城市污泥发酵处理中微生物对有机物的降解

为园林绿化安全施用城市发酵污泥提供科学依据,将污水处理厂采集的脱水消化污泥,添加吸湿剂,使其含水量达40%后,装入发酵地,与对照池同时进行0、5、10、15、20天采样,并同步进行微生物培养计数和用色谱法对毒性有机物进行定量分析。结果表明,微生物对毒性有机物的降解有明显效果,特别对甲苯、乙苯、邻苯二甲酸酯、γ－666,op＇－DDT等降解效果更显著。同时,微生物类群的数量变化与毒性有机物的降解率呈正相关关系。毒性有机物的降解是以细菌、放线菌为主的微生物综合作用的结果。可以认为污水处理厂的消化污泥通过发酵处理降解有机物是可行的,其产物应用于园林绿地将是比较安全的。     

厌氧发酵系统温度的选择和热量平衡

本文分析了厌氧发酵温度的选择和厌氧系统中热量平衡的关系。并运用此关系对薯干酒糟过滤液在冬季最低温度为0℃,夏季最高温度为35℃的地区进行中温和高温厌氧发酵处理中的热量平衡关系分别进行了讨论,证明了对温度为50℃,COD浓度为23g/L的废液进行中温发酵能得到更大的经济效益,但也必须使用所产生的沼气作为能源加热或冷却废液。所需的热量和气温的关系为:Q_t=4.73×105to-3.73×106 (KJ/d)。      

产酸相最佳发酵类型工程控制对策

对二相厌氧消化工艺的研究证明,产酸发酵阶段对整个厌氧生物处理系统运行的成败起着关键的作用,作为产酸发酵三种类型之一的乙醇型发酵被证明是产酸相的最佳发酵类型。采用连续流二相厌氧生物处理系统,对产酸相乙醇型发酵在实际工程中能够直接控制的运行参数进行了研究与探讨。试验结果表明,产酸相乙醇型发酵的最佳参数：温度为34～38℃,pH为4.0～4.4,Eh为－300～－400mV,HRT为5～6h;污泥负荷应不大于4gCOD/gVSS·d,以2.5gCOD/gVSS·d最佳。     

污泥处理及有效利用

在调研国内外关于污泥处理及有效利用的文献资料的基础上,分析天津开发区污水处理厂污染特性和成份并进行污泥发醇模拟试验,根据污泥特性并结合开发区土壤理化性质特点,提出开发区污泥处理及有效利用的可行方案。     

Production of Ethanol by an Integrated Valorization of Olive Oil Byproducts. The Role of Phenolic Inhibition (2 pp)

Background, Aim and Scope Agricultural industrial wastes can frequently be used as raw materials in the production of bio-fuels. Olive-oil milling wastewater is considered as one of the most polluting agro-industrial residues, but fortunately due to its high content of organic matter, it has the potential to be a valuable starting material to obtain bio-ethanol via fermentation with Saccharomyces cerevisiae. The fermentation of olive-oil milling wastewater has been demonstrated with good yield of ethanol (8-12%v/v) once the level of reducing sugars is appropriate and the phenolic fraction, which inhibits the yeast, is removed. Materials and Methods: - Results: - Discussion: - Conclusions: - Recommendations and Perspectives: -     

Biohydrogen production through fermentation using liquid swine manure as substrate

In this paper, continuous production of hydrogen through fermentation with liquid swine manure as substrate was researched using a semi-continuously fed fermenter (8 L in total volume and 4 L in working volume). The pH and temperature for the fermenter were controlled at 5.3 ± 0.1 and 35 ± 1°C, respectively, throughout the experiment. Three hydraulic retention times (16, 20, and 24 h) were investigated for their impact on the efficiency and performance of the fermenter in terms of hydrogen yields. The results indicate that hydraulic retention time (HRT) has a strong influence on the fermenter performance. An increasing HRT would increase the variation in hydrogen concentration in the offgas. To produce hydrogen with a fairly consistent concentration, the HRT of the fermenter should not exceed 16 h, which, however, did not appear to be short enough to control methanogenesis because the offgas still contained about 5% methane. When methane content in the offgas exceeded 2%, an inverse linear relationship between hydrogen and methane was observed with a correlation coefficient of 0.9699. To increase hydrogen content in the offgas, methane production has to be limited to below 2%. Also, keeping oxygen content in the fermenter below 1.5% would increase the hydrogen concentration to over 15%. The product to substrate ratio was found to be around 50% for the fermenter system studied, evidenced by the observation that for every 6 liters of manure fermented, 3 liters of pure hydrogen were produced, which was significant and encouraging.     

