粉煤灰的改性及其在垃圾渗滤液深度处理中的应用研究

实验采用物理方法和化学方法对粉煤灰进行改性,并用改性粉煤灰深度处理垃圾渗滤液。通过扫描电镜和X-射线衍射对改性前后粉煤灰的表面结构和主要晶相组成进行分析,同时考察其在垃圾渗滤液深度处理中的吸附效果。结果表明,改性后粉煤灰的比表面积和孔隙度增大,吸附能力增强。通过比较,吸附能力最强的改性粉煤灰是将引发剂A与粉煤灰以质量比为1∶9的比例混合,在800℃下恒温焙烧2 h所制得的改性粉煤灰,该改性粉煤灰对垃圾渗滤液中COD和色度的去除率可达到67.3%和87.3%,相对于改性前去除率提高了96.0%和57.8%。     

面向矿山废弃地复垦的炉渣污泥人工土壤的理化特性

通过添加不同比例的燃煤电厂粉煤灰和炉渣对城市污泥进行钝化,配制成不同灰渣比例的人工土壤,对人工土壤的pH、电导率、养分含量、重金属含量以及持水、渗水性能进行了研究。结果表明,污泥人工土壤pH介于7.5～8.0之间,属于弱碱性土壤;电导率变化范围为2.93～3.71 mS/cm,表明盐分含量较高。污泥人工土壤中有效态养分含量随炉渣比例提高而增加,所有配比人工土壤有机质和有效磷、速效钾的含量达到高肥力水平。人工土壤中Cd、Ni、Pb、Cu、Zn含量均明显低于国家农用标准(GB 4284-84、GB 8173-87)。粉煤灰渣对污泥中有效态Cd、Ni、Pb和Cu有钝化作用,使其向无效态转化,对Zn则有活化作用。炉渣对Cd、Ni的钝化作用要优于粉煤灰,而粉煤灰对Pb、Cu的钝化作用要优于炉渣。添加炉渣提高了污泥人工土壤水分的蒸发量,减弱了人工土壤的持水能力,但加入炉渣使人工土壤的渗透系数显著增加,提高了其渗水性能。     

冶金高炉高温熔融处理垃圾飞灰

为了探讨冶金高炉处理垃圾飞灰的可能性,将一定量的垃圾飞灰作为造球原料通过快凝水泥固化制备冷固飞灰球团,模拟高炉温度、气氛条件对飞灰球团进行高温冶金性能实验研究,并采用X射线衍射仪对飞灰球团中物相变化进行了研究。结果表明:在造球原料里配入5%左右的飞灰通过水泥固化造出的球团能达到入炉要求;配入10%飞灰球团的高炉炉料的高温冶金性能变化不大,且能够保持高炉内的工作环境相对稳定,符合当前冶炼要求的炉内工程条件;在高温下飞灰中的重金属能有效还原固封,二恶英能有效分解,为垃圾飞灰的资源化处理开辟了新的途径。     

不同粒径垃圾焚烧飞灰金属形态分布比较研究

研究了华南地区某垃圾焚烧厂的除尘器飞灰的化学组成和粒径分布,并采用分级提取法对不同粒径飞灰中的重金属化学形态进行了研究。同时比较了华南、华东、西南地区以及台湾地区垃圾焚烧飞灰的筛下累积分布和不同粒径飞灰中各重金属组成。结果表明,飞灰的组要成分为：CaO、SiO2和SO3等;各地区75%的飞灰粒径都主要集中在38.5～75μm。华南地区各粒径飞灰中挥发性金属（Zn和Pb）含量明显高于其他金属。除Ni和Cr外,Cu、Zn、Pb和Cd含量随粒径减小呈先减少后增大的趋势。华南地区Cu、Zn、Ni、Cr、Pb和Cd的含量均高于其他地区（台湾地区除外）。Cu、Zn和Cd的弱酸提取态和可还原态含量较高。高于40%的水溶态Pb表明其对环境有较大潜在危害;40%Ni和Cr主要以残渣态存在,对环境的潜在影响较小。     

