全程高温好氧堆肥快速降解城市生活垃圾

为了提高堆肥处理城市生活垃圾（MSW）的速率和质量,设计了一种外加热源的全程高温好氧堆肥工艺.实验以全程高温好氧堆肥和传统好氧堆肥两种方法对MSW进行了60d的堆肥处理.同时,监测了堆肥的pH和温度等参数的变化情况,并以C/N、种子发芽率(GI)、可溶性有机碳(DOC)、比好氧速率(SOUR)和脱氢酶（DH-ase）活性为指标评价了堆肥的腐熟度和质量.结果表明,全程高温堆肥法和传统堆肥法的堆肥周期分别为16d和28d,两种方法得到的产品其pH值均在7左右.在第31d将全程高温堆肥产品置于30℃恒温箱时,其理化性质没有出现明显波动,说明其堆肥产品性质稳定.因此,全程高温好氧堆肥法能明显缩短堆肥周期、提高堆肥质量,具有很大的应用潜力.     

船舶塑料垃圾热解特性及动力学分析

利用热重分析(TGA)研究船舶塑料垃圾在不同升温速率和不同气氛下的热解特性,并得到了热解动力学参数。结果表明,船舶塑料垃圾的热解过程主要有3个阶段,比一般塑料热解复杂;随着升温速率增大,最大热解速率和最大热解速率温度等热解特性参数也增大,反应变得更剧烈;N2/CO2比为4∶1时,热解反应进行得最完全,固体残留率最少。动力学分析表明,采用3个连续一级反应模型能很好地拟合实验数据;不同的升温速率和气氛比对反应各阶段活化能均有不同程度的影响。     

丁二烯装置中乙烯基乙炔危险性研究

根据丁二烯装置中高级炔烃的特点和危险性,通过爆炸极限测定仪和爆轰管研究并确定了温度对乙烯基乙炔爆炸极限的影响,确定了不同温度下乙烯基乙炔的安全分压,确定了氮气稀释对乙烯基乙炔安全分压的影响,掌握了乙烯基乙炔的燃爆特性和分解特性。研究表明:乙烯基乙炔易发生分解失控或气相燃爆,且发生分解失控时后果严重。为了确保丁二烯装置中乙烯基乙炔的安全使用,建议在低温和低分压下使用乙烯基乙炔。     

武汉市秸秆燃烧VOCs排放估算及管理对策

秸秆燃烧是我国人为源挥发性有机物(volatile organic compounds,VOCs)排放的重要来源之一,其排放对气候变化和人体健康都有很大影响.对该来源VOCs排放量的可靠估算是在区域或城市范围内进行排放效应分析和污染控制的重要前提.根据2005~2011年武汉市农作物的总产量,采用排放因子分析法估算了武汉市及主要6个农作物产区的秸秆燃烧VOCs的排放量,并分别计算其耕地排放强度(I c)和区域排放强度(I r).结果表明,武汉市2005~2011年年均秸秆燃烧VOCs排放量约为(3 163±139)t,I c和I r分别为(1.52±0.06)t·km-2和(0.37±0.02)t·km-2.粮食类和油料类农作物秸秆燃烧是主要的排放源,需优先控制7大类21种VOCs物质.武汉市分区VOCs排放量从大到小排序依次为黄陂区、新洲区、江夏区、蔡甸区、汉南区、东西湖区,前4个区的排放总量占到武汉市的近九成.江夏区、汉南区、黄陂区和新洲区应作为秸秆燃烧VOCs排放的优先控制区,尤其是能作为全国代表性的江夏区,应引起高度重视.在进行区域或城市范围的秸秆燃烧产生污染物质的生态风险评价时,该污染物的I c和I r都是需要考虑的重要基础数据.最后,提出大力发展农村秸秆资源综合循环经济利用是解决区域或城市范围内秸秆燃烧产生环境问题的可行之径.     

Emissions of SO2, NO and N2O in a circulating fluidized bed combustor during co-firing coal and biomass

This paper presents the experimental investigations of the emissions of SO2, NO and N2O in a bench scale circulating fluidized bed combustor for coal combustion and co-firing coal and biomass. The thermal capacity of the combustor is 30 kW. The setup is electrically heated during startup. The influence of the excess air, the degree of the air staging, the biomass share and the feeding position of the fuels on the emissions of SO2, NO and N2O were studied. The results showed that an increase in the biomass shares resulted in an increase of the CO concentration in the flue gas, probably due to the high volatile content of the biomass. In co-firing, the emission of SO2 increased with increasing biomass share slightly, however, non-linear increase relationship between SO2 emission and fuel sulfur content was observed. Air staging significantly decreased the NO emission without raising the SO2 level. Although the change of the fuel feeding position from riser to downer resulted in a decrease in the NO emission level, no obvious change was observed for the SO2 level. Taking the coal feeding position R as a reference, the relative NO emission could significantly decrease during co-firing coal and biomass when feeding fuel at position D and keeping the first stage stoichiometry greater than 0.95. The possible mechanisms of the sulfur and nitrogen chemistry at these conditions were discussed and the ways of simultaneous reduction of SO2, NO and N2O were proposed.     

