Ni/Ce-Y沸石的制备及其对二苯并噻吩吸附研究

研究了负载二元金属NiCe-Y沸石的制备以及吸附二苯并噻吩的动力学性能。试验考察了二元金属Ni、Ce离子交换顺序、负载溶液方面对吸附剂制备的影响,初步得到了制备负载二元金属NiCe-Y吸附剂的优化条件。对NiCe-Y吸附剂进行脱硫性能评价及动力学分析,结果表明,负载二元金属NiCe-Y吸附剂比负载单一金属的Ni-Y吸附量提高31%,比Ce-Y吸附剂提高16%。     

沸石改性天然粘土防渗层性能研究

用不同比例的沸石对天然粘土进行改性,对改性粘土防渗层的渗透性、去除主要污染物的有效性和控制渗滤液渗透的可行性进行研究。实验结果表明改性粘土防渗层的渗透系数随沸石比例的增加而增大,如果沸石的配比适当,其渗透系数可达到低于1×10-7cm/s的现行标准,而且提高了防渗层的污染物去除能力。因此,沸石改性粘土作为垃圾填埋场防渗材料是可行的。     

阳离子表面活性剂改性沸石对铬酸根的吸附机制

研究了由十六烷基三甲基溴化铵(CTAB)改性制成的有机沸石对水体中铬酸根的吸附性能及吸附机制.结果表明,与沸石原矿相比有机沸石对铬酸根的吸附容量更高,而铬酸根在有机沸石表面的吸附量随着体系离子强度的增加而显著减小,说明铬酸根的吸附以静电作用为主.研究还发现沸石经有机改性后表面Zeta电位由负变正,说明表面活性剂在沸石表面的吸附改变了沸石表面的电荷性质,这也是有机沸石能够对铬酸根发生静电吸附的主要原因.铬酸根的吸附量及吸附的铬酸根的解吸量均随着体系pH值的升高而增加,分别约在pH=5.0和pH=6.0时达最大,随后铬酸根的吸附量和解吸量随着pH值的进一步增加逐渐减小.铬酸根的吸附量与解吸量之间的差值随pH升高而减小,说明在低pH条件下非静电吸附所占比例较高pH值条件下有所增加.     

SDS改性沸石吸附结晶紫

以表面活性剂十二烷基硫酸钠（SDS）对沸石进行改性,改性后的沸石对结晶紫溶液进行吸附,以紫外可见分光光度计分析最佳吸附条件。实验结果表明,在30℃,SDS改性沸石投入量为0．25g;吸附平衡时间为1h;pH为8的条件下,对含50mg／L结晶紫染料的去除率可达到92．6％,吸附量达到4．63mg／g。SDS改性沸石吸附结晶紫的等温吸附曲线与Henry型和Freundlich型均拟合较好。热力学参数计算结果表明,吸附符合自发吸热过程。     

SDS改性沸石吸附结晶紫简

以表面活性剂十二烷基硫酸钠（SDS）对沸石进行改性,改性后的沸石对结晶紫溶液进行吸附,以紫外可见分光光度计分析最佳吸附条件。实验结果表明,在30℃,SDS改性沸石投入量为0.25 g;吸附平衡时间为1 h;pH为8的条件下,对含50 mg/L结晶紫染料的去除率可达到92.6%,吸附量达到4.63 mg/g。SDS改性沸石吸附结晶紫的等温吸附曲线与Henry型和Freundlich型均拟合较好。热力学参数计算结果表明,吸附符合自发吸热过程。     

Alkaline hydrothermal conversion of fly ash precipitates into zeolites 3: the removal of mercury and lead ions from wastewater

In this paper, the utilisation of zeolites synthesised from fly ash (FA) and related co-disposal filtrates as low-cost adsorbent material were investigated. When raw FA and co-disposal filtrates were subjected to alkaline hydrothermal zeolite synthesis, the zeolites faujasite, sodalite and zeolite A were formed. The synthesised zeolites were explored to establish its ability to remove lead and mercury ions from aqueous solution in batch experiments, to which various dosages of the synthesised zeolites were added. The test results indicated that when increasing synthesised zeolite dosages of 5-20 g/L were added to the acid mine drainage (AMD) wastewater, the concentrations of lead and mercury in the wastewater were reduced accordingly. The lead concentrations were reduced from 3.23 to 0.38 and 0.17 microg/kg, respectively, at an average pH of 4.5, after the addition of raw FA zeolite and co-disposal filtrate zeolite to the AMD wastewater. On the other hand, the mercury concentration was reduced from 0.47 to 0.17 microg/kg at pH=4.5 when increasing amounts of co-disposal filtrate zeolite were added to the wastewater. The experimental results had shown that the zeolites synthesised from the co-disposal filtrates were effective in reducing the lead and mercury concentrations in the AMD wastewater by 95% and 30%, respectively.     