化学絮凝-吸附预处理垃圾填埋场渗滤液试验研究

为改进现有二滩库区垃圾处理填埋场垃圾渗滤液处理工艺,研究絮凝—吸附法预处理工艺,试验以聚合氯化铝作为絮凝剂,最佳投放量为600mg/L,以粉煤灰作为吸附剂,最佳投放量为200g/L。结果表明:CODcr去除率达到79.64%;NH3-N去除率达到83.23%;悬浮物去除率达到58.75%;色度去除率达到92.56%;重金属离子去除率为60.37%～96.33%;研究证明:渗滤液经预处理后可以与城市生活污水合并处理。     

Modeling batch leaching behavior of arsenic and selenium from bituminous coal fly ashes

Correctly predicting the leaching potential of arsenic (As) and selenium (Se) is critical for assessing the environmental impact of coal fly ash. This study investigated the impacts of several key environmental factors, including pH, leaching time, and ash washing on the batch leaching behavior of As and Se from bituminous coal fly ashes. The experimental results demonstrated that As and Se leaching from fly ash increased beyond the minimal leaching pH ranges. Increasing leaching time increased As leaching but decreased Se leaching in the alkaline pH condition. A speciation-based adsorption model was used to quantify the batch leaching data, and determine the intrinsic leaching parameters including the total batch leachable mass and the adsorption constant of As or Se. The modeling approach was validated by correctly predicting the independent batch leaching data in a broad pH range and a different L/S condition. Experimental and modeling results also demonstrated that ash washing and ash aging (longer leaching time) did not change the adsorption constants of As and Se on the ash surface. However, ash washing could increase the availability of As and Se for leaching.     

Influence of arbuscular mycorrhizal fungi on the growth and nutrient status of bermudagrass grown in alkaline bauxite processing residue

A nursery experiment was conducted to evaluate the potential role of arbuscular mycorrhizal (AM) fungi in encouraging the vegetation cover on bauxite residue (red mud) sites. An alkali tolerant bermudagrass (Cynodon dactylon) adapted to local conditions were grown in red mud with different amendments with and without AM fungi to assess mycorrhizal effects on plant growth, mineral nutrition, metal uptake and neutralization of bauxite residue. Inoculation of AM fungi significantly increased the plant growth, nutrient uptake and reduced Fe, Al accumulation in plant tissue and also improved the soil physico-chemical and biochemical properties. Gypsum and sludge amended treatments inoculated with AM fungi had maximum biomass, nutrient uptake and reduced accumulation of metals. The neutralization of red mud was significant in presence of AM fungi than control. The experiment provided evidence for the potential use of bermudagrass in combination with AM fungi for ecological restoration of bauxite residue sites.     

粉煤灰合成NaX型分子筛的表征及其对Fe~（2＋）离子的吸附研究

以高温碱熔融处理粉煤灰合成了NaX型沸石分子筛,考察了不同水热晶化温度对产物结果的影响,用粉末XRD、XRF、SEM和FT-IR等手段对产品进行了表征,结果表明,以粉煤灰为原料用水热合成法合成微孔分子筛时,在晶化温度为90℃时能得到晶形较好的NaX型分子筛。同时考察了NaX分子筛的用量、时间和pH值等因素对Fe2＋离子的吸附影响,在25 mL Fe2＋离子浓度为2×103 mg/L的溶液中,当吸附剂用量为0.2 g,吸附时间为2 h,吸附效率达到最大值（36.41%）,而随着溶液pH值的升高其吸附效率显著增大。     

新型复合混凝吸附药剂对无铅皮蛋废水的处理

皮蛋废水水质相当复杂,既属于含重金属离子废水,又属于中等浓度含盐有机废水.针对皮蛋废水特点,采用混凝+吸附方法预处理皮蛋废水,将PAC与粉煤灰按2:5的投加比混合复制成一种新型复合混凝吸附剂,通过正交实验考察了复合药剂的较佳处理条件.结果表明,在投加量为5 g/L,pH为6.5左右,搅拌时间约为14 min,处理温度为...     

优选粉煤灰制备人工合成沸石及去除氨氮研究

7种粉煤灰样品的物理化学性质,如元素组成、结晶相组成、比表面积、灼失量、阳离子交换容量和pH得到表征。采用熔融法提取硅铝效率作为粉煤灰原料优选的依据,并通过L9（34）正交实验研究氢氧化钠投加量、熔融温度、氢氧化钠提取液浓度和体积对于硅铝提取效果的影响。结果表明,湿式除尘技术收集的低品位粉煤灰比电除尘技术所收集粉煤灰更...