UASB反应器快速启动的试验研究

在中温条件下投加颗粒活性炭可加快ＵＡＳＢ反应器颗粒化进程。通过对比试验,表明投加和不投加活性炭的反应吕处理石化石废水污泥颗粒化时间分别为３９ｄ和６２ｄ。投加活性炭反应器的颗粒污泥粒径也较大。最大ＣＯＤ去除率在８６％以上。并且投加活性炭反应器的有机负荷为不投加的２倍,运行效果更稳定。     

Enhanced struvite recovery from wastewater using a novel cone-inserted fluidized bed reactor

The feasibility of struvite recovery at low （12.5 mg/L） and high （120 mg[L） phosphorus concentrations was studied by constructing a novel fluidized bed reactor with cones （FBRwc） and without cones （FBRwoc）. The crystallization process was continuously operated for 133 days under different hydraulic retention times （HRT = 1-10 hr）, pH （7.5-10）, and molar ratios of Mg/P （0.75-1.75）, N/P （1-10） and Ca/Mg （0-2）. The optimum operating conditions of HRT, pH, Mg/P and N/P molar ratios were found to be 2 hr, 9, 1.25, and 7.5, respectively. Under these optimum conditions, the phosphorus precipitation efficiencies of FBRwc were 93% for low and 98% for high phosphorus influent; however, the efficiencies were 78% and 81% for FBRwoc, respectively. Due to crystal losses at each junction （17%-31%）, the crystal recovery efficiency of FBRwoc was relatively low （47%-65%） for both influent concentrations. However, the losses were minimal in FBRwc, which showed 75% and 92% crystal recovery for low and high phosphorus concentrations, respectively. At low calcium concentration, crystal chemical analysis showed the product to be pure struvite （〉 99%）. The scanning electron microscope and X-ray diffraction results further confirmed that the crystal recovered from FBRwc contained pure struvite, which could be considered a high quality fertilizer. Except HRT, all parameters （pH, Mg/P, N/P and Ca/Mg） were found to be influencing factors for FBRwc performance. Overall, inserting cones in each part of the reactor played a significant role in enhancing struvite recovery from a wide range of phosphorus-containing wastewater.     

摩尔配比对MAP沉淀法回收模拟废水中磷的影响

以磷浓度50mg/L的实验室模拟废水为研究对象,考察了以鸟粪石(MAP)形式回收磷的最佳摩尔配比,并借助X-衍射(XRD)对不同摩尔配比条件下得到的沉淀物进行分析。试验结果表明,在pH=9.5时,以鸟粪石形式回收磷的最佳Mg:N:P=4:1.6:1。对沉淀物的XRD分析发现,在pH=9.5,当固定Mg:P=1.6时,N:P=1时沉淀物中基本不含MAP,当N:P=2时,生成的沉淀物中混有少量的副产物Mg(3PO)42,当N:P2时则生成较纯的MAP;当固定N:P=4时,Mg:P=2是生成较纯的MAP的临界值,超过此比例则生成副产物Mg(3PO)42;当反应按照理论配比投加氨氮和镁盐时,所得产物基本不是MAP,而是副产物Mg(3PO)42。故鸟粪石沉淀结晶反应中应尽量提高氨氮配比,并避免投加过量的镁盐,以保证回收产物的纯度。     

用煤矸石合成4A沸石分子筛处理氨氮废水

以煤矸石为原料,采用碱熔-水热法合成4A沸石分子筛。由于煤矸石中铝、硅主要以高岭土形式存在,其活化过程是合成4A沸石分子筛关键环节。为提高4A沸石分子筛钙离子的交换能力,增加对模拟废水氨氮的去除率,实验考察了碳酸钠与煤矸石质量比、活化温度、活化时间、晶化温度和晶化时间对4A沸石分子筛钙离子交换能力的影响,同时也考察了模拟废水的pH、4A沸石分子筛加入量及吸附时间对氨氮去除率的影响。结果表明,最佳工艺条件为,碳酸钠与煤矸石质量比为0.9、活化温度为800℃、活化时间1.5 h、晶化温度90℃和晶化时间3 h。合成4A沸石分子筛的钙离子交换能力为310 mg/g,在pH为6的100 mL模拟氨氮废水中加入6 g 4A沸石分子筛吸附40 min后,废水中氨氮的去除率达到86%。通过最佳工艺条件合成4A沸石分子筛,在处理氨氮废水方面具有一定的应用前景。     

