Combined alkaline and ultrasonic pretreatment of sludge before aerobic digestion

Alkaline and ultrasonic sludge disintegration can both be used as pretreatments of waste activated sludge (WAS) for improving the subsequent anaerobic or aerobic digestion. The pretreatment has been carried out using different combination of these two methods in this study. The effect was evaluated based on the quantity of soluble chemical oxygen demand (SCOD) in the pretreated sludge as well as the degradation of organic matter in the following aerobic digestion. For WAS samples with combined pretreatment, the released COD was in high level than those with ultrasonic or alkaline treatment. When combined with the same ultrasonic treatment, NaOH treatment resulted in more solubilization of WAS than Ca(OH)2. For combined NaOH and ultrasonic treatments with different sequences, the released COD were in the order: simultaneous treatment > ultrasonic treatment following NaOH treatment > NaOH treatment following ultrasonic treatment. For simultaneous treatment, low NaOH dosage (100 g/kg dry solid), short duration (30 min) of NaOH treatment, and low ultrasonic specific energy (7 500 kJ/kg dry solid) were beneficial for sludge disintegration. Using combined NaOH and ultrasonic pretreatment with the optimium parameters, the degradation efficiency of organic matter was increased from 38.0% to 50.7%, which is much higher than with ultrasonic (42.5%) or with NaOH pretreatment (43.5%) in the subsequent aerobic digestion at the same retention time.     

芦苇酶解对氢气-甲烷联产过程微生物群落演替规律的影响

采用10 mg/g纤维素酶R-10预处理芦苇秸秆,研究了酶解预处理对芦苇厌氧产气潜力的影响,分析了氢气-甲烷联产过程中微生物群落结构演替规律. 结果表明:酶解预处理后,芦苇秸秆在产氢阶段的累积产气量和φ(H₂)分别达到42.5 mL/g和52.1%;在产甲烷阶段,累积产气量稳定上升,最高值可达137.5 mL/g,是对照组产气量的5倍. 由扫描电镜(SEM)观察可知,产氢阶段以短杆状和梭状菌为主,产甲烷阶段以长杆菌为主. PCR-DGGE(聚合酶链式反应-变性梯度凝胶电泳)分析表明,芦苇在酶解预处理后,其厌氧联产过程中微生物群落呈规律性演替,产氢阶段的优势微生物分别为具有降解纤维素产氢气功能的嗜热纤维素菌Clostridium thermocellum(条带B20)、具有高效产氢潜力的兼性厌氧产气肠杆菌Enterobacter aerogenes(条带B28);在产甲烷阶段,其优势微生物为可利用氢营养途径合成甲烷的产甲烷古菌Methanoculleus bourgensis(条带A3)、Methanoculleus horonobensis(条带A13). 经纤维素酶预处理后,芦苇秸秆厌氧联产的累积产气量、φ(H₂) 提高显著,具有纤维素降解功能的细菌和可利用氢营养途径合成甲烷的古菌为主要优势微生物.      

Effect of organic matter on phosphorus recovery from sewage sludge subjected to microwave hybrid pretreatment

Microwave (MW) hybrid processes are able to disrupt the flocculent structure of complex waste activated sludge, and help promote the recovery of phosphorus as struvite. In this study, to optimize struvite yield, (1) the characteristics of matter released in MW-hybrid treatments were compared, including MW, MW-acid, MW-alkali, MW-H₂O₂, and MW-H₂O₂-alkali. The results showed that selective release of carbon, nitrogen, phosphorus, Ca^2 +, and Mg^2 + achieved by sludge pretreatment using MW-hybrid processes. MW-H₂O₂ is the recommended sludge pretreatment process for phosphorus recovery in the form of struvite. The ratio of Mg^2 +:NH₄⁺-N:PO₄^3 −-P was 1.2:2.9:1 in the supernatant. (2) To clarify the effects of organic matter on struvite recovery, the composition and molecular weight distribution of organic matters were analyzed. Low molecular weight COD was found to facilitate the removal rate of NH₄⁺-N and PO₄³-P via crystallization, and the amorphous struvite crystals (< 1 kDa) from the filtered solutions had high purity. Therefore, the present study reveals the necessity of taking into consideration the interference effect of high molecular weight organic matters during struvite crystallization from sewage sludge.     