拮抗放线菌T111菌株鉴定、发酵液理化性质测定及发酵条件优化

为明确放线菌T111在植物病害生物防治中的应用潜力,通过形态观察、生理生化测定结合16S rDNA序列分析确定了其分类地位,采用平板打孔法测定了发酵液的理化性质,并采用单因素试验与正交设计方法筛选出该菌株的优化发酵配方和发酵条件.结果表明,T111与黄色链霉菌Streptomyces flaveus strain NBRC3359(AB184749)序列的同源性最高,初步鉴定为黄色链霉菌(Streptomyces flaveus).该发酵液对黄瓜菌核、黄瓜蔓枯、棉花红腐病菌等有较高的抑制活性;贮存稳定性和热稳定性良好,4℃贮存60 d,抑菌活性为对照的88.3%,80℃处理60 min抑菌活性为对照的90.9%;对pH值较敏感,在pH 5～7时活性较高;对紫外线稳定,紫外光照射12 h,其活性基本不受影响.培养基优化组合为:可溶性淀粉20 g,大豆蛋白胨5 g,NaNO3 20 g,FeSO4 0.5 g,去离子水1 000 mL;优化发酵条件为:发酵温度27℃,发酵时间5 d,初始pH 6.0,接种量5%,装液量75 mL/250 mL,摇床转速150 r min-1.图6表2参18     

The Effects of Gas Flow Rate and the Interval Time of Water Supplement on Ethanol Production of Rice Straw by Simultaneous Saccharification and Fermentation

In the present work, characteristics of ethanol production from a single particle composing of pretreated rice straw, cellulase, and β-glucosidase were invesitgated by simultaneous saccharification and fermentation (SSF). The experiment experienced a start-up stage for S. cerevisiae biofilm formation, which was operated at an initial pH value of 4.8 for yeast solution, culture temperature of 30°C, flow rate of 0.8 mL/min for yeast solution, and stably operating stage for ethanol production at a culture temperature of 30°C. Investigations found that the maximal ethanol yield of 9.7 mg/g and the biofilm thickness of 0.37 mm were obtained at 30 mL/min of carrier gas flow rate. Also, the optimal interval time of water supplement was 4 h for SSF. The results show that the appropriate gas flow rate and the interval time of water supplement can keep the high activities of biofilm and enzymes during SSF and result in a high ethanol yield.     

南昌市城市污水厂污泥处理处置方案探讨

从理化性质、有机质及N、P、K等营养元素、重金属、热值等方面对南昌市城市污水厂污泥泥质特征进行分析,调查南昌市污泥处理处置的现状及存在问题,针对多种污泥处置方式和处理技术对其适用性进行探讨,最终确定适合南昌市污水处理厂的污泥处理处置方案。     

Fate of atrazine and chlorpyrifos during solid state fermentation—examination of processes

Abstract

Solid state fermentation (SSF) was investigated as a means to dispose of two commonly used pesticides, chlorpyrifos (O, O‐diethyl O‐(3,5,6‐trichloro‐2‐pyridyl) phosphorothioate) and atrazine (2‐chloro‐4‐ethylamino‐6‐isopropylamino‐1,3,5‐triazine). SSF experiments were carried out in bench‐scale bioreaetors (equipped with CO₂ and volatile organic traps) containing a mixture of lignocellulosic materials and a radiolabeled pesticide. Ethyl acetate‐extractable, alkali soluble, and alkali insoluble fractions were evaluated for radioactivity following a 60‐d incubation period at 40°C. The majority of the [2, 6‐pyridyl‐¹⁴C]chlorpyrifos was associated with the ethyl acetate extract (about 74%), 17% was trapped as organic volatiles by polyurethane foam traps and < 0.5% of the chlorpyrifos was mineralized to CO². Only small amounts of the radioactivity were associated with alkali soluble (0.0003%) and alkali insoluble (0.3%) fractions. In the [¹⁴C‐U‐ring] atrazine bioreactors, very little of the radioactivity volatilized (<0.5%) and less than 0.5% was mineralized to CO₂. Approximately 57% of the applied radioactivity was associated with the ethyl acetate extract while 9% and 24% of the radioactivity was associated with the alkali soluble (humic and fulvic acids) and alkali insoluble fractions, respectively. Possible reaction mechanisms by which covalent bonds could be formed between atrazine (or metabolites) and humic substances were investigated. The issue of bound atrazine residue (alkali soluble fraction) was at least partially resolved. Oxidative coupling experiments revealed that formation of covalent bond linkages between amino substituent groups of atrazine residue and humic substances is highly unlikely.