Ultrasound enhancement of the reduction of the Basic Green dye in wastewater by cast iron

Dyes in wastewater are of particular environmental concern since they give an undesirable color to the waters, dye and their derivatives are harmful to human health and the environment （ Annadurai et al., 2002）. Due to their biological persistency, conventional biological treat-ment processes such as activated sludge process are ineffective for their removal（Shaul et al., 1991）. There is a need to develop effective methods for the degradation of such persistent organic pollutants, either to less harmful compounds or, more desirable, to their complete mineralization.     

污垢系数对热交换器的影响

环保、冶金及建材行业余热利用中的热交换器,常因管内污垢系数上升、换热面粘附粉尘而失效.研制用于某硅铁电炉高温烟尘治理余热利用中设有脉冲喷吹自动清灰装置的热交换器,可有效解决因粉尘粘附而导致的传热系数下降,从而保证了换热器长期稳定运行.     

高炉原料矿槽槽上除尘方式综述

槽上卸料车及矿槽口尘源点具有移动性特征,有效的矿槽槽口密闭以及可靠的随卸料车移动的风管连接装置,是保证除尘良好效果的要点.常用的除尘方法各有其特点和适用条件,应根据作业方式及矿槽结构状况有针对性的采用.     

铬渣烧结矿炼制含铬生铁工业化生产试验研究

采用铬渣烧结矿作为熔剂,在３０ｍ＾３小高炉上进行了冶炼含铬生铁的工业化生产试验,铬河中六价铬的还原率接近１００％,总铬的金属化还原率大于９４％,平均每吨产品铁吃渣量为２．２９８ｔ,最高达２．７８５ｔ。炼制含铬最大于１０％铁含铬生铁,需同时配入铬铁矿增铬,保持１４８０Ｋ以上的炉温,控制较低的碱度,配入辅料降低炉渣溶点,可显著善炉渣的流动性,成功地实现渣,铁分离排放。监测了试验过程的二次污染,需控制高     

硫铁矿烧渣制取铁红

研究了以硫铁矿烧渣为原料制备铁红的工艺过程及原理,详细探讨了合成反应的各种影响因素及煅烧工艺条件。采用该工艺可使烧渣中氧化铁浸出率达92％,铁红纯度达96．5％。铁红产品质量符合GB1863-89一级品标准。     

Degradation of atrazine by catalytic ozonation in the presence of iron scraps: performance,transformation pathway,and acute toxicity

Degradation of atrazine by catalytic ozonation in the presence of iron scraps (ZVI/O₃) was carried out. The key operational parameters (i.e., initial pH, ZVI dosage, and ozone dosage) were optimized by the batch experiments, respectively. This ZVI/O₃ system exhibited much higher degradation efficiency of atrazine than the single ozonation, ZVI, and traditional ZVI/O₂ systems. The result shows that the pseudo-first-order constant (0.0927?min^?1) and TOC removal rate (86.6%) obtained by the ZVI/O₃ process were much higher than those of the three control experiments. In addition, X-ray diffraction (XRD) analysis indicates that slight of γ-FeOOH and Fe₂O₃ were formed on the surface of iron scrap after ZVI/O₃ treatment. These corrosion products exhibit high catalytic ability for ozone decomposition, which could generate more hydroxyl radical (HO^?) to degrade atrazine. Six transformation intermediates were identified by liquid chromatography-mass spectrometry (LC-MS) analysis in ZVI/O₃ system, and the degradation pathway of atrazine was proposed. Toxicity tests based on the inhibition of the luminescence emitted by Photobacterium phosphoreum and Vibrio fischeri indicate the detoxification of atrazine by ZVI/O₃ system. Finally, reused experiments indicate the approving recyclability of iron scraps. Consequently, the ZVI/O₃ system could be as an effective and promising technology for pesticide wastewater treatment.     

低影响开发雨洪管理技术费效分析

文章对LID技术的环境效益、经济效益、社会效益分类分析以及采用费效分析方法对其综合效益进行评价;指出国内外LID技术推广层面的政策经济不同之处,总结出LID技术的推广建议。表明LID措施比传统雨洪管理技术具有更大的环境效益、经济效益和社会效益,合理有效的运用将为海绵城市建设提供技术经济上的支持。     

氧化石墨烯-零价铁-聚乙二醇-海藻酸钠凝胶球活化过硫酸钠降解水中的偏二甲肼

以海藻酸钠(SA)、聚乙二醇(PEG)、氧化石墨烯(GO)和零价铁(ZVI)为原料制备了氧化石墨烯-零价铁-聚乙二醇-海藻酸钠凝胶球(GZPS),用于活化过硫酸盐(PDS)降解水中的偏二甲肼(UDMH)。对GZPS进行了表征,并优化了GZPS的制备工艺。实验结果表明:对UDMH去除率影响因素的主次顺序为:w(PEG) w(SA)w(GO)w(ZVI);GZPS的最佳制备工艺为SA、PEG、GO、ZVI的质量分数分别为5%,3%,0.3%,2%;在UDMH质量浓度为100mg/L、PDS加入量为4mmol/L、GZPS加入量为60g/L、反应温度为35℃、反应时间为80 min的条件下,UDMH的去除率达85%以上。GZPS活化PDS降解UDMH的反应符合准一级动力学,Fe溶出量仅为Fe-GO-PDS体系的12.7%,重复使用4次后对UDMH的去除率仍在65%以上。     

不同前处理方式对铁屑还原降解土壤中对硝基苯酚的影响

为推动铁屑在治理受硝基酚类化合物污染土壤中的实际应用,常温(25±1℃)常压下,利用不同前处理方式处理的铁屑、还原铁粉对土壤中的对硝基苯酚(p-NP)进行了还原降解研究;分析了土壤部分理化性质对p-NP还原效果的影响;并对反应时间、铁屑用量和土壤含水量3个人工易控因素作了最优化选择。结果表明:铁屑和铁粉对p-NP还原降解效果影响的大小顺序为:酸洗铁屑还原铁粉水洗铁屑碱洗铁屑;适中的土壤含水量、偏酸性的土壤初始pH值及较高的土壤有机质含量均可显著提高铁屑对p-NP的还原率;正交实验结果显示反应时间对p-NP还原效果影响最大,铁屑用量次之,土壤含水量最小;处理1.5 g p-NP浓度约为1.3×10-5mol/g的模拟污染土壤的反应最优化条件为:酸洗铁屑用量26 mg,土壤含水量0.35 mL,反应时间130 m in,还原率可达到96.4%。     

内电解法处理含N,N-二甲基乙酰胺工业废水

用内电解法处理含N,N-二甲基乙酰胺(DMAC)工业废水,研究pH、Fe∶C(体积比)、活性炭粒径和水力停留时间(HRT)等对该废水处理效果的影响,并确定最佳工艺条件。实验结果表明:在进水浓度维持在50 mg/L左右,最佳的工艺参数pH、Fe∶C和HRT分别为3.0、1∶1和60 min时,DMAC去除率高达到95%,处理水DMAC浓度小于5 mg/L。处理后废水的可生化性有明显的改善,BOD5/COD由0.21提高至0.66;而DMAC的去除基本符合二级动力学规律。