油气田建设项目施工期环境监理探析

针对油气田建设项目的具体情况,对油气田建设项目施工期主要环境影响,包括钻井作业、输气站及输气管道建设工程中的主要环境影响进行了分析,从施工期的污染防治措施监理、生态保护措施监理、环境保护设施监理几个方面对施工期环境监理的主要内容进行了探讨。     

LCA of the South African sugar industry

A life cycle assessment of sugar produced in South Africa evaluates the environmental impacts and energy consumption of the different life cycle phases of sugar production. The system studied includes sugar cane farming, fertiliser and herbicide manufacture, cane burning, sugar cane transportation and sugar manufacture. Inventory and impact assessment results show that non-renewable energy consumption is 5350 MJ per tonne of raw sugar produced and 40% of this is from fertiliser and herbicide manufacture. Reduction in the use or impact of fertiliser for cane farming could bring considerable savings in terms of fossil energy consumption and a reduction in greenhouse gas emissions.     

Oxidation inhibition of sulfite in dual alkali FGD system

A laboratory-scale well-mixed thermostatic reactor with continuously blasting air was used to investigate the oxidation inhibition of sulfite in dual alkali flue gas desulfurization （FGD） system. The effects of operating parameters such as pH value and catalyst concentration on the oxidation were studied. Sodium thiosulfate was used in the system, and was found that it significantly inhabited the sulfite oxidation. In the absence of catalyst, sodium thiosulfate at 12.67 mmol/L had an inhibition efficiency of approximately 98%. While in the presence of catalyst, sodium thiosulfate at 26.72 mmol/L had an inhibition efficiency less than 85.0%. The oxidation reaction order of sulfite in the sodium thiosulfate was determined to be -1.90 and 4）.55 in the absence and presence of the catalyst, respectively. Apparent activation energy of oxidation inhibition was calculated to be 53.9 kJ/mol. Pilot tests showed that the consumption rate of thiosulfate agreed well with the laboratory-scale experimental results.     

再生条件对钾基CO_2吸附剂吸附性能的影响

通过固定床实验研究了再生条件对钾基CO2吸附剂吸附性能的影响。深入分析了再生温度和气氛对吸附穿透时间和饱和吸附量的影响。研究发现,当再生温度为200℃,N2气氛下再生时效果最佳,在此条件下再生后钾基CO2吸附剂循环性能良好,10次循环后仍然能有很好的吸附效果;再生气氛中有H2O或CO2时会影响再生反应的进行,不利于吸附剂的再生。     

彻底封闭烟气旁路挡板的可行性探索

随着环保标准的进一步提高,部分新建火电厂不再设置烟气旁路挡板,现有机组彻底封闭旁路挡板也是未来趋势。结合漳山电厂烟囱防腐期间,彻底封闭旁路挡板8个月的运行经验,阐述这种运行方式的逻辑修改和启动方式。经过实践证明,彻底封闭旁路挡板完全可行。     

电石炉炉气电改袋除尘技术

介绍了某厂3台20 000kVA内燃式电石炉炉气除尘系统由原来采用的电式除尘器改为袋式除尘器技术,同时将原系统内的增湿塔改造为强制风冷及预荷电、预除尘设备,这样不但可以降低烟气温度使其满足袋式除尘器对进口烟气温度的要求,同时使微细粉尘荷电凝聚,提高了后续袋式除尘器对颗粒的捕集效率,并降低了袋式除尘器的阻力损失。改造后的系统运行稳定,烟气出口排放浓度满足国家环保要求。     

危险及可操作性分析在LNG汽车加气站的应用

利用危险及可操作性分析(HAZOP)技术对液化天然气(LNG)汽车加气站卸车、调压和加液流程进行系统的危险分析和探讨,并提出建议措施。应用实例表明,HAZOP技术可有效地辨识LNG汽车加气站的风险,可作为LNG加气站风险管理的有效工具之一。     

吸附法油气回收系统在成品油库中的应用

介绍了活性炭吸附法油气回收系统在成品油库汽油装车过程中的应用情况。结合油库油气回收改造的实际情况,重点介绍了了吸附法油气回收装置的工艺流程、油库油气回收系统的组成、监控系统主要功能、环保检测的相关事项,并分析了油气回收系统的经济效益,结合实际经验对油库油气回收改造提出了建议。     

高碱性烟气脱硫灰中亚硫酸钙含量分析方法

针对烟气脱硫灰中的亚硫酸钙含量测定方法没有国家标准和行业标准,在参考不同标准中亚硫酸盐的测定方法基础上,对碘量法测定烟气脱硫灰中亚硫酸钙含量的方法进行实验研究。通过自制烟气脱硫灰模拟样的滴定,结果表明高碱性脱硫灰在滴定前应采用先加碘后加酸的顺序进行处理,并使用盐酸或磷酸作为酸化剂,而不宜使用硫酸酸化;采用磷酸(1+1)作酸化剂,控制溶液pH值在2.49¹.40之间,可以准确测定高碱性烟气脱硫灰中亚硫酸钙含量,重复性好,同时可有效避免Fe3+干扰。     

钢渣湿法捕获CO_2反应机制研究

以炼钢过程中排放的固体废弃物钢渣为碳捕获剂,进行了钢渣湿法捕获烟气CO2工艺的实验研究。通过分析钢渣的组成成份及反应机理,研究液固比、反应温度、反应时间、pH值及反应产物等主要参数对钢渣湿法碳捕获状况的影响。实验证明,通过合理的设计和适当的操作,可使钢渣湿法碳捕获效率达60%以上,具有一定的应用价值。