活性染料染色模拟液的电化学混凝研究

本文以铁电极电解装置处理活性翠篮K-GL及活性红M-8B染料染色模拟液,研究了电流密度,溶液pH值同模拟液脱色率及COD去除率的关系,同时还考察了PVA对于模拟液脱色及去除COD的影响。     

用Fe3+掺杂锐钛矿型TiO2光催化剂降解孔雀石绿

以硫酸钛为原料,用水热法制备了Fe3+掺杂锐钛矿型TiO2(Fe3+ - TiO2)粉末,用扫描电子显微镜测定了试样的形貌.研究了自制的Fe3+ - TiO,光催化剂对孔雀石绿的光催化降解作用.实验结果表明,在孔雀石绿溶液质量浓度为2 mg/L、Fe3+ - TiO2加入量为1.616 g/L、Fe3+-TiO2中Fe...     

铁屑协同玉米芯/花生壳处理玛瑙染色废水

针对农村玛瑙染色工业废水中存在高浓度Cr(Ⅵ)、SO42-和H+等污染严重、难处理的问题,基于玉米芯、花生壳和铁屑,分别构造了1#(玉米芯)、2#(花生壳)、3#(铁屑+玉米芯)、4#(铁屑+花生壳)动态柱实验模型,研究了生物质材料及其与铁屑协同处理玛瑙染色废水中Cr(Ⅵ)、SO42-、H+的效果和机理.结果表明,铁屑+玉米芯、铁屑+花生壳动态柱对Cr(Ⅵ)、SO42-的平均去除率分别为95.97%、96.42%和72.17%和59.55%,高于玉米芯、花生壳动态柱的89.67%、90.74%和39.00%、28.73%的平均去除率,且具有较强的抗污染负荷变化和一定的pH值提升的能力.对比分析可见,经过铁屑强化的生物质动态柱对Cr(Ⅵ)、SO42-、H+有更好、更稳定的去除效果.     

Effects of initial iron corrosion rate on long-term performance of iron permeable reactive barriers: Column experiments and numerical simulation

Column experiments and numerical simulation were conducted to test the hypothesis that iron material having a high corrosion rate is not beneficial for the long-term performance of iron permeable reactive barriers (PRBs) because of faster passivation of iron and greater porosity loss close to the influent face of the PRBs. Four iron materials (Connelly, Gotthart-Maier, Peerless, and ISPAT) were used for the column experiments, and the changes in reactivity toward cis-dichloroethene (cis-DCE) degradation in the presence of dissolved CaCO₃ were evaluated. The experimental results showed that the difference in distribution of the accumulated precipitates, resulting from differences in iron corrosion rate, caused a difference in the migration rate of the cis-DCE profiles and a significant difference in the pattern of passivation, indicating a faster passivation in the region close to the influent end for the material having a higher corrosion rate. For the numerical simulation, the accumulation of secondary minerals and reactivity loss of iron were coupled using an empirically-derived relationship that was incorporated into a multi-component reactive transport model. The simulation results provided a reasonable representation of the evolution of iron reactivity toward cis-DCE treatment and the changes in geochemical conditions for each material, consistent with the observed data. The simulations for long-term performance were also conducted to further test the hypothesis and predict the differences in performance over a period of 40 years under typical groundwater conditions. The predictions showed that the cases of higher iron corrosion rates had earlier cis-DCE breakthrough and more reduction in porosity starting from near the influent face, due to more accumulation of carbonate minerals in that region. Therefore, both the experimental and simulation results appear to support the hypothesis and suggest that reactivity changes of iron materials resulting from evolution of geochemical conditions should be considered in the design of iron PRBs.     

生物炭负载硫化改性纳米零价铁去除水中的Cr(Ⅵ)

为研发治理地下水Cr(Ⅵ)污染的可行除铬材料,以碳热法制得生物炭负载纳米零价铁（BC-nZVI）,并通过对BC-nZVI硫化改性制备得到改性材料（M-BC-nZVI）,采用除铬容量、铬铁比（Cr/Fe）、反应活性分析M-BC-nZVI的除铬优势,通过模拟柱试验建立失效速率模型,从而推算M-BC-nZVI完全失效的除铬容量,最后与相关文献数据进行对比,分析M-BC-nZVI除Cr(Ⅵ)的应用可行性。结果表明：M-BC-nZVI材料的除铬容量、Cr/Fe、拟一级反应速率常数（k_obs）分别是BC-nZVI的1.86倍、1.95倍和3.00倍,因此相对于BC-nZVI来说M-BC-nZVI更具除铬优势;各模拟柱在运行过程中无明显堵塞情况,且随着进水浓度的升高,M-BC-nZVI的失效速率常数变大。当失效除铬速率为初始除铬速率的1.0%、进水Cr(Ⅵ)浓度为5 mg/L时,除铬容量最高,可以达到12.70 mg/g;对比M-BC-nZVI与其他文献报道的铁基材料及铁基改性材料的Cr/Fe可知,M-BC-nZVI的Cr/Fe为其他文献的1.06~42.06倍,故从材料的除铬性能来看,M-BC-nZVI应用于可渗透反应墙处理地下水Cr(Ⅵ)污染可行。

     

铁屑去除地下水中Cr6+的试验研究

以铁屑和纯Fe0为供试介质处理地下水中Cr6 ,在不调节原水pH值情况下,通过室内对比试验发现铁屑比纯Fe0的去除效率高,且可使处理后水中Cr6 达到地下水质量标准的Ⅲ类标准,确定出铁屑去除Cr6 的最佳运行参数:铁屑与Cr6 的重量比为1395:1,反应时间为40 min,并分析讨论了其去除机理.     

