折流生物膜反应器处理生活污水效能研究

折流生物膜反应器是一种以活性炭纤维组合的膜载体为折流挡板的新型污水处理工艺。考察了活性炭纤维表面生物膜的挂膜情况,并针对不同停留时间和碳氮比情况下,生物膜同时去除有机物和氮的效果。结果表明,折流状况下,活性炭纤维挂膜效果好,5d后生物膜厚度达到3~4mm;在水温为18~23℃,pH值为7.1~7.4,进水DO为4.5~5.4mg/L,停留时间为8h,碳氮比为10的条件下,对COD和NH+4-N的去除率分别达到80%和60%以上。     

SBR反应器内短程硝化系统快速启动及影响因素研究

探讨了采用序批式反应器(SBR)快速启动自养短程硝化系统的方法,研究了溶解氧(DO)、pH、温度、外加有机碳源对自养短程消化系统的影响。以硝化污泥接种反应器(SBR),在纯自养条件下利用高浓度溶解氧1.0～1.6mg/L和中温(35±1)℃达到亚硝酸氮的快速积累。结果表明,在进水氨氮浓度为280～300mg/L,HRT为12h,控制pH值为7.5～8.5、温度在(28±1)℃、溶解氧浓度为0.8～1.2mg/L条件下,氨氮去除率达到90%以上,亚硝酸氮积累率高达95%。试验证明投加有机碳源(COD)50mg/L左右时,不会对短程硝化系统产生影响,且能实现较高氨氮去除率和稳定的亚硝酸氮积累率。     

一个中小型中药厂生产废水处理运行实例

采用“水解（预处理）－ABR（厌氧）－UNITANK（好氧）”工艺处理中成药废水,电气控制部分采用可编程PLC系统。废水站全天24h全自动连续运行,无人值守。进水CODo约2000～5000ms／L,出水水质达到GB8978—1996《污水综合排放标准》一级排放标准。     

Bio-reduction of nitrate from groundwater using a hydrogen-based membrane biofilm reactor

A hydrogen-based membrane biofilm reactor(MBfR) using H2 as electron donor was investigated to remove nitrate from groundwater.When nitrate was first introduced to the MBfR,denitrification took place on the shell side of the membranes immediately,and the effluent concentration of nitrate continuously decreased with 100% removal rate on day 45 under the influent nitrate concentration of 5 mg NO3--N/L,which described the acclimating and enriching process of autohydrogenotrophic denitrification bacteria.A series of short-term experiments were applied to investigate the effects of hydrogen pressures and nitrate loadings on denitrification.The results showed that nitrate reduction rate improved as H2 pressure increasing,and over 97% of total nitrogen removal rate was achieved when the nitrate loading increased from 0.17 to 0.34 g NO3--N/(m2 ·day) without nitrite accumulation.The maximum denitrification rate was 384 g N/(m3 ·day).Partial sulfate reduction,which occurred in parallel to nitrate reduction,was inhibited by denitrififcation due to the competition for H2 .This research showed that MBfR is effective for removing nitrate from the contaminated groundwater.     

Efficient degradation of lube oil by a mixed bacterial consortium

A laboratory study was performed to assess the biodegradation of lube oil in bio-reactor with 304# stainless steel as a biofilm carrier. Among 164 oil degrading bacterial cultures isolated from oil contaminated soil samples, Commaonas acidovorans Px1, Bacillus sp. Px2, Pseudomonas sp. Px3 were selected to prepare a mixed consortium for the study based on the efficiency of lube oil utilization. The percentage of oil degraded by the mixed bacterial consortium decreased slightly from 99% to 97.2% as the concentration of lube oil was increased from 2000 to 10,000 mg/L. The degradation of TDOC (total dissolved organic carbon) showed a similar tendency compared with lube oil removal, which indicated that the intermediates in degradation process hardly accumulated. Selected mixed bacterial consortium showed their edge compared to activated sludge. Scanning electron microscopy (SEM) photos showed that biofilms on stainless steel were robust and with a dimensional framework constructed by EPS (extracellular polymeric substances), which could promote the biodegradation of hydrocarbons. The increase of biofilm followed first-order kinetics with rate of 0.216 μg glucose/(cm2·day) in logarithm phase. With analysis of Fourier transform infrared spectroscopy (FT-IR) and gas chromatography-mass spectrometry (GC-MS) combined with removal of lube oil and TDOC, mixed bacterial consortium could degrade benzene and its derivatives, aromatic ring organic matters with a percentage over 97%.     

