Treating solid dairy manure using microwave-enhanced advanced oxidation process

The microwave enhanced advanced oxidation process (MW/H₂O₂-AOP) was used to treat separated solid dairy manure for nutrient release and solids reduction. The MW/H₂O₂-AOP was conducted at a microwave temperature of 120°C for 10 minutes, and at three pH conditions of 3.5, 7.3 and 12. The hydrogen peroxide dosage at approximately 2 mL per 1% TS for a 30 mL sample was used in this study, reflecting a range of 0.53–0.75 g H₂O₂/g dry sludge. The results indicated that substantial quantities of nutrients could be released into the solution at pH of 3.5. However, at neutral and basic conditions only volatile fatty acids and soluble chemical oxygen demand could be released. The analyses on orthophosphate, soluble chemical oxygen demands and volatile fatty acids were re-examined for dairy manure. It was found that the orthophosphate concentration for untreated samples at a higher % total solids (TS) was suppressed and lesser than actual. To overcome this difficulty, the initial orthophosphate concentration had to be measured at 0.5% TS.     

污泥厌氧消化预处理技术综述

全球环境问题已成为国际社会关注的焦点,围绕全球气候变化,降低温室气体排放,寻求再生能源,节能减排已成为目前国际科技发展的方向。通过"十一五"污水处理厂的建设,每年污泥产量已接近3000万吨(含水率80%脱水污泥计)以上,且以每年10%的速度递增。其处理与处置是制约社会经济发展的重要问题。但是,城市污泥蕴含有大量生物质能,通过借鉴国外先进技术与经验,开发城市污泥生物质能提取和利用技术,对我国节能减排具有重要战略意义。由于细胞壁的存在,使得污泥水解成为限制厌氧消化效率的重要瓶颈,而污泥强化预处理可有效提高污泥细胞壁的破坏,溶出胞内有机物,最大化回收剩余污泥中的有机能源。目前,预处理技术较多,如超声波预处理、热处理、微波预处理、碱解处理、臭氧预处理等,本文从物理、化学等角度分析了不同预处理对厌氧消化技术的影响。     

超声-生化法降解8-羟基喹啉废水的实验研究

本文采用超声-生化(两级好氧)联用的方法,对8-羟基喹啉废水的降解工艺进行了研究。对废水的预处理方法为超声降解法,文中分析了溶液初始浓度、超声时间、超声全程时间以及超声细胞粉碎机的变幅杆直径大小对废水预处理效果的影响。实验结果表明,变幅杆直径为25mm,溶液初始浓度为0.6g/L,超声全程时间在20min,最佳超声时间为2s时降解效率最高,CODcr去除率可以达到40.4%。本实验生化处理方法为普通活性污泥法(两级好氧),一级好氧反应池停留时间选择10h,去除率为69.4%;二级好氧反应池停留时间选择6h,去除率为71.7%。超声-生化(两级好氧)联用对8-羟基喹啉废水处理效果良好,CODcr总去除率达到94.4%。     

超声辐射浸渍法制备Fe-Ni-Mn/Al_2O_3催化剂及性能研究

以Al2O3为载体,分别采用超声辐射浸渍法和普通浸渍方法制备Fe-Ni-Mn/Al2O3催化剂。采用BET、XRD和SEM对催化剂的理化性质和孔结构进行了分析,以模拟酸性绿B废水为研究对象考察催化剂的催化性能。实验结果表明,浸渍溶液pH值和焙烧温度显著影响催化剂的性能。与普通浸渍法相比,超声浸渍法制备的Fe-Ni-Mn/Al2O3催化剂对酸性绿B脱色反应表现出较高的催化活性。     

利用缫丝废水处理过程中产生的微生物蛋白制备复合氨基酸

以缫丝废水处理过程中产生的微生物蛋白为原料,采用正交实验分析了采用酸水解、超声波水解、微波水解制备复合氨基酸的最佳工艺条件,并对比了最佳工艺条件下的水解效果.结果表明,酸水解的最佳工艺条件是水解时间2.Oh、固液比(体积比,下同)5∶1、硫酸质量分数50％、水解温度100℃,超声波水解的最佳工艺条件是水解时间0.5h、...     

