环氧化PVA载体固定漆酶的最佳工艺条件研究

在T=35℃,HAc-NaAc缓冲溶液pH为4的条件下,用环氧化PVA载体对漆酶进行固定化,固定后酶活为游离酶活的95%。用该固定化漆酶处理制浆造纸废水,反复使用6次后,酶活仍保持为初始酶活的45%,且每次COD去除率在40%以上,处理后的废水BOD增大了50%,废水可生化性得到很大提高。     

Preliminary Studies on Converting Agricultural Waste into Biodegradable Plastics—Part IV: Polysaccharide Containing Natural Materials

Corn distillers’ dry grain, corncob powder, hardwood powder, and sugar beet pulp were separately anionized by oxidation with sodium hypochlorite in aqueous solution. Solid reaction products instantly precipitated upon admixing each of the above-oxidized materials with soy protein isolate. Infrared spectra and differential scanning calorimetry supported the hypothesis that soy protein isolate complexed with all of the above-oxidized polysaccharides. Reaction products with either oxidized corn distillers’ dry grain or oxidized sugar beet pulp provided hard, brittle pellets with tensile strengths as high as 9.5 MPa, suggesting that these materials could be viable as biodegradable plastics.     

厌氧折流板反应器处理玉米秆纤维浆粕废水的研究

采用厌氧折流板反应器 (ABR)处理玉米秆纤维浆粕废水 ,研究了工艺条件和工艺特征。试验结果表明 ,在HRT为 2 4h ,OLR为 6 .5 6kgCOD/m3 ·d条件下 ,ABR能有效处理浓度为 6 5 6 0mgCOD/L的玉米秆纤维浆粕废水 ,COD去除率为 75 .1% ;ABR对负荷冲击有良好的适应性 ,且具有推流式和两相式反应器的双重特点。     

Determination of dibenzo-p-dioxin (DBD) and dibenzofuran (DBF) in paper pulp mill defoamer additives and in paper pulp samples

An analytical procedure has been developed for quantitatively measuring dibenzo-p-dioxin (DBD) and dibenzofuran (DBF) present at part-per-billion levels in paper mill defoamers and paper pulp using gas chromatography coupled with either low resolution mass spectrometry (GC-LRMS) or high resolution mass spectrometry (GC-HRMS).     

Intra- and inter- laboratory variability in paper industry PCDD/PCDF analysis

Studies were conducted to quantify variability for pulp industry wastewater effluent, pulp and sludge analyses. Intralaboratory variability studies indicated that there is a potential for greater between batch variability in results than for within a batch. Intralaboratory relative standard deviations for replicate analyses ranged from 6% to 60%. Interlaboratory studies, using standard reference materials showed relative standard deviations from 4% to 135%. There appeared to be little dependance of variability on concentration, suggesting matrix effects were very important. In general, effluent variability was greater than observed for pulps or sludges. Analysis of reference standards indicated that 13% to 17% variability can be attributed to differences in calibration standards. A limited study of full congener PCDD/PCDF analysis variability showed it to be greater than observed for TCDD/TCDF.     

用草浆造纸黑液制取活性炭

本法用酸水解炭化、ZnCl_2活化法处理草浆造纸黑液生产活性炭.结果表明,由7—8Be的草浆黑液1L可制20g左右的活性炭.活性炭的碘值>1000mg/g,亚甲基兰值>180ml/g,其主要指标已超过我国LY216-79和日本JIS K1426标准一级品的要求.提取活性炭后,黑液中COD_(Cr)去除率达72％,色度去除率达93％.残液还可作提取Na_2SO_4、糠醛的原料.     

草浆造纸黑液无污染排放治理新方案——双极膜电渗析法回收碱

介绍碱法草浆黑液采用膜技术处理的各种方案,着重介绍了碱法草浆黑液资源化全回收技术并提出了新的技术方案,该方案是先用硫酸中和酸析黑液中的木质素,或用纳滤方案回收木质素,然后采用双极膜电渗析法回收已去除木质素的黑液中的酸和碱,最后经蒸发和喷雾干燥回收其中的糖、其他营养成分及大部分水,达到无污染排放的目的。该方案碱回收率在50%～80%,取决于黑液中碱的浓度,回收1 t碱的耗电量低于2 500 kW.h。该法的基本投资比同规模碱回收法节省60%以上,具有较好的经济效益。     

纸浆模塑缓冲材的技术研究

聚苯乙烯发泡塑料（EPS）作为缓冲包装的内衬件广泛用于电子产品的内包装,但其所带来的白色污染问题也日益严峻。研究以再生资源（废纸）为原料,生产产品内衬包装物——纸浆模塑缓冲材,并使其产业化,以替代发泡塑料包装物,改变发泡塑料包装物难降解所带来的污染和危害,并实现“废弃物—产品”的资源循环利用。     

生物法处理棉浆黑液的现场实验研究

利用经驯化的以嗜碱菌群为主的好氧活性污泥及常规厌氧、好氧污泥,针对不同浓度的棉浆黑液在现场进行了单独"好氧"及"好氧-厌氧-好氧"全流程工艺实验。结果表明:对棉浆黑液直接进行好氧曝气,可将原水pH值自12.4左右稳定降低至10以下,COD去除率可达40%左右。全流程实验中厌氧效果显著,pH值最低可降至8.2,整个系统抗冲击能力强,运行稳定,COD总去除率保持在63%以上。     

Dioxin formation in pulp and paper mills of India

Samples of effluents, sludge, pulp, final products (paper) and soil were collected from the identified pulp and paper mills in India. The samples were analysed for 2,3,7,8-tetrachloro-dibenzo-p-dioxin (2,3,7,8-TCDD) and other dioxin congeners and precursors. Pulp and paper mills using chlorine for the bleaching process showed the presence of 2,3,7,8-TCDD in effluent samples. In the effluent and pulp samples from mills where chlorine dioxide was used as a bleaching agent, the 2,3,7,8-TCDD congener ranged from below the detection limit 0.05 to 0.12 ngL⁻¹/ngg⁻¹. The relative standard deviation of reproducibility and the percent recovery of 2,3,7,8-TCDD were 2.07 and 82.4% in pulp and 2.8 and 92% in effluent, respectively. The 1,3,6,8-TCDD was the only other major dioxin congener found in the treated and untreated effluent and sludge samples. However, dichlorobenzene, trichlorophenyl, and hexachlorobiphenyl were detected in all samples. The formation of dioxins can be minimised by replacing chlorine with chlorine dioxide in bleaching processes in pulp and paper mills.