常温处理生活污水微氧高效颗粒污泥反应器内颗粒污泥性能研究

为了分析微氧高效颗粒污泥反应器(EGSB反应器)在环境温度下处理实际生活污水时高效稳定运行的可行性,对15~26℃常温处理实际生活污水微氧EGSB反应器内颗粒污泥活性、沉淀性能、粒径分配、形态等进行研究.结果表明,15~26℃常温处理实际生活污水微氧EGSB反应器稳定运行时颗粒污泥沉速在11~79m·h-1之间,低沉速污泥有少量上浮至三相分离器底部甚至三相分离器上部,但没有出现污泥的流失,污泥浓度达到28g·L-1（以MLSS计）,可获得93.4%、83.8%、74.7%和44.0%的高COD、NH+4-N、TN和TP去除率;污泥产甲烷活性并没有降低,甚至比单纯厌氧时还有所偏高;颗粒污泥的平均粒径增大,主要集中0.63~2.00mm之间,质量分数达到了89%,既能保证反应器内的高污泥浓度,又能保证污染物质向颗粒表面和颗粒内部的高效传质,提高污染物质的转化率.颗粒污泥不同层面上微生物菌群发生了很大变化,外层丝状菌占优势,内层杆菌、丝状菌、球菌混生.微生物菌群排列紧密,细胞间紧密结合,集群协同作用使代谢物质能够以最短距离高效传递,保证了微氧EGSB反应器在常温、低浓度下的高效稳定运行.     

Influence of the wastewater composition on denitrification and biological P-removal in the S-DN-P process： （c） Dissolved and undissolved substrates

The denitrification and P-removal in the sorption-denitrification-P-removal (S-DN-P) process were carried out under various wastewater compositions. It is noted that P-removal largely depends on the wastewater composition as well to the quantity of the substrates present in wastewater fraction. Three different wastewater fractions are obtained as: raw wastewater, dissolved wastewater (obtained with filtration using 0.45 μm filter), and undissolved wastewater (i.e., infiltrate obtained by above filtration). ...     

水流紊动特性对活性污泥沉降性能的影响

为优化活性污泥处理系统的设计和运行,在SBR反应器中通过改变搅拌浆的转速,调整水流的紊动条件,借助粒子图像测速技术分析了反应器内水流的紊动特性,研究了反应器内不同区域紊动强度对活性污泥沉降性能的影响.结果表明,搅拌浆叶周围15mm的范围内,紊动强度远高于距桨叶更远的区域,距离浆板5mm的1-1断面和距离浆板60mm的3-3断面搅拌轴心处的紊动强度值分别反映了反应器搅拌主体区和其他区的紊动特征.随搅拌浆转速的增加,反应器内各区域的紊动强度逐渐增加,活性污泥的沉降性能表现出先改善后恶化的规律.当反应器搅拌主体区紊动强度1.51%,其他区紊动强度0.31%时,本试验条件下形成的活性污泥沉降指数(SVI)达到最小值67mL/g,界面沉降速率(ZSV)达到最大值0.20mm/s,活性污泥的沉降性能最佳.搅拌主体区范围较小,紊动强度较高,增强该区的紊动强度会加剧污泥的侵蚀破坏;其他区范围较大,紊动强度较低,增强该区的紊动强度对改善污泥的沉降效果作用明显.工程中可通过降低搅拌主体区的紊动强度,选择其他区适当的紊动强度,改善活性污泥的沉降性能.     

上流式多级厌氧反应器（UMAR）处理木薯淀粉废水的研究

对自行研制的上流式多级厌氧反应器（UMAR）处理木薯淀粉废水的启动和运行特性进行了研究.结果表明,UMAR反应器启动周期短,易培养出活性高的颗粒污泥,经过40 d的运行,COD去除率可达84%,VSS/TSS由78%增加到90.4%.UMAR处理效率高,水力停留时间（HRT）为4 h,进水COD为6 250 mg/L,容积负荷为24 kg/(m³·d)时, COD去除率在75%以上.UMAR反应器对负荷提高、低pH冲击、进水水质的改变表现出良好的耐受能力.     

湿地介质高炉矿渣磷吸附与再生能力研究

通过批实验和长期动态柱实验评价了湿地介质高炉矿渣吸附和截留P能力,并利用水位落干操作提高P吸附再生能力.结果表明,长期柱实验可以精确评价矿渣吸附磷的能力,矿渣磷截留能力达到1.65 g/kg;湿地保持落干4周,磷吸附能力再生,吸附能力提高58％.矿渣磷吸附饱和后磷组分分析得到树脂提取磷(P₁）占13％,Fe-P 39%,Al-P 21%,Ca-P 13%(1 mol/L HCl),Ca-P 14%(热浓HCl).吸附饱和前后X射线荧光衍射分析介质成分发现：K₂O和P₂O₅分别提高3倍和1.7倍,Al₂O₃和FeO提高8％.高炉矿渣吸附特性的研究表明该材料能长期有效去除P,适当干湿交替操作可以延长人工湿地运行年限.