超声波-铁粉协同降解五氯酚

通过超声波-铁粉联合体系协同降解废水中的五氯酚(PCP).实验结果表明:降解120 min后,PCP去除率可达90.4％;在该体系中铁粉被逐渐腐蚀成Fe2+,随降解时间的延长,Fe2+浓度逐渐增加;体系中的Fe2+可以促进·OH的产生,并且可以与超声空化作用下产生的H2O2发生Fenton试剂氧化反应降解PCP;超声波...     

Studies on enhanced degradable plastics: 1. The geographic variability in outdoor lifetimes of enhanced photodegradable polyethylenes

Studies on three types of enhanced photodegradable polyethylenes showed tensile elongation at break to be a suitable parameter for assessing disintegration due to outdoor weathering. Disintegration rates varied greatly with exposure location, with Arizona the harshest environment and Washington and New Jersey the mildest. The rate of breakdown of the enhanced degradable polyethylenes relative to unmodified plastic was termed an enhancement factor. For the materials studied, average enhancement factors generally ranged from five to fifteen. The location-dependent variability in rate parameters can be mostly explained in terms of different average radiation levels and temperatures at these locations. A duplicate exposure protocol was developed to determine if the test data were complicated by short-term fluctuations in sunlight or temperature during exposure.     

石英砂加工企业职业病危害防护措施与管理对策研究

通过对安徽省石英砂加工企业生产工艺流程和现场进行调查分析,得出矽尘和噪声是两种最主要的职业病危害因素,发现石英砂生产企业矽尘和噪声危害十分严重,生产作业现场未配备任何防护装备和个人防护用品,作业人员接触职业病危害的比率非常高。分析了石英砂加工企业在职业病危害防护与管理方面的欠缺与不足,提出了针对矽尘和噪声危害因素的具体工程防护措施与管理对策,从源头控制和消除职业病危害,保护劳动者的生命安全与健康。     

柠檬酸对重金属复合污染土壤的浸提效果研究

以浙江富阳某炼铜厂附近受Cd、Cu、Pb和Zn复合污染的土壤为研究对象,采用振荡、静置和超声3种不同浸提方式,通过研究柠檬酸在不同浸提方式下对重金属的去除效果,筛选出最佳柠檬酸浓度、处理时间及功率,并采用Tessier连续提取法分析浸提前后4种重金属形态变化.结果表明,柠檬酸对4种重金属均具有较好的去除效果,其中对Zn的去除效果最好,Cd的去除效果最差,而Cu和Pb的去除效果相当.Pb和Zn的去除率均随着柠檬酸浓度的增加而增加,但增幅随之减小,Cu的去除率则先增加后基本保持不变,而Cd的去除率变化不明显.综合考虑成本和浸提效果后,选用0.2 mol·L-1柠檬酸浸提2次为最优条件,最佳振荡时间和静置时间分别为4 h和24 h,最佳超声时间和功率分别为30 min和500 W.柠檬酸能够在很大程度上改变土壤中重金属的形态分布,主要去除以可交换态和碳酸盐结合态形式存在的Cd及以碳酸盐结合态和铁锰氧化物结合态形式存在的Cu、Pb和Zn.通过对比3种浸提方式,在同等去除效果的前提下,静置浸提相比振荡浸提需要更长的时间,而将超声波应用于重金属污染土壤淋洗,所需时间较少,因此,超声波辅助浸提土壤中重金属是可行的,具有良好的应用前景.     

Sewage sludge disintegration by high-pressure homogenization: A sludge disintegration model

High-pressure homogenization (HPH) technology was applied as a pretreatment to disintegrate sewage sludge. The effects of homogenization pressure, homogenization cycle number, and total solid content on sludge disintegration were investigated. The sludge disintegration degree (DDCOD), protein concentration, and polysaccharide concentration increased with the increase of homogenization pressure and homogenization cycle number, and decreased with the increase of sludge total solid (TS) content. The maximum DDCOD of 43.94% was achieved at 80 MPa with four homogenization cycles for a 9.58 g/L TS sludge sample. A HPH sludge disintegration model of DD_COD= kN^aP^b was established by multivariable linear regression to quantify the effects of homogenization parameters. The homogenization cycle exponent a and homogenization pressure exponent b were 0.4763 and 0.7324 respectively, showing that the effect of homogenization pressure (P) was more significant than that of homogenization cycle number (N). The value of the rate constant k decreased with the increase of sludge total solid content. The specific energy consumption increased with the increment of sludge disintegration efficiency. Lower specific energy consumption was required for higher total solid content sludge.