broth than with model solutions, indicated by the permeance and membrane selectivity. This could be attributed to by-products present in the multicomponent mixtures, facilitating the ethanol permeability. By-products analyses show that the presence of lactic acid increased the hydrophilicity of the membrane. Based on this, we believe that pervaporation with hollow membrane of ethanol produced from banana waste is indeed a technology with the potential to be applied.     

两级序批式反应器运行模式下平板膜污染机理研究

从膜污染物分析、微生物代谢产物EPS、SMP对膜污染的影响等方面,对两级序批式反应器运行模式下的平板膜污染机理进行了试验研究.结果表明,膜表面及膜孔内部存在以球菌、杆菌为主的生物污染,膜表面的无机污染物主要是Fe、Na、Zr、Rb、Ca等化合物在浓差极化的作用下超过其溶解度极限后结晶形成的盐垢,膜表面的有机污染物主要是蛋白质,是形成膜表面凝胶层的主要原因,而蛋白质在膜面为伴随有电子转移的化学吸附,从而引起膜通量严重下降.     

膜系统处理电镀废水实验研究

采用膜系统处理二级排放电镀废水,研究在不同的进水条件与操作条件下,膜系统分离电镀废水中重金属离子及回收废水的效果;研究结果表明:膜系统去除二价及以上重金属离子非常有效,当系统的运行压力为0.65 MPa,进水pH在6～8,进水流量和回流比分别维持在1 m3/h与1.0左右,膜系统对Cr3+、Cu2+、Ni2+去除率分别可达99.3%、98.9%、98.6%;废水回收率达35%,运行成本仅为1.6元/t;运用膜系统处理二级排放电镀废水可产生显著的经济与环境效益。     

Effects of a dynamic membrane formed with polyethylene glycol on the ultrafiltration of natural organic matter

The formation of a dynamic membrane (DM) was investigated using polyethylene glycol (PEG) (molecular weight of 35000 g/mol, concentration of 1 g/L). Two natural organic matters (NOM), Dongbok Lake NOM (DLNOM) and Suwannee River NOM (SRNOM) were used in the ultrafiltration experiments along with PEG. To evaluate the effects of the DM with PEG on ultrafiltration, various transport experiments were conducted, and the analyses of the NOM in the membrane feed and permeate were performed using high performance size exclusion chromatography, and the effective pore size distribution (effective PSD) and effective molecular weight cut off (effective MWCO) were determined. The advantages of DM formed with PEG can be summarized as follows: (1) PEG interferes with NOM transmission through the ultrafiltration membrane pores by increasing the retention coefficient of NOM in UF membranes, and (2) low removal of NOM by the DM is affected by external factors, such as pressure increases during UF membrane filtration, which decreases the effective PSD and effective MWCO of UF membranes. However, a disadvantage of the DM with PEG was severe flux decline; thus, one must be mindful of both the positive and negative influences of the DM when optimizing the UF performance of the membrane.     

平板膜在污泥浓缩消化处理中的应用研究

采用中试规模的反应器对平板膜-污泥浓缩消化(MSTD)工艺的污泥消化机制和膜污染机理进行了研究.结果表明,经过15d的运行,MSTD工艺的污泥浓度(MLSS)从最初的3.6g/L上升到约34.2g/L,MLVSS和MLSS的消解率分别达到52%和47%,实现了同步浓缩和消化.由于溶解氧的变化,MSTD工艺的消化机制分为好氧消化和类似的厌氧消化2个阶段,分别降解二价金属离子和铁离子连接的2类生物聚合物.在MSTD过程中,平板膜的截留和污泥消化导致污泥性质剧烈变化,从而造成膜过滤性能剧烈下降.MLSS、胞外聚合物(EPS)和溶解性微生物产物(SMP)均对膜污染有显著的影响.     

立方体和八面体微/纳米氧化亚铜对大型水蚤(Daphnia magna)的氧化胁迫和生理损伤

为了实现特定的功能和应用,越来越多不同结构特性的纳米材料逐渐被人们精确合成。一些研究指出纳米材料的物理化学特性能够显著影响纳米材料对水生生物的毒性作用,但是对于不同特性的纳米氧化亚铜的毒性研究依然比较缺乏。本研究制备了2种不同形貌和结构的微/纳米氧化亚铜(micro/nano-Cu_2O)晶体,通过对大型水蚤(Daphnia magna)进行72 h的急性暴露实验,测定了大型水蚤体内还原型谷胱甘肽(GSH)的含量以及超氧化物歧化酶(SOD)、过氧化氢酶(CAT)和钠/钾腺苷三磷酸酶(Na+/K+-ATPase)的活性变化。结果表明在2种不同特性的微/纳米氧化亚铜暴露体系中,大型水蚤体内Cu的积累量差别不大,但是不同结构的micro/nano-Cu_2O对大型水蚤抗氧化酶活性和钠/钾腺苷三磷酸酶活性影响存在差别。与立方体相比,八面体micro/nano-Cu_2O能够暴露更多的{111}面,并且其原子排列使其具有较高的表面能量,因此更容易在大型水蚤肠道内诱导产生活性氧(ROS)及溶出更多Cu2+,对大型水蚤产生更强的氧化胁迫和膜损伤。     

乳状液膜法治理草甘膦废水

采用液膜分离技术从草甘膦生产废水中回收可利用资源草甘膦,并通过实际工业废水进行验证。主要考察了外水相pH值、乳水比及内水相浓度对草甘膦去除的影响。试验结果表明:以航空煤油为溶剂,3%表面活性剂(质量分数),4%载体(体积分数),10%NaOH内水相,油内比Roi为2∶1乳状液膜体系,处理初始浓度为1%的草甘膦工业废水,在pH值为2,乳水比Rew为1∶5的传质条件下,草甘膦去除率可达85%以上。     

膜生物反应器在医院污水处理中的应用

采用全封闭式膜生物反应器处理医院污水,出水水质良好,ρ(COD)<60 mg/L,ρ(NH3-N)<6 mg/L,浊度<0.3NTU的概率约为95%,ClO2消毒后出水中未检测出细菌和粪大肠菌群,可满足GB 18466—2005《医疗机构水污染物排放标准》的要求。高效过滤器对曝气尾气中的微生物粒子截留效果良好,大大降低了MBR系统因气溶胶扩散可能产生的二次污染和威胁。此外采用了远程监控技术,可以通过公共网络对污水处理系统进行监视和控制,最大限度地保证系统的稳定运行和保障操作人员的生命安全。