低浓度SO2诱导驯化选育脱硫菌研究

采集于城市污水处理厂氧化沟的微生物用100～2 000 mg/m3低浓度SO2气体通入0.5 h停1 h的方式诱导驯化6 d以上,得到生长繁殖速度快、活性高、具有能将亚硫酸根氧化为硫酸根并从中获取能源的脱硫菌,该混合菌中优势菌属氧化亚铁硫杆菌,呈革兰氏染色阴性,杆菌单极生鞭毛运动的专性无机化能自养性菌.驯化过程中逐渐提高SO2浓度、供氧速率以及适时添加N、P、K等营养液对优势菌种的驯化生长起关键作用,驯化所得脱硫菌可只以低浓度SO2气体为能源进行生长,对亚硫酸根水溶液降解速率达160 g/(m3·h),生化降解率超过50%.在填拉西环塔式反应器中降解不高于5 500 mg/m3的SO2气体,气体接触时间3 s时SO2的净化效率达98%以上,出口SO2气体浓度低于100 mg/m3,生化降解率接近80%,对15 000 mg/m3 SO2气体的净化效率也高于95%.     

气升式反应器中微生物烟气脱硫研究

基于微生物酸性铁溶液烟气脱硫特性,实验构建了一套内循环气升式反应器.在反应器中,利用处于对数生长期的氧化亚铁硫杆菌(Thiobacillus ferrooxidans)酸性铁溶液进行了模拟烟道气SO2脱除实验研究.为寻求高脱硫率,实验研究了铁离子浓度、入口氧含量、细菌数和pH值的变化对脱硫率的影响.考察了反应液中Fe(Ⅱ)离子浓度的变化规律.实验表明,含T.f菌酸性铁溶液的脱硫效果较高;Fe离子浓度在7.67 g/L左右时脱硫率最佳;入口气中氧含量、反应液中细菌数和pH值越高,反应液的脱硫率也就越高.反应液中的Fe(Ⅱ)离子浓度是一先扬后抑的变化过程.     

Microorganisms desulfurization of coal

A culture of Thiobacillus ferrooxidans strain T-4, isolated from Song Zao Coal Mining, China, is able to use pyrite from coal as a source of energy. The bacterial culture solution with 108 -109 cells/ml, pH 1.55 - 1.70 was employed in the nine coal samples with -200 mesh have been studied at initial pH 1.7.30℃ , 20-30% coal pulp density. The bacterial removal sulfur from coal in samples 3, 4, 6 and 7 were reduced to 1.05 - 1.33% and 86.11% of pyritic sulfur can be removed in 4-24 hours.     

氧化亚铁硫杆菌浸出线路板中铜的研究

从煤堆积水中分离得到氧化亚铁硫杆菌,利用该菌种对线路板中的铜进行了浸出实验.研究了不同线路板粉末添加量对浸出效果的影响,观察了浸出过程中pH和氧化还原电位(Eh)的变化,结果表明添加量为10 g/L和20 g/L时,在15 d内线路板Cu几乎全部浸出,而50g/L和100g/L在15 d内亦有较高的浸出效率,并呈持续上升趋势.     

Effect of Pollution On the Occurrence, Distribution and Sulphur Transformation Ability of the Thiobacilli in the River Ganga

The occurrence, distribution and nature of ambient thiobacilli along with their ability to oxidize different sulphur species under simulated natural and in vitro culture conditions were studied in the polluted and unpolluted sites of the River Ganga.

Thiobacillus thioparus, T. thiooxidans and T. denitrificans were isolated from the river water. the former two occurred in both polluted and unpolluted sites, while T. denitrificans occurred in polluted areas only. the paper pulp mill effluent discharge area contained the highest population of T. thioparus. the sewage drainage area showed relatively higher populations of T. thiooxidans and T. denitrificans.

The present study revealed that only biological oxidation of either thiosulphate or elemental sulphur occurred in the river water. All the thiobacilli screened oxidized thiosulphate, and three-fourths of them oxidized elemental sulphur. Some strains were found to be very good acidifiers. in spite of such acidification by the ambient thiobacilli, the pH of the river water remained alkaline. the specific rates of thiosulphate (0.18 -0.51 μMmolh^-1 mg^-1 cell) and sulphur (1.3 - 6.2 Normality day^-1 mg^-1 biomass) oxidations under simulated natural condition were found to be higher in polluted areas when compared with the unpolluted one (sulphur: 0.8 - 1.0 Normality day^-1 mg^-1).

Further, addition of thiouslphate or elemental sulphur in the river water in simulated in vitro condition resulted in the increase of respective oxidation rates. the variations in the natae of pollutants discharged into the river water influenced the oxidation rate of thiosulphate or sulphur.     

