Acid Orange 7 degradation using methane as the sole carbon source and electron donor

• AO7 degradation was coupled with anaerobic methane oxidation. • Higher concentration of AO7 inhibited the degradation. • The maximum removal rate of AO7 reached 280 mg/(L·d) in HfMBR. • ANME-2d dominated the microbial community in both batch reactor and HfMBR. • ANME-2d alone or synergistic with the partner bacteria played a significant role. Azo dyes are widely applied in the textile industry but are not entirely consumed during the dyeing process and can thus be discharged to the environment in wastewater. However, azo dyes can be degraded using various electron donors, and in this paper, Acid Orange 7 (AO7) degradation performance is investigated using methane (CH₄) as the sole electron donor. Methane has multiple sources and is readily available and inexpensive. Experiments using ¹³C-labeled isotopes showed that AO7 degradation was coupled with anaerobic oxidation of methane (AOM) and, subsequently, affected by the initial concentrations of AO7. Higher concentrations of AO7 could inhibit the activity of microorganisms, which was confirmed by the long-term performance of AO7 degradation, with maximum removal rates of 8.94 mg/(L·d) in a batch reactor and 280 mg/(L·d) in a hollow fiber membrane bioreactor (HfMBR). High-throughput sequencing using 16S rRNA genes showed that Candidatus Methanoperedens, affiliated to ANME-2d, dominated the microbial community in the batch reactor and HfMBR. Additionally, the relative abundance of Proteobacteria bacteria (Phenylobacterium, Pseudomonas, and Geothermobacter) improved after AO7 degradation. This outcome suggested that ANME-2d alone, or acting synergistically with partner bacteria, played a key role in the process of AO7 degradation coupled with AOM.     

纺织印染厂废水的深度处理中试及工程应用

采用曝气生物滤池(BAF)-臭氧-曝气生物滤池工艺对广东某大型纺织印染厂的常规水解酸化-接触生物氧化处理出水进行深度处理回用中试,在中试研究成功的基础上,设计了每小时处理5 t的工业化试验装置。试验运行结果表明:进水COD为100~150 mg/L,色度约80倍,浊度约10 NTU,在前BAF水力停留时间3 h,中间化学氧化池中臭氧投加量40 mg/L,后BAF水力停留时间2 h的情况下,经组合工艺处理后出水COD约30 mg/L,色度2倍,浊度<1 NTU,该工艺处理后的出水,可直接回用于对电解质浓度要求不高的生产工艺中,也可作为反渗透或纳滤膜的预处理工序。     

Biodegradation of azo dyes by genetically engineered azoreductase

A azoreductase gene with 537 bp was obtained by PCR amplification from Rhodobacter sphaeroides ASI. 1737. The enzyme,with a molecular weight of 18.7 kD, was efficiently expressed in Escherichia coli and its biodegradation characteristics for azo dyes were investigated. Furthermore, the reaction kinetics and mechanism of azo dyes catalyzed by the genetically engineered azoreductase were studied in detail. The presence of a hydrazo-intermediate was identified, which provided a convincing evidence for the assumption that azo dyes were degraded via an incomplete reduction stage.     

铝镁氢氧化物溶胶吸附脱色性能的研究

对染料在具有永久正电荷的铝镁氢氧化物上的吸附,考察了铝镁比、染料类型、pH值等因素对吸附效果的影响,并进行了动力学、热力学研究结果表明,铝镁氢氧化物溶胶具有良好的脱色效果,铝镁比为1∶3的溶胶处理效果最佳;溶胶对大多数阴离子型染料的脱色率明显大于其它类型;染料的吸附量随pH值的增大而减小;溶胶对实验的各种阴离子型染料的饱和吸附量在961—3319mg·g-1之间;吸附量随温度升高而减小,说明吸附是放热过程     

反硝化菌的偶氮染料脱色研究

从活性污泥中分离到几株反硝化能力的偶氮染料脱色菌。它们在合成培养基吧有使大多数所试偶氮染料脱色,而在反硝化条件下很难使偶氮染料脱色,只有菌株１７在培养２０ｄ后才有较好的脱色效果。酵母粉等有机物作为生长因子时,对菌株１７反硝化条件下的偶氮染料脱色有非常明显的促进作用;     

Photocatalytic degradation of dye effluent by titanium dioxide pillar pellets in aqueous solution

