Removal of phosphate from wastewater using alkaline residue

Alkaline residue(AR) was found to be an efficient adsorbent for phosphate removal from wastewater. The kinetic and equilibrium of phosphate removal were investigated to evaluate the performance of modified alkaline residue. After treatment by NaOH(AR-NaOH), removal performance was significantly improved, while removal performance was almost completely lost after treatment by HCl(AR-HCl). The kinetics of the removal process by all adsorbents was well characterized by the pseudo second-order model. The Langmuir model exhibited the best correlation for AR-HCl, while AR was effectively described by Freundlich model. Both models were well fitted to AR-NaOH. The maximum adsorption capacities calculated from Langmuir equation were in following manner: AR-NaOH AR AR-HCl. Phosphate removal by alkaline residue was pH dependent process. Mechanisms for phosphate removal mainly involved adsorption and precipitation, varied with equilibrium pH of solution. For AR-HCl, the acid equilibrium pH( 6.0) was unfavorable for the formation of Ca-P precipitate, with adsorption as the key mechanism for phosphate removal. In contrast, for AR and ARNaOH, precipitation was the dominant mechanism for phosphate removal, due to the incrase on pH( 8.0) after phosphate removal. The results of both XRD and SEM analysis confirmed CaHPO4·2H2O formation after phosphate removal by AR and AR-NaOH.     

半固态培养条件下烟曲霉去除土壤中镉

选用了1株高耐镉(Cd)的烟曲霉,提出了利用烟曲霉在半固态培养体系表面生长并去除Cd的方法,研究了菌体对不同模拟Cd污染水平土壤中Cd的去除效果,测定了菌体吸附和富集Cd的变化.结果表明,烟曲霉在半固态培养体系中能够实现一定的Cd去除效果,Cd含量为10 mg·kg~(-1)时,对土壤Cd的综合去除率可达31%.同时通过研究不同Cd含量下烟曲霉干重和体系pH随时间变化情况,发现随着培养时间和Cd含量的增加,烟曲霉干重逐渐下降,最大下降幅度可达64%,pH为5.6~6.0时去除效果较好.培养过程中土壤Cd形态变化表明,烟曲霉在该体系下主要去除土壤中弱酸溶态和可还原态的Cd,可氧化态Cd含量在培养前后基本保持不变.这种方法的提出为微生物去除土壤重金属污染提供了新的思路.     

温度对好氧颗粒污泥处理纤维素乙醇废水脱氮效能的影响

采用SBR反应器,考察了温度对好氧颗粒污泥处理纤维素乙醇废水脱氮性能的影响.研究结果表明,当进水为纤维素乙醇废水原水时,稳定阶段不同温度(10、20、30℃)条件下体系对COD的去除率分别为10.2%、12.7%、13.7%;总无机氮的去除率分别为42.8%、53.6%、70.5%,温度的升高明显地提高了硝化菌的活性和生长速率,进而促进了脱氮效果.当进水为纤维素乙醇废水经IC工艺处理后的厌氧出水时,3个温度条件下系统对废水中有机物的去除效果无较大差异,去除率均低于15%,主要因为纤维素乙醇废水的厌氧处理出水中的有机物很难被微生物利用;而温度对脱氮效果影响较大,30℃下NH_4~+-N去除率达到60.9%,分别是10℃和20℃时的2.0和1.3倍,并且,随着温度的升高总无机氮的去除率增强,NO_3~--N的去除量增加.由于体系COD去除率低说明反硝化可利用的碳源不足,因此,系统内可能存在内碳源反硝化作用,而且内碳源反硝化作用也随着温度的升高而增强.通过氮平衡计算可知,3个温度条件下氮损失分别为37.6%、45.0%、53.6%,说明温度的升高不仅提高了硝化菌活性,还促进了内碳源反硝化,进而提高了对氮素的去除.     

络合-超滤耦合工艺去除水中镍离子的研究

以聚丙烯酸钠(PAANa)和聚乙烯亚胺(PEI)作为络合剂,将其与镍离子络合后的溶液转移至超滤杯中,在0.1 MPa压力下通过聚醚砜超滤膜进行分离,研究pH值和络合剂/Ni2+装载质量比(L)对Ni2+去除率的影响,并根据朗缪尔等温模型拟合络合反应平衡常数.同时研究超滤时间对膜通量和Ni2+去除率的影响.结果表明,选用PAANa为络合剂,在pH值为8、L=5时,Ni2+的去除率达到最大值99.5%.PEI为络合剂时,Ni2+去除率在pH值为7、L为5时达到最大值93.0%.不同pH值条件下拟合得到的络合平衡常数表明,pH为7时最有利于络合反应.另外,单个络合剂单体所能结合的Ni2+个数随着pH值的升高而增大.研究结果还表明,在长达12 h的超滤时间内,PAANa为络合剂时,膜通量的衰减<10%;PEI为络合剂时,膜通量基本保持不变;Ni2+的去除率都基本保持恒定.因此,在合适条件下,络合-超滤耦合工艺能有效去除水中的镍离子.     

