结晶沉淀-树脂吸附组合工艺回收黄连素废水中铜试验研究

通过多批次的小试试验考察了结晶沉淀-树脂吸附组合工艺对黄连素含铜废水的处理效果,并对产生的碱式氯化铜(TBCC)结晶沉淀进行X射线衍射(XRD)成分分析。结果表明:反应pH为7.0~9.0时,废水中超过99.9%的Cu ²⁺以碱式氯化铜结晶沉淀的形式得以回收,反应生成的碱式氯化铜沉淀通过水洗后,其成分符合GB/T 21696—2008《饲料添加剂 碱式氯化铜》质量标准。剩余的废水再经过树脂吸附工艺处理后,出水Cu ²⁺浓度小于1.0 mg/L。在小试试验的基础上,开展了中试试验研究,其结果进一步验证了小试试验的运行效果及该工艺的可行性。通过该处理工艺既可综合利用废水中的铜资源,又可将废水的pH由小于1调至大于7,有利于实现制药废水综合处理和达标排放。     

A miniature stainless steel net dumbbell-shaped stir-bar for the extraction of phthalate esters in instant noodle and rice soup samples

Abstract

This work reports the development of a very-simple-to-construct stir-bar extraction device so called “a dumbbell-shaped stainless steel stir-bar.” The extraction device was assembled from a rolled up stainless steel net filled with an XAD-2 sorbent and a metal rod to allow the use of a magnetic stirrer during extraction. The dumbbell-shaped stainless steel stir-bar was used to extract diethyl phthalate (DEP), dibutyl phthalate (DBP), and di(2-ethylhexyl) phthalate (DEHP) before analysis by a gas chromatograph equipped with an electron capture detector (GD-ECD). Under the optimal conditions, the developed method provided a good linearity from 10.0 to 1,000.0?ng mL^?1 for all three compounds. Limits of detection and limits of quantification were 9.37?±?0.29?ng mL^?1 and 31.22?±?0.95?ng mL^?1 for DEP, 5.73?±?0.31?ng mL^?1 and 19.1?±?1.0?ng mL^?1 for DBP and 3.30?±?0.06?ng mL^?1 and 11.0?±?0.19?ng mL^?1 for DEHP, respectively. Good recoveries in the range of 81.89?±?0.17 to 109.5?±?2.0% were achieved when the method was used to extract phthalate esters in five instant noodle and two rice soup samples.     

Nitrogen removal efficiencies and microbial communities in full-scale IFAS and MBBR municipal wastewater treatment plants at high COD:N ratio

• Two IFAS and two MBBR full-scale systems (high COD:N ratio 8:1) were characterized. • High specific surface area carriers grew and retained slow-growing nitrifiers. • High TN removal is related to high SRT and low DO concentration in anoxic tanks. The relative locations of AOB, NOB, and DNB were examined for three different kinds of carriers in two types of hybrid biofilm process configurations: integrated fixed-film activated sludge (IFAS) and moving bed biofilm reactor (MBBR) processes. IFAS water resource recovery facilities (WRRFs) used Anodkalness^TM K1 carriers (KC) at Broomfield, Colorado, USA and polypropylene resin carriers (RC) at Fukuoka, Japan, while MBBR WRRFs used KC carriers at South Adams County, Colorado, USA and sponge carriers (SC) at Saga, Japan. Influent COD to N ratios ranged from 8:1 to 15:1. The COD and BOD removal efficiencies were high (96%–98%); NH₄⁺-N and TN removal efficiencies were more varied at 72%–98% and 64%–77%, respectively. The extent of TN removal was higher at high SRT, high COD:N ratio and low DO concentration in the anoxic tank. In IFAS, RC with high specific surface area (SSA) maintained higher AOB population than KC. Sponge carriers with high SSA maintained higher overall bacteria population than KC in MBBR systems. However, the DNB were not more abundant in high SSA carriers. The diversity of AOB, NOB, and DNB was fairly similar in different carriers. Nitrosomonas sp. dominated over Nitrosospira sp. while denitrifying bacteria included Rhodobacter sp., Sulfuritalea sp., Rubrivivax sp., Paracoccus sp., and Pseudomonas sp. The results from this work suggest that high SRT, high COD:N ratio, low DO concentration in anoxic tanks, and carriers with greater surface area may be recommended for high COD, BOD and TN removal in WRRFs with IFAS and MBBR systems.     

改性三聚氰胺甲醛树脂的合成及性能研究

研究了反应物配比、反应时间、反应温度、ＰＨ值对丙烯酰胺改性三聚氰胺甲醛树脂絮凝效果的影响，实验结果表明絮凝效果最佳的合成反应条件为三聚氰胺／甲醛／丙烯酰胺（质量比）＝１／５（２－３），反应温度为７０℃，反应时间为４ｈ，ＰＨ值为９．０左右。     

野外便携净水器净水消毒工艺试验研究

野外便携净水器应具杀菌消毒效率高、净水时间短、使用寿命长、操作方便等功能使用要求。通过试验考察了三碘树脂和载银活性炭两种不同净水消毒工艺流程对原水处理效果。结果表明：三碘树脂材料比载银活性炭材料具有灭菌效果好、反应接触时间短、使用时间长等优势，是一类具有良好军事应用价值的野外便携净水器的净水消毒材料。     

大孔树脂对邻苯二甲酸的吸附研究

研究了XDA-200大孔树脂对水溶液中邻苯二甲酸的吸附。结果表明XDA-200树脂对水溶液中的邻苯二甲酸吸附速度很快，30min内基本达到平衡，其后达到完全平衡的吸附进程非常缓慢。树脂对邻苯二甲酸的吸附量随质量浓度增加而增加。pH值降低，有利于邻苯二甲酸在溶液中以分子态存在，易于树脂吸附。邻苯二甲酸的吸附均满足Freundlich和Langmiur等温吸附方程。泄漏点与进水浓度和流速均有很大关系。     

用螯合树脂研究光解作用对水中铝形态的影响

本文对用螯合树脂分离水中无机铝和有机铝的方法、螯合树脂的制备及其对无机铝的交换进行了探讨。结果表明,水体中的有机铝在紫外光照射下能分解为无机铝,其分解速度随光照时间的增加而增加。由于无机单聚体铝对鱼类有致毒作用,因此,光解作用的结果使水体中铝的毒性增加。     

大孔网状树脂在富集水体中有机物的应用

介绍了ＸＡＤ及ＧＤＸ型大孔网状树脂富集水体中痕量有机物的方法。讨论了上述树脂对某些有机物的富集率；影响树脂对有机污染物富集率的因素，如洗脱剂的种类，水样流速，水样和洗脱液保存时间及有机物性质等因素的影响。提出了富集过程中应注意的问题。     

污灌区地下水中有机污染物的分离鉴定与致突变活性研究

应用XAD系列大孔网状树脂萃取富集法,结合GC、GC/MS/DS1的分离鉴定技术,研究了北京东郊污灌区深层(90m)和浅层(18m)地下水中的有机污染物。采用LSC-GC/MS/DS装置测定了地下水中的挥发性有机物,并对水样进行了Ames试验以检验水样的致突变活性。结果从深井水样中检出32种非挥发性有机物,未检出挥发性有机物,致突变试验阴性。浅井水样中同时检出非挥发性和挥发性有机物。两种菌株在所有试验条件下均呈现阳性致突变反应。     

处理化肥厂造气废水新型催化剂的研究

利用合成的氧化还原树脂进行了实际废水的处理 ,取得了良好的效果 ,开辟了废水处理的一条新途径。