不同有机废水厌氧产酸过程的研究

主要研究了不同类废弃有机物厌氧产酸过程中产生的挥发性脂肪酸的产量和组成比例。研究发现,废糖蜜溶液、蛋白废液和淀粉废液在达到最高产酸量时,超过50%的VFAs是乙酸,其次是丙酸,还含有少量的丁酸和戊酸。废甘油溶液在达到最高产酸量时,产生的VFAs的主要成分是丙酸。4种有机废液中,相同初始COD浓度条件下,淀粉废液产生的VFAs产量最多,初始COD为5000mg/L时最高产量为2.321g/L,其次是废甘油溶液,最高产量是2.244g/L。     

密封充氢环境条件下固态电化学氢气传感器效应试验研究

目的研究密闭充氢环境下固态电化学氢气传感器效应。方法设计能模拟低氧、低氢和压力变化的密闭充氢环境,并在此环境中进行一系列氢气传感器效应试验,分析、评定试验数据。结果得到了不同环境下氢气、氧气浓度随时间变化的规律,提出固态电化学氢气传感器的有效工作环境,并预测了其在不同贮存环境下的工作寿命。结论密闭充氢环境内压力和温度的变化对固态电化学氢气传感器影响较大,湿度影响较小,注气检定合格的氢气传感器,在密封容器内扩散式检定,不合格率高,检定数据误差大于±5%FS。     

秸秆厌氧发酵产沼气技术现状进展

秸秆是世界上数量最大的可再生资源,但是秸秆内木质纤维素的复杂结构和难降解性限制了秸秆的应用,因此秸秆预处理成为秸秆发酵产气的重要一环。本文介绍了木质纤维素预处理物理技术、化学技术、生物技术、联合处理技术和秸秆厌氧发酵研究进展,并对秸秆预处理技术前景进行展望。     

生物酶对初沉污泥厌氧发酵产短链脂肪酸的调控研究

旨在通过生物酶调节(碱性蛋白酶、中性蛋白酶和α-淀粉酶)提高初沉污泥的厌氧发酵效率,并通过微生物群落结构解析,SCFAs (short-chain fatty acids,SCFAs)组分分析等揭示其调控机理.结果表明,3种生物酶均可增强初沉污泥水解和产酸作用,碱性蛋白酶调控系统对初沉污泥厌氧发酵的促进效果最为明显,发酵第4d SCFAs的产量和产率分别达到1508mg COD/L和0.174g COD/g VSS.对比控制组,SCFAs的产量和产率分别增加了1129mg COD/L和0.13g COD/g VSS.微生物群落结构分析表明,在碱性蛋白酶调控发酵系统中,Lentimicrobium、Proteiniphilum和Bacteroides等发酵相关菌群的相对丰度得到了改善,Methanosaeta、Methanospirillum等产甲烷古菌的活性受到了抑制.同时,生物酶调控对促进发酵过程乙酸占比也有促进作用.     

Potassium ferrate pretreatment promotes short chain fatty acids yield and antibiotics reduction in acidogenic fermentation of sewage sludge

During the acidogenic fermentation converting waste activated sludge (WAS) into short-chain fatty acids (SCFA), hydrolysis of complex organic polymers is a limiting step and the transformation of harmful substances (such as antibiotics) during acidogenic fermentation is unknown. In this study, potassium ferrate (K₂FeO₄) oxidation was used as a pretreatment strategy for WAS acidogenic fermentation to increase the hydrolysis of sludge and destruct the harmful antibiotics. Pretreatment with K₂FeO₄ can effectively increase the SCFA production during acidogenic fermentation and change the distribution of SCFA components. With the dosage of 0.2 g/g TS, the maximum SCFA yield was 4823 mg COD/L, which is 28.3 times that of the control group; acetic acid accounts for more than 90% of the total SCFA. The higher dosage (0.5 g/g TS) can further increase the proportion of acetic acid, but inhibit the overall performance of SCFA production. Apart from the promotion of hydrolysis and acidogenesis, K₂FeO₄ pretreatment can also simultaneously oxidizes and degrades part of the antibiotics in the sludge. When the dosage is 0.5 g/g TS, the degradation efficacy of antibiotics is the most significant, and the contents of ofloxacin, azithromycin, and tetracycline in the sludge are reduced by 69%, 42%, and 50%, respectively. In addition, K₂FeO₄ pretreatment can also promote the release of antibiotics from sludge flocs, which is conducive to the simultaneous degradation of antibiotics in the subsequent biological treatment process.     

