堆肥生物过滤器净化苯、甲苯混合废气的实验研究

选取木块和多孔塑料为填料,选择苯为VOCs代表,研究堆肥生物过滤器对高低浓度的苯生物降解性能。实验结果表明,（1) 以木块和多孔塑料为填料的堆肥生物过滤器对高、低浓度苯净化效率呈现降低后升高,最后再降低的过程,对高低浓度甲苯均呈现缓慢升高后降低的过程,高浓度苯的最大净化效率为90.5%和97.7%,甲苯的最大净化效率为71.34%和66.45%;（2) 以多孔塑料为填料的堆肥生物过滤器对高浓度苯具有较好的抗冲击性和抗负荷性,以木块为填料的堆肥生物过滤器对高浓度甲苯有更好的净化效果;（3) 堆肥生物过滤器对高低浓度苯、甲苯的平均净化率为68%和56%以上,低浓度苯和甲苯的平均去除能力分别为0.122和0.012 g/（m³·h）,最大去除能力为0.148和0.015 g/（m³·h）,而高浓度苯和甲苯的平均去除能力为0.94和0.11 g/（m³·h）,最大去除能力为1.32和0.135 g/（m³·h）。     

Atmospheric Volatile Organic Compound Monitoring. Ozone Induced Artefact Formation

Assessment of population exposure to VOC in ambient atmospheres is receiving heightened interest as the adverse health effects of chronic exposure to certain of these compounds are identified. Active (pumped) and passive samplers are the most commonly used devices for this type of monitoring. It has been shown, however, that these devices, along with all other preconcentration techniques, are susceptible to ozone interference. It is demonstrated that this interference occurs even at low ozone concentrations and that it may result in the under-estimation of population exposure. A convenient and effective ozone scrubbing method is identified and successfully applied and validated for both active and passive samplers for a range of VOC.     

Anaerobic biodegradation of benzene series compounds by mixed cultures based on optional electronic acceptors

A series of batch experiments were performed using mixed bacterial consortia to investigate biodegradation performance of benzene, toluene, ethylbenzene and three xylene isomers （BTEX） under nitrate, sulfate and ferric iron reducing conditions. The results showed that toluene, ethylbenzene, m-xylene and o-xylene could be degraded independently by the mixed cultures coupled to nitrate, sulfate and ferric iron reduction. Under ferric iron reducing conditions the biodegradation of benzene and p-xylene could be occurred only in the presence of other alkylbenzenes. Alkylbenzenes can serve as the primary subs＇rates to stimulate the transformation of benzene and p-xylene under anaerobic conditions. Benzene and p-xylene are more toxic than toluene and ethylbenzene, under the three terminal electron acceptors conditions, the degradation rates decreased with toluene 〉 ethylbenzene 〉 m-xylene 〉 o-xylene〉 benzene 〉 p- xylene. Nitrate was a more favorable electron acceptor compared to sulfate and ferric iron. The ratio between sulfate consumed and the loss of benzene, toluene, ethylbenzene, o-xylene, m-xylene, p-xylene was 4.44, 4.51, 4.42, 4.32, 4.37 and 4.23, respectively; the ratio between nitrate consumed and the loss of these substrates was 7.53, 6.24, 6.49, 7.28, 7.81, 7.61, respectively; the ratio between the consumption of ferric iron and the loss of toluene, ethylbenzene, o-xylene, m-xylene was 17.99, 18.04, 18.07, 17.97, respectively.     

非稳态条件下生物滴滤塔净化甲苯废气的实验

在接近于工业应用的非稳定条件下,以陶粒为填料,恶臭假单胞菌为单一菌源,甲苯为目标污染物,对生物滴滤塔的抗负荷冲击与抗饥饿能力进行研究。结果表明,停留时间及进气污染负荷的瞬间变化不会造成滤塔处理性能明显下降,仅为7%左右,12h内基本恢复,最大去除能力为136.49g/(m3.h);碳源与氮源的突然中断以及短期的闲置,对滤塔处理性能的影响均较小;填料层中水分的含量是影响滤塔处理性能的一个重要因素。     