氧化亚铁硫杆菌基因转移系统研究进展[综述]

氧化亚铁硫杆菌 (Ｔｈｉｏｂａｃｉｌｌｕｓｆｅｒｒｏｏｘｉｄａｎｓ)是极端嗜酸性的专性自养细菌 ,广泛分布于硫化矿床、酸性矿水及土壤中 ,最适生长ｐＨ 2 .0～ 2 .5 .氧化亚铁硫杆菌很早就被广泛应用于有用金属的浸出 ,特别适合于从低品位的矿石中浸出和回收稀有贵重金属 .这种方法具有低成本、低能耗、无污染等特点 ,因而在能源日益紧缺的今天 ,受到人们越来越多的关注 .目前许多国家已经成功地利用细菌浸出液技术开采多种金属 ,如铜、铀、金、钴、镍、锌和铅等 .其主要作用原理是通过氧化ＦｅＳＯ4 或ＦｅＳ2 产生Ｆｅ3 氧化剂 ,氧化…     

Biological mine drainage treatment

Drainage from sulphur mines contains a high concentration of ferrous iron and it is strongly acidic. The mechanism of acid mine drainage formation was briefly explained. As a case study, successful measures taken at the abandoned Matsuo mine, Iwate Prefecture, Japan, for preventing the pollution in receiving rivers was presented in this paper. The measures consisted of the construction works against pollution sources and the construction of a drainage treatment plant in which Thiobacillus ferrooxidans oxidizes ferrous iron under a low pH condition, and produced ferric iron is removed by sedimentation. Then, a laboratory-scale fluidized bed reactor using anion exchange resin as attaching material for the bacteria was examined in order to improve the efficiency of biological oxidation of ferrous iron. More than 90% of oxidation had been maintained for 2 months at 1 h of HRT, which suggests that the size of the oxidation tank could be reduced.     

培育优势菌种处理腈纶厂硫氰酸钠废水

采用两段生物氧化法处理腈纶厂的硫氰酸钠废水，Ⅰ段去除易降解的有机物，Ⅱ段培育以自养性排硫杆菌为主体的生物膜，降解硫氰酸钠。试验装置的容积负荷达１．１—２．２ｋｇＮａＳＣＮ／ｍ￣３·ｄ，比单级氧化池处理同类废水试验的容积负荷提高２—４倍。文中介绍了试验装置运转情况，两段生物膜的特性，探讨了在第Ⅱ段氧化池中硫氰酸钠生物降解的动力学模型。     

微生物对煤系固体废弃物淋滤液污染性影响

煤矸石和粉煤灰是煤矿区的两种主要废弃物,它们不仅占用大量的土地,同时也对矿区环境产生了严重污染。分别接种氧化硫硫杆菌和解磷细菌于煤矸石和粉煤灰中,通过柱状淋滤试验研究微生物对两种固体废弃物淋滤液污染性的影响。结果表明:煤矸石中添加氧化硫硫杆菌能显著脱除煤矸石中的硫,同时淋滤液中也生成了大量的H+和铁离子,使淋滤液中硫酸根和磷酸根离子浓度显著增大,超出了GB3838-2002《地表水环境质量标准》的指标。粉煤灰中添加解磷菌能显著提高淋滤液中的磷含量和电导率,但对淋滤液的pH、SO42-和铁离子影响不明显。氧化硫硫杆菌和解磷细菌对煤矸石和粉煤灰混合工艺处理效果较好,粉煤灰在一定程度上降低了硫、磷和铁的污染性。     

嗜酸菌对废旧印刷线路板金属铜的浸出研究

选用嗜酸性氧化亚铁硫杆菌(Acidithiobacillus ferrooxidans,简称T.f)、氧化硫硫杆菌(Thiobacillus thiooxidans,简称T.t)作为实验菌种研究其对线路板(Printed circuit board)粉金属铜的浸出;试验以单一菌种、混合菌种、无菌培养基及酸性蒸馏水进行浸出实验研究,通过对比不同条件下的浸出效果,得出单一氧化亚铁硫杆菌(T.f)的浸出效果最好,浸出率达到92.1%。通过对浸出过程中pH、ORP及Fe2+、Fe3+变化分析,发现Fe3+的氧化作用在铜的浸出过程中起主导作用,酸浸也有一定的贡献;对浸出后残余的PCB进行XRD及SEM观察分析发现,PCB组成成分中含有大量的酚烃、苯酚及邻、对位取代酚以及少量的长链烷烃及其脂肪烃,此类有机物在浸出过程中均与细菌或其代谢物发生了作用。