碳酸化对模拟废物水泥窑共处置产品中重金属浸出的影响

通过模拟煅烧试验制取水泥熟料(重金属以一定的比例掺入水泥生料)并制备混凝土样品,研磨至粒径小于1mm,并使部分样品发生碳酸化作用.并分别对未碳酸化样品和碳酸化样品进行pH静态试验,研究了碳酸化作用对混凝土样品酸中和容量以及重金属(Cr,Ni,As,Cd和Pb)浸出行为的影响.结果表明,未碳酸化样品在碱性范围内(pH=7~12)酸中和容量较大,而碳酸化样品则在弱酸性范围内(pH=5~7)酸中和容量较大;碳酸化作用不影响混凝土中Cr、Ni、Cd、Pb的释放曲线的变化趋势,仅改变了浸出量最小值出现的pH值区间,但是碳酸化作用改变了混凝土中As的吸附相,使其释放曲线发生了明显的改变;碳酸化作用降低了混凝土中Cr、Ni、Cd、Pd的浸出量,但在较大pH范围内(pH=3~7和pH>11),增加了As的浸出量,因此,对混凝土中重金属溶出的安全性评价应重点关注As.     

Managing emissions from highly industrialized areas: Regulatory compliance under uncertainty

The use of regulatory and compliance-based modeling for air quality impact assessment is invariably relied upon to predict future air quality under various management scenarios particularly where air quality monitoring data are limited. This paper examines the dispersion from a multi-stack cement manufacturing complex with associated quarries and transport activities for regulatory compliance under uncertain emission and meteorological conditions. The concentrations of CO, NO_x, SO₂ and PM at sensitive receptor locations were used as indicators in comparison to World Health Organization (WHO) interim guidelines. Exceedance exposure areas were delineated under bounded uncertainties in input emission factors and meteorological parameters. Planning and management initiatives were tested to control/minimize potential exposure. Compared to the case of low emissions and actual meteorological conditions, the consideration of worst emissions coupled to worst meteorological conditions enlarged the boundaries of the exceedance exposure areas considerably. The implementation of best available technologies and enforcement of emission standards improved air quality in the region significantly and lowered the exposure at many population centers to below health standards. Uncertainty in the output of atmospheric dispersion models continues to play a significant role to be considered at the point where science is translated into political decision making.     

水泥窑共处置污染土壤的污染排放研究

以被DDT和六六六污染的土壤为研究对象,开展了利用水泥窑进行共处置的工程试验研究,分析了共处置过程对尾气排放的影响。结果表明,水泥窑共处置对农药污染物的焚毁去除率很高,DDT达到99.99991%,六六六达到99.99964%,均高于我国危险废物焚烧炉规定99.99％的焚烧效率;与空白处理相比,尾气排放中有机污染物（包括二恶英/呋喃,简称PCDD/F、多氯联苯PCB、六氯苯HCB、挥发性有机物VOC）、酸性气体和重金属的排放在共处置过程中没有显著增加,且都低于相应的规定限值。试验结果表明,水泥窑共处置固体废物不会导致污染负荷的增加。     

水泥旋窑并行处理城市污水厂污泥的污染物排放研究

通过重庆某水泥厂的工业试验,测定了水泥旋窑并行处理城市污水厂污泥的烟气参数及污染物排放指标,分析了并行处理污泥对旋窑烟气的影响程度及各项指标之间的相关性。结果表明：①在污泥添加速率增大时,烟气流速、排气量、含氧量、空气过剩系数、HF和SO₂等排放浓度均随之增加,粉尘、NO_x排放浓度基本保持不变,HCl排放浓度下降,CO排放浓度先剧增后缓慢下降,而总烃排放浓度无明显规律;②污泥添加速率与SO₂排放浓度、烟气流速与排气量、含氧量与空气过剩系数、总烃浓度与SO₂排放浓度、烟气流速与总烃浓度呈显著正相关,污泥添加速率与HCl浓度、SO₂浓度与HCl浓度、NO_x与总烃浓度呈显著负相关;③烟气排放的污染物主要来自煤的燃烧,各指标之间的相关性主要表现为煤耗量增加而引起的连锁效应,但污泥本身在高温条件下燃烧产生的污染物较少,由污泥燃烧产生的污染物之间的相关性较小;④污泥添加速率达到2.4 t/h时,水泥旋窑并行处理城市污水处理厂污泥过程中所有指标均满足国家及相应的控制标准,但其参数优化及污染物控制极为复杂,该方法处理污泥需要进行深入研究才能在工业上应用。     

回转窑焚烧炉在医疗废物处理中的应用

在医疗废物焚烧处理中,对于炉型的选择一直是工程设计人员最为关心的问题,也是关系医疗废物的处置是否能够真正达到无害化、减量化、资源化,特别是达到无害化处置目的的核心因素,在此通过西北某市医疗废物焚烧处理工艺设计,共同探讨回转窑焚烧炉在医疗废物焚烧处理中的应用。     