吨量煤体的自燃过程实验模拟研究

为更好地弄清矿井实际的煤自然发火规律,利用装煤量达5吨的大型实验台对两种烟煤分别进行了自燃模拟实验。大煤量的实验能够很好地模拟煤矿中煤低温氧化和传热传质共同作用导致的发火过程,实验得到的自然发火期与煤矿实际发火期也是一致的。实验中煤样从缓慢氧化变为快速氧化的临界温度为100～110℃。当煤温低于,临界温度时,煤样的升温受到空气流带走热量和向外界散热的影响很大,因此夹层水的保温作用就很关键。当煤温超过临界温度后,反应加快,温度急剧上升,散热的影响明显降低,反应主要受限于氧气的供应情况。     

不同点火模式下软质聚氨酯泡沫燃烧的实验研究

为研究软质聚氨酯泡沫(FPUF)的燃烧行为对火灾的影响,采用锥形量热仪(CONE)分析FPUF在强制点火和非强制点火模式下的燃烧行为、热释放速率HRR、质量损失速率MLR和燃烧效率η。研究结果表明：当外部辐射≥40 kW/m²时,FPUF在2种点火模式下燃烧的HRR和MLR均出现2个明显的峰值且η约为88%;当外部辐射<40 kW/m²时,FPUF在非强制点火模式下燃烧的HRR和MLR曲线趋于单峰形式;FPUF在强制点火模式下燃烧前期为异氰酸酯(TDI)和多元醇的混合燃烧,在非强制点火模式下为TDI的挥发。根据研究结果修正现有燃料组分的热值计算方法,获得FPUF和多元醇的热值分别为(20±2),(28±3) kJ/g。     

居民电子废物回收行为影响因素的实证研究

基于对350名城市居民的问卷调查结果,运用验证性因子分析方法对居民的电子废物回收行为、行为意向及其影响因素进行了实证研究.结果表明,基于计划行为理论所建立的结构方程模型可以较为有效地诠释有关研究假设,环境知识、舆论宣传和垃圾分类等情境因素对电子废物回收行为具有调节作用.知觉行为控制对于行为意向转化为行为具有非常重要地促进作用,而便利状况则是影响知觉行为控制的重要因素.     

Antimicrobial activity of thin metallic silver flakes, waste products of a manufacturing process

The aim of the research was to develop new products and processes from a manufacturing waste from an Italian metallurgic company. The company produced thin silver metallic films and the production scraps were silver flakes. The possibility to use the silver flakes in water disinfection processes was studied. The antimicrobial activity of the flakes was investigated in batch using Escherichia coli as Gram-negative microorganism model. The flakes did not show any antimicrobial activity, so they were activated with two different processes: thermal activation in reducing atmosphere and chemical activation, obtaining, respectively, reduced flakes (RF) and chemical flakes (CF). The flakes, activated with either treatment, showed antimicrobial activity against E. coli. The kill rate was dependent on the type of activated flakes. The chemical flakes were more efficient than reduced flakes. The kill rate determined for 1 g of CF, 1.0 ± 0.2 min⁻¹, was greater than the kill rate determined for 1 g of RF, 0.069 ± 0.004 min⁻¹. This was confirmed also by the minimum inhibitory concentration values. It was demonstrated that the antimicrobial capability was dependent on flakes amount and on the type of aqueous medium. Furthermore, the flakes maintained their properties also when used a second time. Finally, the antimicrobial activities of flakes were tested in an effluent of a wastewater treatment plant where a variety of heterotrophic bacteria were present.     

农作物废料对海洋溢油吸附研究

根据海上围油栏围油原理,使用小型围油设备模拟出在围油栏除油后海上剩余溢油的质量M。收集稻壳、小米壳、小麦壳3种农作物废料作为吸油材料,室温下分别测出3种吸油材料对质量为M的溢油的饱和吸附时间。在吸附平衡的条件下,利用紫外分光光度计分别测出3种吸油材料吸附海水表面M质量溢油后的平衡吸附浓度ce。根据物理吸附理论,由平衡吸附浓度ce和平衡吸附量qe分别得出3种材料的Freundlich吸附等温式,从Freundlich吸附等温式比较了3种农作物废料的吸油性能。结果表明:稻壳的吸油性能最佳。