生物酶对初沉污泥厌氧发酵产短链脂肪酸的调控研究

旨在通过生物酶调节(碱性蛋白酶、中性蛋白酶和α-淀粉酶)提高初沉污泥的厌氧发酵效率,并通过微生物群落结构解析,SCFAs (short-chain fatty acids,SCFAs)组分分析等揭示其调控机理.结果表明,3种生物酶均可增强初沉污泥水解和产酸作用,碱性蛋白酶调控系统对初沉污泥厌氧发酵的促进效果最为明显,发酵第4d SCFAs的产量和产率分别达到1508mg COD/L和0.174g COD/g VSS.对比控制组,SCFAs的产量和产率分别增加了1129mg COD/L和0.13g COD/g VSS.微生物群落结构分析表明,在碱性蛋白酶调控发酵系统中,Lentimicrobium、Proteiniphilum和Bacteroides等发酵相关菌群的相对丰度得到了改善,Methanosaeta、Methanospirillum等产甲烷古菌的活性受到了抑制.同时,生物酶调控对促进发酵过程乙酸占比也有促进作用.     

Potassium ferrate pretreatment promotes short chain fatty acids yield and antibiotics reduction in acidogenic fermentation of sewage sludge

During the acidogenic fermentation converting waste activated sludge (WAS) into short-chain fatty acids (SCFA), hydrolysis of complex organic polymers is a limiting step and the transformation of harmful substances (such as antibiotics) during acidogenic fermentation is unknown. In this study, potassium ferrate (K₂FeO₄) oxidation was used as a pretreatment strategy for WAS acidogenic fermentation to increase the hydrolysis of sludge and destruct the harmful antibiotics. Pretreatment with K₂FeO₄ can effectively increase the SCFA production during acidogenic fermentation and change the distribution of SCFA components. With the dosage of 0.2 g/g TS, the maximum SCFA yield was 4823 mg COD/L, which is 28.3 times that of the control group; acetic acid accounts for more than 90% of the total SCFA. The higher dosage (0.5 g/g TS) can further increase the proportion of acetic acid, but inhibit the overall performance of SCFA production. Apart from the promotion of hydrolysis and acidogenesis, K₂FeO₄ pretreatment can also simultaneously oxidizes and degrades part of the antibiotics in the sludge. When the dosage is 0.5 g/g TS, the degradation efficacy of antibiotics is the most significant, and the contents of ofloxacin, azithromycin, and tetracycline in the sludge are reduced by 69%, 42%, and 50%, respectively. In addition, K₂FeO₄ pretreatment can also promote the release of antibiotics from sludge flocs, which is conducive to the simultaneous degradation of antibiotics in the subsequent biological treatment process.     

不同堆沤处理对玉米秸秆厌氧发酵的影响

研究利用纤维素分解菌F2对玉米秸秆进行堆沤预处理,将经不同堆沤预处理时间后的秸秆与猪粪混合进行厌氧发酵产沼气试验。结果发现,堆沤15 d后秸秆的总有机碳含量降低了10.06%,VS去除率和纤维素降解率比未加菌堆沤预处理分别提高了10.74%、10.60%;加菌堆沤预处理后的秸秆厌氧发酵甲烷产气率、干物质产气率、发酵前后VS去除率均高于未加菌堆沤预处理后的秸秆,且产气效率也有明显的提高;加菌堆沤预处理10 d的秸秆比未加菌堆沤预处理15 d的秸秆提前了2 d达到产气高峰,累计产气量达到21 957 mL,比未加菌堆沤预处理15 d的秸秆增加了1 629 mL。实验结果表明:该纤维素分解菌对玉米秸秆纤维素有较强的降解能力,并在一定程度上促进了有机碳的矿化;有效地提高了秸秆的生物降解性能,缩短了预处理所需时间;同时提高了玉米秸秆的利用率和产气潜力。     

餐厨垃圾综合资源化处理技术实例研究

在目前餐厨垃圾处理现状基础上,介绍了一种餐厨垃圾处理工艺,采用机械生物处理技术,包括收运系统、粉碎分选预处理、厌氧发酵生物处理、沼气热电联供、有机堆肥、废水处理、除臭系统多个环节,分离出油脂进行回收,垃圾厌氧发酵产生沼气发电,沼渣进行堆肥,以期实现餐厨垃圾减量化、无害化、资源化,解决"垃圾猪"、"地沟油"问题。     

耦合发酵产氢尾液处理的微生物电化学系统研究

区别于传统的稀释或加缓冲剂调节pH值的方法,本文提出采用微生物电解池（MEC）电调控暗发酵尾液pH值,并进一步采用微生物电合成系统（MES）降解废液产甲烷.结果表明,在MEC处理产氢暗发酵尾液过程中,伴随着阴极侧氢气的产生,暗发酵尾液中大量H⁺被消耗,溶液pH值从4.5升高到8.7;随后在MES中,产氢发酵尾液中有机物被进一步降解产生甲烷,其平均产甲烷速率达到4.5mmol/（L·d）,且在21d内化学需氧量（COD）去除率达到89%,远优于没有经过pH调控的产氢发酵尾液MES中的产甲烷性能.     