真菌Trichoderma viride Pers.ex Fr降解三苯废气性能实验

利用固相静态试验考察前期实验驯化出的真菌Trichoderma viride Pers.ex Fr对苯、甲苯、二甲苯的好氧生物降解性能。结果表明,在本研究的气相浓度范围内(苯47.25~1677.47g/m3,甲苯64.70~1258.50g/m3、二甲苯20.59~1707.85g/m3),3种气体的降解速率随其初始浓度的增大而增加,降解规律苯、甲苯符合Monod方程,二甲苯符合一级反应。     

吸收法脱除甲苯废气的实验研究

以柠檬酸钠溶液为吸收液,在散堆填料塔里进行脱除甲苯废气的实验研究。研究了柠檬酸钠浓度、甲苯进口浓度、空塔气速及液气比对含甲苯废气吸收效果的影响,确定了最佳工艺条件,为解决含甲苯废气污染问题提供了应用基础。在此基础上提高填料层高度可使吸收率达到88%~93%,废气达标排放,并对吸收液的后处理进行了初步研究。     

复合催化剂对气相苯和甲苯的光催化降解研究

研究了在无催化剂、纯锐钛矿、纯金红石以及复合催化剂时苯和甲苯的光催化降解情况,考察了反应物初始浓度以及不同催化剂组成时苯和甲苯的光催化降解. 结果表明,使用锐钛矿催化剂,苯和甲苯降解效率都有很大提高,而使用金红石催化剂,苯和甲苯降解效率提高的幅度不大,这主要与锐钛矿和金红石的晶体结构有关. 在无催化剂和以金红石为催化剂时,甲苯比苯更容易降解;以锐钛矿为催化剂时苯比甲苯更容易降解. 初始浓度对苯和甲苯的光催化降解过程有一定的影响,在低浓度时降解速率较快,而在高浓度时降解速率较慢. 在锐钛矿催化剂中掺入一定量的金红石可提高催化剂的光催化活性. 对于苯,锐钛矿80%、金红石20%的复合催化剂光催化活性最高;而对于甲苯,锐钛矿90%、金红石10%的复合催化剂光催化活性最高.     

温度对生物过滤塔填料层含水率和运行性能的影响研究

实验以模拟甲苯废气为研究对象,系统分析了温度对生物过滤塔填料层含水率、甲苯去除能力、抗冲击负荷能力和再启动特性的影响.结果表明,生物过滤塔在温度20~30℃下,填料层含水率随温度变化不大(维持在45%),较高的进气温度(40~62℃)对填料层含水率影响显著,当气流温度从40℃升高至62℃时,填料层含水率从47%下降至19%.生物过滤塔处理每立方米体积废气需水量与气流温度间存在幂函数关系.温度过高会降低生物过滤塔的抗冲击负荷能力,并增加生物过滤塔的启动时间.温度在不同范围内对生物过滤塔甲苯去除性能的影响存在差异.在20~30℃下,生物过滤塔的甲苯去除速率常数的对数与温度的倒数呈线性关系,符合Arrhenius公式.而在40~62℃时,生物过滤塔的甲苯去除速率随温度的升高而呈现出先上升而下降的趋势,符合Ratkowsky模型.     

改性赤泥催化剂制备及其催化燃烧甲苯性能

以赤泥固废为原料,采用酸溶-碱沉淀耦合焙烧处理方法制备低成本改性赤泥催化材料,通过XRF,BET,H₂-TPR,热重分析,FT-IR等手段进行表征测试分析,结果发现,酸溶-碱沉淀法耦合焙烧改性后的赤泥比表面积较原始赤泥提高了约26倍,较原始赤泥的甲苯催化活性大幅度提高.H₂-TPR结果表明,改性后赤泥的还原峰温度向低温方向移动,还原峰面积增大,说明改性后的赤泥氧化还原能力增强.在反应温度为300℃时,原始赤泥的甲苯转化率仅为11.6%,改性赤泥的甲苯转化率接近100%.甲苯浓度在1000~4000mg/m³条件下浓度升高,催化甲苯活性降低;空速对甲苯催化活性影响较大.对制备的催化剂进行稳定性测试,研究发现催化剂并无失活或恶化迹象,表明催化剂具有较优良的稳定性.