不同堆沤处理对玉米秸秆厌氧发酵的影响

研究利用纤维素分解菌F2对玉米秸秆进行堆沤预处理,将经不同堆沤预处理时间后的秸秆与猪粪混合进行厌氧发酵产沼气试验。结果发现,堆沤15 d后秸秆的总有机碳含量降低了10.06%,VS去除率和纤维素降解率比未加菌堆沤预处理分别提高了10.74%、10.60%;加菌堆沤预处理后的秸秆厌氧发酵甲烷产气率、干物质产气率、发酵前后VS去除率均高于未加菌堆沤预处理后的秸秆,且产气效率也有明显的提高;加菌堆沤预处理10 d的秸秆比未加菌堆沤预处理15 d的秸秆提前了2 d达到产气高峰,累计产气量达到21 957 mL,比未加菌堆沤预处理15 d的秸秆增加了1 629 mL。实验结果表明:该纤维素分解菌对玉米秸秆纤维素有较强的降解能力,并在一定程度上促进了有机碳的矿化;有效地提高了秸秆的生物降解性能,缩短了预处理所需时间;同时提高了玉米秸秆的利用率和产气潜力。     

餐厨垃圾综合资源化处理技术实例研究

在目前餐厨垃圾处理现状基础上,介绍了一种餐厨垃圾处理工艺,采用机械生物处理技术,包括收运系统、粉碎分选预处理、厌氧发酵生物处理、沼气热电联供、有机堆肥、废水处理、除臭系统多个环节,分离出油脂进行回收,垃圾厌氧发酵产生沼气发电,沼渣进行堆肥,以期实现餐厨垃圾减量化、无害化、资源化,解决"垃圾猪"、"地沟油"问题。     

耦合发酵产氢尾液处理的微生物电化学系统研究

区别于传统的稀释或加缓冲剂调节pH值的方法,本文提出采用微生物电解池（MEC）电调控暗发酵尾液pH值,并进一步采用微生物电合成系统（MES）降解废液产甲烷.结果表明,在MEC处理产氢暗发酵尾液过程中,伴随着阴极侧氢气的产生,暗发酵尾液中大量H⁺被消耗,溶液pH值从4.5升高到8.7;随后在MES中,产氢发酵尾液中有机物被进一步降解产生甲烷,其平均产甲烷速率达到4.5mmol/（L·d）,且在21d内化学需氧量（COD）去除率达到89%,远优于没有经过pH调控的产氢发酵尾液MES中的产甲烷性能.     

Methane fermentation of dung from litter-free reared domestic animals — an optimisation study

Data on the quantity (27 453 tons from litter-free reared animals in Bulgaria, only) and the chemical and energy characteristics of dung produced in intensive management farms for domestic animals suggests that technologies combining biogenic elements recycling with energy utilistation and dung decontamination are expedient to be applied on these types of farms. To this effect a fermenter was designed and a mathematical model (a Chen-Hashimoto model based computer programme) was applied, as a result of which the optimum methane fermentation parameters were determined. The technological methane output (Y_v) — indicator of biogas production efficiency (output/dm³ fermentor volume) showed an optimum at temperature 55°C and period of exchange 6 days. The methane output per unit mineralised organic matter in the substrate (B) — assumed as an indicator of ecological efficiency (maximum organic matter degradation) exhibited an optimum at 33°C for 15 days period of exchange.     

Fe和Fe2+对混合细菌产氢发酵的影响

在研究Fe粉剂量和Fe²⁺浓度对混合细菌产氢发酵的影响基础上,确定Fe和Fe²⁺促进混合细菌产氢能力的最佳阈值,并对乙醇型发酵菌群在不同Fe粉和Fe²⁺浓度下的产氢量和最大比产氢速率进行考察和对比.结果表明,Fe粉和Fe²⁺对乙醇型发酵菌群的产氢能力均有明显的促进作用.以葡萄糖为底物,投加Fe²⁺试验中,Fe²⁺浓度200mg/L获得最大产氢量143.7mL/g,较对照组提高32%;Fe²⁺浓度50mg/L获得单位VSS最大比产氢速率21.2 mL/(h·g),较对照组提高33%.投加单质Fe试验中,Fe粉剂量1000mg/L获得最大产氢量156.1mL/g,较对照组提高44%;Fe粉剂量500mg/L获得单位VSS最大比产氢速率23.5mL/(h·g),较对照组分别提高47%.单质Fe浓度高于50mg/L时,对发酵菌群产氢的促进作用要优于同浓度下的Fe²⁺.同时对混合细菌中铁的全量和形态分布进行了考察.