Methane fermentation of dung from litter-free reared domestic animals — an optimisation study

Data on the quantity (27 453 tons from litter-free reared animals in Bulgaria, only) and the chemical and energy characteristics of dung produced in intensive management farms for domestic animals suggests that technologies combining biogenic elements recycling with energy utilistation and dung decontamination are expedient to be applied on these types of farms. To this effect a fermenter was designed and a mathematical model (a Chen-Hashimoto model based computer programme) was applied, as a result of which the optimum methane fermentation parameters were determined. The technological methane output (Y_v) — indicator of biogas production efficiency (output/dm³ fermentor volume) showed an optimum at temperature 55°C and period of exchange 6 days. The methane output per unit mineralised organic matter in the substrate (B) — assumed as an indicator of ecological efficiency (maximum organic matter degradation) exhibited an optimum at 33°C for 15 days period of exchange.     

Fe和Fe2+对混合细菌产氢发酵的影响

在研究Fe粉剂量和Fe²⁺浓度对混合细菌产氢发酵的影响基础上,确定Fe和Fe²⁺促进混合细菌产氢能力的最佳阈值,并对乙醇型发酵菌群在不同Fe粉和Fe²⁺浓度下的产氢量和最大比产氢速率进行考察和对比.结果表明,Fe粉和Fe²⁺对乙醇型发酵菌群的产氢能力均有明显的促进作用.以葡萄糖为底物,投加Fe²⁺试验中,Fe²⁺浓度200mg/L获得最大产氢量143.7mL/g,较对照组提高32%;Fe²⁺浓度50mg/L获得单位VSS最大比产氢速率21.2 mL/(h·g),较对照组提高33%.投加单质Fe试验中,Fe粉剂量1000mg/L获得最大产氢量156.1mL/g,较对照组提高44%;Fe粉剂量500mg/L获得单位VSS最大比产氢速率23.5mL/(h·g),较对照组分别提高47%.单质Fe浓度高于50mg/L时,对发酵菌群产氢的促进作用要优于同浓度下的Fe²⁺.同时对混合细菌中铁的全量和形态分布进行了考察.     

调节细胞通透性促进天蓝色链霉菌蓝色素生物合成

在天蓝色链霉菌分批发酵中，36h时一次加入20mg/L的青霉素，色素浓度和分泌率分别提高了26．2％和39．2％；与一次性添加青霉素相比，分多次添加可使色素浓度再提高9％，但分泌率没有明显变化。DMSO浓度为6g/L时，色素浓工和分泌率较对照分别提高了20．5％和50％；2－50g/L的DMSO对菌体生长没有影响。36h时lg/L的吐温80，色素浓度和分泌率分别提高了16．9％和37．5％，60h时加入0.2g/L浓度的SDS，色素浓度较对照基本相当，但分泌率却提高了16．1％。图4表1参7     

基于动力学分析提高黑木耳多糖产量的pH控制策略

为了实现黑木耳(Auriculariaauricula)深层发酵生产胞外多糖的高产量和高生产强度的统一,在7L发酵罐中研究不同pH对A.auricula分批发酵生产黑木耳多糖的影响.A.auricula细胞生长的最适pH为5.0,而黑木耳胞外多糖合成的最适pH为5.5.恒定pH有利于合成黑木耳多糖,但降低了黑木耳多糖的生产强度.发酵液中较高的pH不利于葡萄糖的消耗,使得发酵结束时的残余葡萄糖含量随pH的升高而升高.分析不同pH条件下A.auricula发酵生产黑木耳多糖动力学参数,发现较低pH有利于加快底物消耗,而较高的细胞生长速率则出现在pH5.0,pH5.5时细胞则具有较高的胞外多糖合成速率和对葡萄糖的得率.在此基础上提出了A.auricula发酵生产黑木耳多糖的两阶段pH控制策略:0~48h控制发酵液pH5.0,48h后控制pH5.5.实验结果表明,采用两阶段pH控制策略,A.auricula胞外多糖产量比控制pH5.5时提高了8.1%,残留葡萄糖含量降低了15.2%,产生最大胞外多糖的时间缩短至96h,且黑木耳多糖的生产强度比pH5.5时提高了35.1%.图4表1参21     

厌氧发酵过程pH对微生物多样性和产物分布的影响

采用PCR-DGGE技术,研究了不同pH条件下蔬菜类有机垃圾厌氧发酵过程中的微生物多样性,探讨了微生物群落结构与发酵产物分布的关系.Shannon指数分析表明,pH=7和pH=8时的微生物多样性较高,随时间变化规律相似,而pH=5时的微生物多样性较低.UPGMA聚类分析和PCA分析结果也表明,pH=7和pH=8时的微生物群落结构相似,pH=5与之显著不同.在不同pH条件下的优势菌属都是乳酸细菌和梭菌。微生物多样性的变化与发酵产物分布具有一定相关性,pH通过影响微生物群落结构的变化最终影响发酵产物的分布.图4表2参27