水泥炉窑中低温催化脱硝技术中试性能

利用中低温SCR脱硝技术路线对水泥窑炉进行深度脱硝,设计建设了烟气处理量为10000m³/h的SCR中试实验装置,考察了在SNCR装置后烟气中未能反应的NH₃进一步在SCR（selective catalytic reduction）装置的脱硝效果,并分析了不同入口NO_x浓度对脱硝率的影响.结果表明,所研究的水泥厂仅采用SNCR（selective non-catalytic reduction）和低氮燃烧技术,能够将烟气中的NO_x控制在100~135mg/Nm³,在不喷氨的状态下SCR系统的脱硝效率可达到50%以上,说明SNCR反应存在着一定懂得氨逃逸;在SCR系统补充喷射氨气后,SCR脱硝效率有显著的提升,可提到至80%以上.通过低氮燃烧、SNCR与SCR等脱硝技术的联合使用,可将水泥炉窑烟气中NO_x的排放浓度控制在50mg/Nm³以内,满足超低排放要求;将经过较长时间稳定运行后催化剂从系统中取出,进行成分、孔径分布和脱硝活性对比,结果表明催化剂内部微孔会被部分堵塞,导致比表面积降低,但经吹扫处理催化剂的脱硝效率可恢复,说明催化剂在水泥窑炉烟气条件下长期运行未出现中毒现象.     

Challenges against CO2 abatement strategies in cement industry: A review

Cement industry is an intensive source of fuel consumption and greenhouse gases (GHGs) emissions. This industry is responsible for 5% of GHGs emissions and is among the top industrial sources of carbon dioxide (CO₂) emissions. Therefore, CO₂ emissions reduction from cement production process has been always an appealing subject for researches in universities and industry. Various efforts have been carried out to mitigate the huge mass of CO₂ emissions from the cement industry. Although, majority of these strategies are technically viable, due to various barriers, the level of CO₂ mitigation in cement industry is still not satisfactory. Among numerous researches on this topic, only a few have tried to answer why CO₂ abatement strategies are not globally practiced yet. This work aims to highlight the challenges and barriers against widespread and effective implementation of CO₂ mitigation strategies in the cement industry and to propose practical solutions to overcome such barriers.     

焚烧、水泥窑和安全填埋法处置PCBs污染物技术优选

应用层次分析法和专家调查法,综合考虑环境、技术、社会和经济因素,建立了PCBs处置技术选择与评估的层次模型,分析了影响PCBs处置技术方案选择的重要因素.针对3种有较大应用前景的PCBs污染物处置技术,开展定性与定量相结合的方案评价.在处置对象为低浓度与高浓度PCBs污染物2种情况下,分别进行方案的优选.研究指出,环境影响是最重要的因素,在目前中国现有国情条件下,焚烧法是最适宜的PCBs处置技术.对高浓度PCBs污染物,或低浓度污染物具备经济条件或处理量较大,宜采取专用焚烧炉焚烧处置.对低浓度污染物,在不具备经济条件且处理量不大的情况下,可考虑利用水泥窑法或安全填埋法进行处置,并且参考就近处理的原则.此外,对不同技术方案的适用条件和改进措施也进行了探讨,并在此基础上提出了提高PCBs处置水平的政策建议.     

“十二五”水泥行业氮氧化物控制技术的经济分析

本文介绍了目前我国水泥行业NOx的排放现状、污染控制政策要求、控制技术及其应用情况。通过调研分析国内几家已采用脱硝技术的水泥企业案例,总结出影响水泥企业NOx控制经济成本的主要因素,并测算出"十二五"水泥行业减排成本。最后提出了促进水泥行业NOx减排工作的政策建议。     

Particulates pollution management and economic analysis of small rural enterprises in mountain areas: A case study of Wenquan town in China

At present, many rural enterprises in China's mountainous areas are developing rapidly, and due to poor planning and improper management, in an uncontrolled manner. These small enterprises are making atmospheric pollution far more serious and more difficult to control than before. Thus, as is the case with most developing countries, China is facing the challenge of managing the increased environmental pollution that is accompanying its economic development. This paper examines the case of cement dust pollution in the town of Wenquan in Sichuan province in order to determine how to adjust the relationship between development of rural enterprises and atmospheric environmental pollution in mountainous areas. Using the single objective linear programming method, and based on the principle of overall optimization, an optimal control plan for different pollution sources was worked out and an economic assessment on reclamation of cement dust was completed. According to our analysis, after implementation of this plan for four years, two months, the concentrations of suspended particles in Wenquan will achieve the requirement of the national third-order ambient air quality standard; the current serious dust pollution will be completely controlled; and the reclamation of cement dust will totally compensate for the cost of dust control and will result in 92,000 yuan of pure profit per year. At that time, the economy and environment will be in harmony.