Low-temperature VOCs oxidation performance of Pt/zeolites catalysts with hierarchical pore structure

Different zeolites supported Pt catalysts with micro-mesoporous structure were prepared by organic base tetrapropylammonium hydroxide (TPAOH) treatment and their catalytic oxidation activity for various volatile organic compounds (VOCs) were evaluated. The results reveal that the synergistic effect between Pt nanoparticles and surface acid sites plays an important role in VOCs low-temperature removal. The small size and high dispersion of Pt nanoparticles on the surface of the zeolites would promote the catalytic oxidation of aromatics and alkanes over the Pt/zeolite catalysts, while strong acidity and abundant acid sites of catalysts are in favour of the oxidation of the VOCs containing N and O heteroatoms. In addition, it was found that Pt/ZSM-5 catalyst exhibits the highest oxidation activity for various VOCs low-temperature removal amongst all the catalysts due to the balance of both Pt dispersion and abundant acid sites in the catalyst. This comprehensive consideration should be very helpful when designing and preparing novel catalysts for the low-temperature removal of VOCs.     

Adsorption of humic acid from aqueous solution on bilayer hexadecyltrimethyl ammonium bromide-modified zeolite

Surfactant-modified natural zeolites (SMNZ) with different coverage types were prepared by loading hexadecyltrimethyl ammonium bromide (HTAB) onto the surface of a natural zeolite. The adsorption behavior of humic acid (HA) on SMNZ was investigated. Results indicate that the adsorbent SMNZ exhibited a higher affinity toward HA than the natural zeolite. HA removal efficiency by SMNZ increased with HTAB loading. Coexisting Ca²⁺ in solution favored HA adsorption onto SMNZ. Adsorption capacity decreased with an increasing solution pH. For typical SMNZ with bilayer HTAB coverage, HA adsorption process is well described by a pseudo-second-order kinetic model. The experimental isotherm data fitted well with the Langmuir model. Calculated maximum HA adsorption capacities for SMNZ with bilayer HTAB coverage at pH 5.5 and 7.5 were 63 and 41 mg·g^-1, respectively. E2/E3 (absorbance at 250 nm to that at 365 nm) and E4/E6 (absorbance at 465 nm to that at 665 nm) ratios of the residual HA in solution were lower than that of the original HA solution. This indicates that the HA fractions with high polar functional groups, low molecular weight (MW), and aromaticity had a stronger tendency for adsorption onto SMNZ with bilayer HTAB coverage. Results show that HTAB-modified natural zeolite is a promising adsorbent for removal of HA from aqueous solution.     

组合工艺处理上虞市总干渠微污染原水的中试启动研究

根据上虞市总干渠微污染原水水质特点,采用混凝沉淀＋曝气生物沸石滤池（ZBAF）＋活性炭滤池（GAC）组合工艺进行中试研究,考察了运行初期ZBAF的挂膜启动情况和组合工艺整体对此类水体的处理效果。结果表明：ZBAF在水温25℃~29℃、气水比1∶2、滤速2.5m/h下运行20天即挂膜成功;挂膜成熟后,组合工艺在5m/h滤速下对浊度、氨氮、UV254、CODMn的去除率分别达99%、85%、70%和75%,出水水质良好,浊度、氨氮、CODMn分别稳定在0.5NTU、0.1mg/L、1.5 mg/L以下。     

酸碱回收对粉煤灰合成沸石性能的影响

针对粉煤灰合成沸石合成成本较高及废酸碱外排污染环境的问题,对粉煤灰合成人工沸石工艺中废酸碱回收的可行性及其对合成沸石产品性能的影响进行了试验研究,研究设置3个废酸碱回收利用比例条件(1:1,2:1,3:1),其他合成条件与初始粉煤灰合成沸石完全相同.利用SEM、XRD、BET等技术对合成产品进行表征,结果表明回收酸合成沸石(WAC-ZFA)、回收碱合成沸石(WAL-ZFA)表面存在大量孔隙结构,XRD图谱也存在尖锐的沸石衍射峰,表征结果与粉煤灰合成沸石(ZFA)相似;在BET方面,与ZFA相比,WAC-ZFA有所下降,而WAL-ZFA明显增大;废碱回收比例对合成沸石除氨的效果影响不大,而废酸回收比例对合成沸石除氨的效果影响较明显,综合考虑,建议在实际生产中废酸回收比例宜≤1:1,废碱回收比例宜≤3:1.