活化凹凸棒石对阳离子染料的脱色作用及其应用研究

活化凹凸棒石对三种阳离子染料有良好的脱色作用并符合Ｆｒｅｕｎｄｌｉｃｈ吸附等温式;脱色率随ｐＨ增加而递增,但各染料有差别;吸附过程似可分为两个阶段并呈现一级及应动力学的特征。用它作主要组份的吸附剂对阳离子染料生产废水的处理效果良好,脱色率和ＣＯＤｃｒ去除率可分别达到８７．５％～９９．８％和４５．４％～７２．３％;再生处理简单且其效果基本不降低,为阳离子染料生产废水的综合治理提供了一种有效而廉价的新型预处理方法。     

南方某市水源水、自来水的致突变活性现状与改善对策

用Ａｍｅｓ试验方法评价现有水处理工艺与模拟水厂水处理工艺对水的致突变活性的控制效果。结果表明,水源水的致突变活性呈阳性,Ｔ（传统处理）工艺出水致突变活性进一步增强;ＢＴ（Ｂ为生物处理）工艺能使致突变活性降低,但仍为阳性;ＢＴＣ（Ｃ为活性炭）、ＯＢＴＣ（Ｏ代表臭氧）组合工艺能有效去除和控制水中的致突物,使水的致突变活性转变为阴性反应。     

色拉油废水处理工程设计

色拉油废水COD、动植物油、氨、氮、磷浓度都很高。采用预处理除油 倒A2 O 接触氧化 化学除磷组合工艺处理 ,效果明显 ,出水各项指标 (特别是磷酸盐 )均能达《污水综合排放标准》(GB8978 1 996 )中的一级排放标准     

饮水中非挥发性有机污染物致突变性的防治对策

针对饮水致突变物的主要成因研究了减少饮水致突变活性的措施。结果表明：进厂源水生物膜预处理,可使致突变前体物,如藻、腐殖酸、总有机碳等含量分别减少68.2％、23.9％、37.2％,使水厂加氯量减少50％,最终使所制饮水的致突变件减少30％。改革加氯消毒方法可使饮水致突变活性降低,不同消毒剂所致致突变活性顺序为Cl₂＞ClO₂Cl₂＋ClO₂＞源水,Cl₂＋ClO₂等量联合消毒优于单一加氯消毒法,既可提高所试甲型肝炎病毒、脊髓灰质炎病毒及大肠杆菌ｆ₂噬菌体的灭活效果一至数倍;又可使饮水中CHCl₃,减少91.5％－96.5％,致突变活性减少27.6％。     

电镀废水处理技术工程应用实践

针对电镀废水的特点,根据清污分流、先预处理再综合处理的原则进行合理的细化分类,对不同的水质进行分类物化处理。该处理技术具有工艺合理、可操作性好、自动化程度高等优点,处理后出水水质达到广东省《水污染物排放限值》(DB44/26-2001)二级标准。     

电子废弃物中持久性有机污染物分析检测方法的研究进展

针对目前电子废弃物中持久性有机污染物(POPs)尚未形成有效快速分析检测方法的问题,介绍了溶剂萃取、固相萃取、微波萃取和超临界流体萃取等POPs前处理技术的研究进展,总结了POPs的分析方法,如:气相色谱、液相色谱、气相色谱-质谱法、高分辨率气相色谱-高分辨质谱法等化学分析方法,以及生物传感器测定法、表面胞质团共振检测法、酶联免疫检测法等生物分析方法。分析了各方法的优劣,并提出了展望。     

基于固液分离预处理的餐厨垃圾厌氧发酵

研究不同预处理方法所获餐厨垃圾浆料的半连续式厌氧发酵效果,评价该类餐厨垃圾的产甲烷资源化潜能.结果表明,固液油三相分离预处理后的液相餐厨垃圾作为进料较固液混合相餐厨垃圾在厌氧发酵时具有更高的VS去除率,实际产甲烷潜能和甲烷转化率,分别为91.2％,531.5mLCH4/gVS和54.3％,表明液相餐厨垃圾半连续中温湿式...