不同诱导条件对结晶产物形貌特征的影响

在流化床反应器中,以含铜废水为处理对象,重点考察了诱导条件改变对结晶系统运行效率及结晶产物形貌特征的影响。结果表明,进水200 mg/L,进药比([Cu2+]/[CO2-3])1∶1.2,p H为10.2的条件下,铜离子去除率可接近100%,诱导晶种表面平滑,诱导颗粒生长成致密杆状晶体结构,以碳酸盐为沉淀剂的诱导结晶系统依赖于体系的p H,高p H体系下发生的共结晶现象是影响系统运行的主要原因;随着进药摩尔比的增加,结晶产物由短杆状向球状转化,晶体机械强度显著降低大量破碎,影响出水水质;进药比1∶1.2,p H为11的条件下,含铜废水浓度为500 mg/L时,系统去除率可达95%以上,微晶产率低于5%。     

Investigation on the relationship between the fine particle emission and crystallization characteristics of gypsum during wet flue gas desulfurization process

The relationship between the fine particles emitted after desulfurization and gypsum crystals in the desulfurization slurry was investigated, and the crystallization characteristics varying with the operation parameters and compositions of the desulfurization slurry were discussed. The results showed that the fine particles generated during the desulfurization process were closely related to the crystal characteristics in the desulfurization slurry by comparison of their morphology and elements. With the higher proportion of fine crystals in the desulfurization slurry, the number concentration of fine particles after desulfurization was increased and their particle sizes were smaller, indicating that the optimization of gypsum crystallization was beneficial for the reduction of the fine particle emission. The lower pH value and an optimal temperature of the desulfurization slurry were beneficial to restrain the generation of fine crystals in the desulfurization slurry. In addition, the higher concentrations of the Fe^3 + ions and the F⁻ ions in the desulfurization slurry both promoted the generation of fine crystals with corresponding change of the morphology and the effect of the Fe^3 + ions was more obvious. With the application of the desulfurization synergist additive, it was beneficial for the inhibition of fine crystals while the thinner crystals were generated.     

粉煤灰源NaY沸石的制备及其对乙酸乙酯的吸附性能研究

采用粉煤灰合成沸石的方法既经济又环保,在乙酸乙酯吸附领域中具有巨大应用前景.遵循节能减排、废物再利用的环保原则,探索了3种不同Si/Al比的粉煤灰、结晶温度、结晶时间和碱浓度4个因素对合成NaY沸石的影响.XRD、氮气吸脱附实验及ICP结果表明,Si/Al比和水热结晶温度对高比表面积NaY沸石的合成影响最大.Si/Al比在1左右的粉煤灰合成的沸石比表面积较低,且晶形中存在大量的NaA沸石,而Si/Al比在2左右的粉煤灰合成了高比表面积且纯度较高的NaY沸石;3种粉煤灰均在65 ℃下合成NaY沸石,但在105 ℃下完全转化为方钠石.实验优化结果表明,最优合成条件为采用Si/Al为2左右的粉煤灰,在2 mol·L^-1碱浓度、65 ℃水热温度下结晶12 h.该条件下合成的NaY沸石比表面积高达654.86 m²·g^-1(比表面积最高的粉煤灰源沸石之一),是原粉煤灰比表面积的22倍左右,对乙酸乙酯的吸附量也由15.4 mg·g^-1增至108.2 mg·g^-1.     

鸟粪石结晶法从废水中回收磷的研究进展

鸟粪石结晶法是一种能同时回收废水中磷源和氮源的处理方法。本文总结了鸟粪石晶体的生长机理、颗粒形成和生长的影响因素,并着重比较了能够形成鸟粪石的各种反应器的优缺点。此外,文章总结了采用鸟粪石结晶法处理实际废水的相关研究,并对其经济效益做了评估。最后对鸟粪石结晶技术未来的研究方向进行了展望,提出了国内鸟粪石结晶技术研究的必要性。     

污水处理磷回收的研究进展

磷矿数量减少与含磷污水造成的水体富营养化问题对磷资源的可持续利用提出了迫切要求。从污水处理的不同环节回收磷并重新利用,是实现磷资源循环利用的有效途径。本文讨论了国内外磷回收技术的研究进展和应用实例,包括从含磷污泥和富磷污水中回收磷的工艺,并对磷回收的技术经济性进行了分析。     

酸性条件下剩余污泥中Ca2＋和Mg2＋溶出对磷回收的影响

为了在酸性条件下实现剩余污泥中磷的高效回收,对pH=3时剩余污泥水解酸化过程中氨氮、正磷酸盐和钙镁离子的溶出现象以及磷回收进行了研究分析。结果表明：当pH=3时,所溶出的氨氮、镁离子和钙离子与磷酸盐的摩尔比均大于1,能满足采用鸟粪石沉淀法或者羟磷灰石沉淀法回收磷的要求;但所溶出的钙镁离子的摩尔比大于1,会对鸟粪石沉淀法回收磷的顺利进行有较大影响;有无外加镁剂对磷回收率影响不大。采用改型后的镁型强酸性阳离子交换树脂进行离子交换可以得到较高纯度的鸟粪石沉淀产品,通过XRD检测其纯度为95％以上。