丁二烯缓冲罐自聚物的生成原因及防范措施

分析了ABS树脂生产装置丁二烯缓冲罐中丁二烯自聚物的生成原因,提出了预防措施,避免丁二烯自聚物的生成,保证装置的安全平稳运行。     

火车装油过程初期火灾扑救方法探讨

以敞口、小鹤管、人工装汽油为例,通过试验分析认为:通常采用的干粉灭火法从理论和生产实际来看都存在问题,细水雾法是适合火车装油过程初期火灾扑救的较好方法,具有安全高效的特点。     

道化学公司指数法在罐区安全评价中的应用

采用道化学公司火灾、爆炸危险指数法对中国石化某厂综合储罐区进行安全评价,得出了其安全措施补偿前后的火灾、爆炸指数（F＆EI）、危险等级、暴露半径、暴露面积以及暴露体积等。结果表明,该企业综合储罐区采取的安全措施较为适用,能降低火灾、爆炸事故发生的概率和事故损害．     

具有自动清洗功能的低温等离子油烟净化装置设计与实现

为了克服现有的油烟净化器清洗困难、清洗成本高的不足,提供一种具有自动清洗功能的低温等离子油烟净化器,该具有自动清洗功能的低温等离子油烟净化器可随时清洗吸附的油烟,并且清洗容易、成本低。     

含硫油品储罐腐蚀产物自燃性的研究

通过模拟储油罐中硫铁化物的生成方式, 分析和研究了H2S气体在无氧条件下,与不同相对湿度的Fe2O3、Fe3O4和Fe(OH)3反应所生成的硫铁化物的自燃性.不同相对湿度的试样经6 h硫化后,其自燃性明显不同.以Fe2O3试样为例,相对湿度为0的硫化产物氧化升温最高为256 ℃,平均升温速率为10.8 ℃/min; 相对湿度为5%、10%和15%的硫化产物,氧化升温最高温度分别为474 ℃、408 ℃和388 ℃,平均升温速率分别为20.5 ℃/min、18.3 ℃/min和13.5 ℃/min.实验结果表明, 不同相对湿度、不同物质的硫化产物,其自燃性有显著差异,样品的相对湿度对硫化产物的自燃性有重要影响.对各种干燥样品的硫化产物进行电镜分析发现,由不同物质硫化所生成的硫化产物结构不同,致使其自燃性有较大差异.硫铁化物氧化反应放热是引发油罐着火的主要因素.     

Applying the precautionary principle to consumer household cleaning product development

Hazardous chemicals are pervasive in household disinfectant products. Many ingredients have established associations with acute and chronic human health conditions as well as with environmental damage. Although these associations are suggested but not proven, they are of great concern. This article describes the application of the precautionary principle to the selection of an anti-microbial active ingredient for a botanical disinfectant when significant uncertainty exists around the hazard and risk of traditional disinfectant active ingredients. We show that application of the precautionary principle does not stifle innovation and facilitates a responsible approach to product development.     

Chemical cleaning of fouled PVC membrane during ultrafiltration of algal-rich water

Cleaning of hollow-fibre polyvinyl chloride (PVC) membrane with di erent chemical reagents after ultrafiltration of algal-rich water was investigated. Among the tested cleaning reagents (NaOH, HCl, EDTA, and NaClO), 100 mg/L NaClO exhibited the best performance (88.4% 1.1%) in removing the irreversible fouling resistance. This might be attributed to the fact that NaClO could eliminate almost all the major foulants such as carbohydrate-like and protein-like materials on the membrane surface, as confirmed by Fourier transform infrared spectroscopy analysis. However, negligible irreversible resistance (1.5% 1.0%) was obtained when the membrane was cleaning by 500 mg/L NaOH for 1.0 hr, although the NaOH solution could also desorb a portion of the major foulants from the fouled PVC membrane. Scanning electronic microscopy and atomic force microscopy analyses demonstrated that 500 mg/L NaOH could change the structure of the residual foulants on the membrane, making them more tightly attached to the membrane surface. This phenomenon might be responsible for the negligible membrane permeability restoration after NaOH cleaning. On the other hand, the microscopic analyses reflected that NaClO could e ectively remove the foulants accumulated on the membrane surface.     

有关斜管沉淀池的上升流速讨论

文章从理论上了分析斜管沉淀池上升流速对沉淀池处理效果的影响,及原水特性与斜管沉淀池上升流速取值的关系。讨论分析斜管沉淀池设计时,应根据原水特性不同选择不同的斜管沉淀池上升流速。     

水力负荷对辐流式初沉池污染物去除效果的影响

以沉砂池出水为原水,在沉淀试验研究颗粒截留速度u0基础上,通过动态试验考察水力负荷对辐流式初沉池污染物去除效果的影响。研究结果表明无机悬浮固体(FSS)分离和总悬浮固体(TSS)高效去除的颗粒截留速度u0分别为0.025 m/min和0.05 m/min。由于泥层截留作用,水力负荷qA在46.3 m3/(m2.d)时,辐流式初沉池污染去除最高效,TSS、总氮(TN)和总磷(TP)去除率分别达到81%,23%,59%。