Batch studies of adsorption of copper and lead on activated carbon from Eucalyptus camaldulensis Dehn. Bark

Powdered activated carbon (PAC) prepared from Eucalyptus camaldulensis Dehn. bark was tested for its adsorption capacity for Cu(Ⅱ) and Pb(Ⅱ). The experiment was conducted to investigate the effects of pH, contact time, initial metal concentration, and temperature. The best adsorption of both Cu(Ⅱ) and Pb(Ⅱ) occurred at pH 5, where the adsorption reached equilibrium within 45 min for the whole range of initial heavy metal concentrations (0.1-10 mmol/L). The adsorption kinetics was found to follow the pseudo-...     

乳化液废水均相催化湿式氧化动力学

在2L高压间歇反应釜中,以高浓度难降解乳化废水为处理对象,研究了温度对铜盐均相湿式氧化的影响和动力学特征.结果表明:升高温度对加快后期反应速度更为有利,催化剂有利于中间产物氧化,在200℃催化活性最高,在进水COD48 400mg/L,反应2h去除率为86.6%;催化剂在不同温度作用下机制有所差别:200℃时3个途径反应速度均加快,中间产物加速氧化更明显;220～240℃时反应向生成中间产物方向偏移,活性降低;通用模型能较好地预测均相催化过程.     

降膜法脱氨氮的技术可行性及影响因素浅析

对煤气化废水的特性和处理现状进行了阐述和分析,总结了降膜技术在煤气化高氨氮废水中的脱氮效果和液泛气速、膜厚、pH值、温度的关系。研究表明,降膜技术可将氨氮去除率提高到95%以上,同时降低调整pH值的药剂成本,并有效缓解结垢现象,在类似工业废水处理项目中具有较好的推广应用价值。     

Inorganic nitrogen removal of toilet wastewater with an airlift external circulation membrane bioreactor

Removal of inorganic nitrogen (inorganic-N) from toilet wastewater, using a pilot-scale airlift external circulation membrane bioreactor (AEC-MBR) was studied. The results showed that the use of AEC-MBR with limited addition of alkaline reagents and volumetric loading rates of inorganic-N of 0.19-0.40 kg inorganic-N/(m3·d) helped achieve the desired nitrification and denitrification. Furthermore, the effects of pH and dissolved oxygen (DO) on inorganic-N removal were examined. Under the condition of MLSS at 1.56-2.35 g/L, BOD5/ammonia nitrogen (NH/-N) at 1.0, pH at 7.0-7.5, and DO at 1.0-2.0 mg/L, the removal efficiencies of NH4 -N and inorganic-N were 91.5% and 70.0%, respectively, in the AEC-MBR. The cost of addition of alkaline reagent was approximately 0.5-1.5 RMB yuan/m3, and the energy consumption was approximately 0.72 kWh/m3 at the flux of 8 L/(m2·h).     

A~2/O-曝气生物滤池工艺处理低C/N比生活污水脱氮除磷

以低C/N比实际生活污水为研究对象,重点考查了A2/O-曝气生物滤池生化系统的脱氮除磷特性.同时,考虑到A2/O工艺的主要功能是除磷及反硝化,而曝气生物滤池则以硝化为目的.因此,通过缩短A2/O的泥龄,可将硝化过程从A2/O中分离出去,让曝气生物滤池完成硝化,实现硝化菌和聚磷菌的分离,并解决了硝化菌和聚磷菌泥龄之间的矛盾.试验结果表明,该生化系统可实现有机物、氮和磷的同步去除.在平均C/N比为4.2,内回流比R为250%的条件下,平均进水COD、TN、TP分别为239.9、57.3和5.1mg·L-1,平均最终出水COD、TN、TP分别为34.1、13.3和0.1mg·L-1,去除率分别为85.8%、76.9%和98.3%.曝气生物滤池对氨氮几乎保持了100%的去除率.序批试验表明,反硝化聚磷菌占聚磷菌的比例为40.5%.     

钢渣对水体中磷的去除性能及机制解析

针对不同类型钢渣在除磷过程中存在的显著差异,以电炉渣为研究对象,探讨了环境因素（吸附时间、吸附温度）对钢渣除磷的影响,验证了其对磷酸盐、焦磷酸盐及实际水体的除磷效果,联合采用扫描电镜（SEM）、能量色散X射线能谱（EDS）、X射线荧光光谱（XRF）和X射线衍射光谱（XRD）技术探究其除磷机制,对比分析了钢渣与陶粒和沸石的除磷效率,并对钢渣除磷的安全性能进行了评估.结果表明,吸附时间显著影响钢渣除磷效果,当吸附时间为30 min时钢渣对质量浓度范围为1~20 mg·L^-1的磷酸盐溶液的去除率均可达到97%以上.温度对实验所用钢渣的除磷效果影响并不显著.钢渣对焦磷酸盐吸附能力弱于正磷酸盐,其对初始质量浓度为3 mg·L^-1的焦磷酸盐的去除率为82.45%.光谱分析结果表明,钢渣除磷的主要机制为化学吸附并辅以物理吸附,CaHPO₄·2H₂O为主要沉淀物质.钢渣对生物池出水和湿地系统中的磷素去除效果显著,总磷去除率分别为98.36%和93.33%.对比可知,钢渣对磷酸盐的去除效果优于陶粒和沸石,其对PO₄^3-的去除率分别为96%、40%和10%.钢渣浸出液中各重金属含量均符合地表水Ⅰ类标准要求,钢渣安全可靠.