Photocatalytic oxidation (PCO) process is an effective way to deal with organic pollutants in wastewater which could be difficult to be degraded by conventional biological treatment methods. Normally the TiO2 powder in nanometre size range was directly used as photocatalyst for dye degradation in wastewater. However the titanium dioxide powder was arduous to be recovered from the solution after treatment. In this application, a new form of TiO2(i. e. pillar pellets ranging from 2.5 to 5.3 mm long and with a diameter of 3.7 mm) was used and investigated for photocatalytic degradation of textile dye effluent. A test system was built with a flat plate reactor(FPR) and UV light source(blacklight and solar simulator as light source respectively) for investigating the effectiveness of the new form of TiO2. It was found that the photocatalytic process under this configuration could efficiently remove colours from textile dyeing effluent. Comparing with the TiO2 powder, the pellet was very easy to recovered from the treated solution and can be reused in multiple times without the significant change on the photocatalytic property. The results also showed that to achieve the same photocatalytic performance, the FPR area by pellets was about 91% smaller than required by TiO2 powder. At least TiO2 pellet could be used as an alternative form of photocatalyst in applications for textile effluent treatment process, also other wastewater treatment processes.     

Quinone-mediated decolorization of sulfonated azo dyes by cells and cell extracts from Sphingomonas xenophaga

The effects of various quinone compounds on the decolorization rates of sulfonated azo dyes by Sphingomonas xenophaga QYY were investigated. The results showed that anthraquinone-2-sulfonate (AQS) was the most effective redox mediator and AQS reduction was the rate-limited step of AQS-mediated decolorization of sulfonated azo dyes. Based on AQS biological toxicity tests, it was assumed that AQS might enter the cells to kill them. In the cytoplasmic extracts from strain QYY, AQS effectively increased decolorization rates of sulfonated azo dyes than other quinone compounds. In addition, we found a NADH/FMN-dependent AQS reductase using nondenaturing polyacrylamide gel electrophoresis (Native-PAGE).     

污泥活性炭对染料的吸附动力学研究

以城市污水处理厂脱水污泥作为原料,采用化学活化法(ZnCl2作为活化剂)制得污泥活性炭,全面研究了污泥活性炭对活性艳红K-2BP、酸性大红GR和直接紫N这3种染料的吸附动力学行为.结果表明,污泥活性炭可以有效地吸附染料,实现污泥的资源化;3种染料的平衡吸附量qe均随着染料初始浓度和温度的增大而增大,相同条件下平衡吸附量qe的大小顺序为:酸性大红GR＞活性艳红K-2BP＞直接紫N;伪二级动力学模型能够很好地描述3种染料在污泥活性炭上的吸附动力学行为;对于活性艳红K-2BP和直接紫N,颗粒内扩散过程是该吸附速率的控制步骤,但不是唯一的速率控制步骤,吸附速率同时还受颗粒外扩散过程的控制,而对于酸性大红GR,颗粒内扩散过程不是吸附速率的控制步骤;污泥活性炭对3种染料的吸附是一个吸热过程,吸附活化能较小,主要为物理吸附过程.     

污泥吸附剂对3种染料吸附动力学的研究

以污水厂脱水污泥、锯末和焦油的混合物为原料,选择ZnCl₂为活化剂制备出过渡孔发达、强度大的污泥吸附剂（S-AC）。借助BET、FT-IR等现代分析测试方法对污泥吸附剂进行表征,同时,研究了吸附剂对酸性大红、中性红和碱性品红吸附动力学行为。结果表明,制得的污泥吸附剂BET比表面积为358 m²/g,强度大于89%。吸附剂的动力学数据均符合伪二阶动力学方程、液膜扩散方程和颗粒内扩散方程,其中液膜扩散为吸附剂对酸性大红吸附过程的主控步骤,颗粒内扩散为吸附剂对中性红和碱性品红吸附过程的主控步骤。     

高盐条件下染料酸性橙7的生物降解特性

对偶氮染料废水厌氧-好氧生物处理中的高盐度抑制生物活性和芳香胺自氧化问题,通过多种强化策略,考察了NaCl为100g/L时酸性橙7(AO7)的生物降解特性.结果表明,加入葡萄糖(0.5g/L)、蛋白胨(1g/L)和酵母粉(0.5g/L)有利于高盐条件下AO7的生物降解.进水中加入酸性红B对AO7的脱色有加速作用.耐盐污泥中加入蒽醌形成的蒽醌-污泥自固定化体系可以促进AO7脱色,当蒽醌浓度为100mg/L时,AO7最大脱色率约为92%.以活性炭毡作为生物载体,厌氧和好氧体系均可实现稳定运行,且体系污泥沉降性良好,脱色速率达26.67mg/(L×h),且可有效抑制脱色中间产物1-氨基-2-萘酚的好氧自氧化,使COD去除率始终保持在90%以上.