金盆水库沉积物铁锰释放规律

针对分层型水库周期性厌氧问题,金盆水库利用人工强制混合充氧技术补充底部水体溶解氧,抑制沉积物中还原性污染物的释放.但受水库地形地貌的影响,人工强制混合充氧效率存在一定差异性,在曝气系统运行结束后部分较深区域上覆水体溶解氧迅速耗竭,导致污染物的再次释放.为探究铁锰在该条件下的释放规律及扩散强度,选取主库区代表性采样点,对沉积物间隙水及上覆水溶解态铁锰浓度分布进行测定,并计算沉积物-水界面处溶解态铁锰的扩散通量.结果表明,人工强制混合充氧结束后地势较低区域底部水体迅速进入厌氧状态,导致大量溶解态锰释放进入上覆水体,浓度最高达0.42mg·L~(-1);而地势较高区域底部水体短暂进入缺氧状态,之后溶解氧浓度迅速回升,因此底部溶解态锰浓度升高幅度较小,浓度最高为0.17mg·L~(-1).沉积物间隙水-上覆水铁锰浓度分布结果表明,由于铁锰氧化还原电位的差异,溶解态锰相较于铁在厌氧条件下更容易释放进入上覆水体,且不断在表层沉积物及上覆水体中积聚,而溶解态铁的释放不仅受溶解氧的抑制,还受锰氧化物等其他氧化剂的抑制.由扩散通量计算可知,人工强制混合充氧结束后溶解态锰的扩散通量有降低趋势.由质量平衡计算可知,溶解态锰在厌氧层中的积聚不仅与扩散通量有关,还与沉降通量、厌氧层厚度有关,因此厌氧层中铁锰的生物地球化学循环作用有待进一步的研究.     

Preparation and application of a phosphorous free and non-nitrogen scale inhibitor in industrial cooling water systems

A novel environmentally friendly type of calcium carbonate, zinc (II) and iron (III) scale inhibitor Acrylic acid- allylpolyethoxy carboxylate copolymer (AA-APEL) was synthesized. The anti-scale property of the AA-APEL toward CaCO₃, zinc (II) and iron (III) in the artificial cooling water was studied through static scale inhibition tests. The observation shows that both calcium carbonate, zinc (II) and iron (III) inhibition increase with increasing the dosage of AA-APEL. The effect on formation of CaCO₃ was investigated with combination of scanning electronic microscopy (SEM), transmission electron microscopy (TEM), X-ray powder diffraction (XRD) analysis and fourier transform infrared spectrometer, respectively. The results showed that the AA-APEL copolymer not only influenced calcium carbonate crystal morphology and crystal size but also the crystallinity. The crystallization of CaCO₃ in the absence of inhibitor was rhombohedral calcite crystal, whereas a mixture of calcite with vaterite crystals was found in the presence of the AA-APEL copolymer. Inhibition mechanism is proposed that the interactions between calcium or iron ions and polyethylene glycol (PEG) are the fundamental impetus to restrain the formation of the scale in cooling water systems.     

Washing out heavy metals from contaminated soils from an iron and steel smelting site

Washing is a promising method for separating contaminants bound to the particles of soil ex-situ by chemical mobilization. Laboratory batch washing experiments were conducted using deionized water and varying concentrations of oxalic acid, citric acid, tartaric acid, acetic acid, hydrochloric acid and ethylenediaminetetra acetic acid (EDTA) to assess the efficiency of using these chemicals as washing agents and to clean up heavy metals from two heavily polluted soils from an iron and streel smelting site. The toxicity reduction index and remediation costs were analyzed, and the results showed that the soils were polluted with Cd, Pb and Zn. Hydrochloric acid and EDTA were more efficient than the other washing agents in the remediation of the test soils. The maximum total toxicity reduction index showed that 0.5 mol·L^-1 hydrochloric acid could achieve the remediation with the lowest costs.     

硝基苯类物质在铜电极上的电还原特性及pH的影响

采用循环伏安法,对硝基苯类化合物在铜电极表面上的电还原特性进行了研究,评价了它们在铜电极上的电还原反应活性,并且讨论了这类物质在铜电极上的还原机理和酸度对它的影响.结果表明,硝基苯类化合物能在铜电极表面被直接还原;还原电位在-0.58V和-1.32V左右 (vs. SCE),酸度和碱度均有利于硝基在铜电极上的还原:在碱性条件下容易发生消去反应生成亚硝基;酸性条件下,得电子后的硝基与氢离子之间反应的几率就增大,导致通过溶液的电流值增加,另外,氢的增加也有利于电极上发生的加成和取代反应.pH对不同的硝基苯类物质在铜电极上的电还原特性有不同程度的影响,这主要取决于苯环上其它取代基的性质、结构、数量和它与硝基在苯环上的相对位置.实验结果为催化铁内电解法机理研究提供了理论和实验依据.