等离子体热解气化有机废弃物制氢的关键技术分析

等离子体热解气化有机固体废物制氢是一种先进高效的废物处理及资源化利用技术.首先,本文讨论了等离子体热解气化有机废弃物的机理,也概括了等离子体发生器的类型及其特点,其次分析了等离子体处理固体废弃物的影响因素,认为输入功率和载气类型等是影响等离子体处理的主要因素,最后总结了等离子体处理医疗垃圾、农林生物质、污泥等的应用现状与前景,指出等离子体热解气化固体废弃物是一种很有潜力的制氢方法.     

Spent rechargeable lithium batteries in e-waste: composition and its implications

The amount of spent rechargeable lithium batteries （RLBs） is growing rapidly owing to wide application of these batteries in portable electronic devices and electric vehicles, which obliges that spent RLBs should be handled properly. Identification of spent RLBs can supply fundamental information for spent RLBs recycling. This study aimed to determine the differences of physical components and chemical compositions among various spent RLBs. All the samplings of RLBs were rigorously dismantled and measured by an inductive coupled plasma atomic emission spectrometer. The results indicate that the average of total weight of the separator, the anode and the cathode accounted for over 60% of all the RLBs. The weight ratio of valuable metals ranged from 26% to 76%, and approximately 20% of total weight was Cu and Al. Moreover, no significant differences were found among different manufacturers, applications, and electrolyte types. And regarding portable electronic devices, there is also no significant difference in the Co-Li concentration ratios in the leaching liquid of RLBs.     

Cation exchange resin supported nanoscale zero-valent iron for removal of phosphorus in rainwater runoff

Self-made cation exchange resin supported nanoscale zero-valent iron （R-nZVI） was used to remove phosphorus in rainwater runoff. 80% of phosphorus in rainwater runoff from grassland was removed with an initial concentration of 0.72 mg. L-1 phosphorus when the dosage of R-nZVl is 8 g per liter rainwater, while only 26% of phosphorus was removed when using cation exchange resin without supported nanoscale zero-valent iron under the same condition. The adsorption capacity of R-nZVI increased up to 185 times of that of the cation exchange resin at a saturated equilibrium phosphorous concentration of 0.42 mg. L-1. Various techniques were implemented to characterize the R-nZVI and explore the mechanism of its removal of phosphate. Scanning electron microscopy （SEM） indicated that new crystal had been formed on the surface of R-nZVI. The result from inductive coupled plasma （ICP） indicated that 2.1% of nZVI was loaded on the support material. The specific surface area was increased after the load of nanoscale zero-valent iron （nZVI）, according to the measurement of BET-N2 method. The result of specific surface area analysis also proved that phosphorus was removed mainly through chemical adsorption process. X-ray photoelectron spectroscopy （XPS） analysis showed that the new product obtained from chemical reaction between phosphate and iron was ferrous phosphate.     

脉冲电晕等离子体降解有毒气体

采用脉冲电晕放电等离子体对化学毒剂模拟剂氯膦酸二乙酯(DECP)进行降解,结果表明,对初始浓度为70 mg·m-3的DECP降解率为96.4%.通过GC-MS和离子色谱分析,其降解产物主要有CHCl2-CH2Cl、CHCl2-CHCl2、二氯膦酸乙酯、HCl和H3PO4,并根据降解产物探讨了等离子体对DECP的降解反应机理.DECP分子中的P—Cl和C—O键断裂促使DECP矿化为H3PO4和HCl,而C—O键断裂形成的乙基与氯自由基反应形成CHCl2-CH2Cl和CHCl2-CHCl2;同时DECP分子中的一个P—O键发生断裂后与氯自由基结合形成了二氯膦酸乙酯.对DECP的反应动力学进行了分析讨论,得到其反应速率常数为0.0516 m.3(W.h)-1.     

甲醇对等离子体脱硫脱硝影响的实验研究

应用等离子体耦合催化剂进行烟气同时脱硫脱硝实验,重点分析了甲醇对脱硫脱硝效率的影响,同时研究了反应温度、甲醇浓度等因素的影响。实验结果表明,在V2O5/TiO2催化剂耦合等离子体反应器中,200℃时添加0.4%的甲醇能将NO的氧化效率从38%提高到99%。     

浅谈雷电危害及其预防措施

雷电是自然界中的一种静电放电现象.由雷击引起的建(构)筑物,生产装置及附属电气线路、变电配电装置等设施的爆炸火灾时有发生.因此研究雷电的特性,采取适当的防雷技术措施,做好工厂雷电灾害防御工作,提高职工的安全防护意识是极为重要的. 1雷电的产生及特性 按照放电形式的不同,雷电可分线形雷、片形雷、球形雷.最常见的是线形雷,云层有时能见到片形雷,个别情况下会出现球形雷.     

浅谈人体静电的产生与防范

有关资料表明,人体静电电位一般可达几千伏、上万伏,最高可达50kV,具有如此高静电电位的人体,一旦靠近或接触接地导体时,就不可避免地发生静电放电.人体静电导致的火花放电,瞬时功率有时高达几十瓦.因此,人体静电放电引燃引爆事故时有发生.     

高压脉冲等离子体降解水中苯酚的实验研究

对高压脉冲放电等离子体技术降解水中有机污染物苯酚进行了实验研究,观察了脉冲成形电容、脉冲峰值电压、脉冲频率、放电电极直径、放电距离、苯酚的人口质量浓度等因素对苯酚降解率的影响;实验结果表明脉冲成形电容有一最佳值;降解率随脉冲峰值电压、脉冲频率增大而升高,随放电电极直径和放电距离的减小而增大,随苯酚人口质量浓度增大而增大。     

单双介质阻挡放电降解苯的对比研究

在相同实验条件下,研究了单、双介质阻挡放电反应器的等离子体发射光谱,对苯的降解效率,以及CO和CO2的生成,检测了NO和NO2的浓度.结果表明,与单介质阻挡放电反应器相比,双介质阻挡放电反应器的发射光谱具有红移现象;单、双介质阻挡放电反应器对苯的降解效率、CO2的生成浓度及选择性几乎一致;采用双介质阻挡放电明显降低了CO的生成浓度,CO的生成选择性也有所下降.更为重要的是,双介质阻挡放电反应器极大地降低了NO2的生成,在本文的实验条件下,没有检测到NO.     

微波液相放电氧化难生物降解有机废水

随着社会工业化进程的不断加快与发展,化工废水量也大幅增加,对环境的危害日益加剧。利用微波液相放电产生等离子体氧化处理难降解有机废水是一种有效的新技术。文章阐述了微波液相放电产生等离子体氧化技术的反应机理及技术优势,通过实验验证了该技术处理难生物降解有机废水的影响因素,并针对 这项技术应用中需要深化探索的关键点给出建议。实验结果表明：输入功率1000W,水体流速250mL/min,pH值6.0,H2O2加量为0.8％的条件下, 微波液相放电氧化反应能在20min内,对有机废水（COD原值5000mg/L）的COD去除率达98％;在最佳条件下反应10min后,B/C值从0.12提高到0.31以上,废水性质由难生物降 解转变为可生物降解,处理成本为41.00元/m3。