PLC控制系统在钢渣热焖工艺中的应用

利用PLC控制系统,实现在钢渣热焖工艺中的恒压供水和钢渣热焖定时定量喷水的自动控制要求,具有国际先进水平,取得了良好的经济效益、社会效益和环境效益.     

络合-超滤耦合工艺去除水中镍离子的研究

以聚丙烯酸钠(PAANa)和聚乙烯亚胺(PEI)作为络合剂,将其与镍离子络合后的溶液转移至超滤杯中,在0.1 MPa压力下通过聚醚砜超滤膜进行分离,研究pH值和络合剂/Ni2+装载质量比(L)对Ni2+去除率的影响,并根据朗缪尔等温模型拟合络合反应平衡常数.同时研究超滤时间对膜通量和Ni2+去除率的影响.结果表明,选用PAANa为络合剂,在pH值为8、L=5时,Ni2+的去除率达到最大值99.5%.PEI为络合剂时,Ni2+去除率在pH值为7、L为5时达到最大值93.0%.不同pH值条件下拟合得到的络合平衡常数表明,pH为7时最有利于络合反应.另外,单个络合剂单体所能结合的Ni2+个数随着pH值的升高而增大.研究结果还表明,在长达12 h的超滤时间内,PAANa为络合剂时,膜通量的衰减<10%;PEI为络合剂时,膜通量基本保持不变;Ni2+的去除率都基本保持恒定.因此,在合适条件下,络合-超滤耦合工艺能有效去除水中的镍离子.     

有机质对土壤气相抽提去除四氯化碳效率的影响

某重要岩溶地下水源地因附近农药厂排放含四氯化碳污水而受到严重污染,实验采用土柱通风试验模拟土壤气相抽提(SVE),研究环境温度为20℃,通风速率为40mL/min,土壤含水率10%,而土壤有机质含量分别为3.02%和0.13%条件下的两种供试土壤中四氯化碳污染物的去除过程.结果表明,土柱通风能有效去除土壤中的四氯化碳污...     

土壤溶解性有机质荧光特征及其与铜的络合能力

选取4种不同类型土壤和腐熟鸡粪,透析提取溶解性有机质(DOM),通过凝胶色谱、三维荧光光谱测定并分析了DOM的相对分子质量(M_r)分布、化学结构特征及其与铜的结合能力.结果表明,鸡粪DOM相对分子质量积分面积远高于其他样品,表现出其具有较高的有机物含量,泥炭土次之.暗棕壤、褐土和黑土较低,仅为鸡粪积分面积的4.5%~5%.鸡粪在中分子量段积分面积约占总物质的34.1%,低分子量段和高分子量段分别约占41.7%和24.2%.荧光光谱分析表明,各样品均出现类蛋白荧光峰(E_x/E_m=240~270/300~350 nm),在中、高分子量段(M_r500)暗棕壤存在的荧光峰消失.泥炭土出现了较为独特的可见光区类富里酸荧光峰(E_x/E_m=325/420 nm),该荧光峰和黑土的荧光峰在中、高分子量段(M_r500)都产生了红移现象.鸡粪分别出现了和黑土类似的紫外区类富里酸荧光峰,以及和泥炭土类似的可见光区类富里酸荧光峰,以及一类独特的类蛋白荧光峰(E_x/E_m=280/350 nm),但这种类蛋白荧光峰在中分子量段(500M_r12 000)消失.分析表明泥炭土与Cu的络合常数(lg K)为4.13,其他3种土壤与Cu的络合常数较小且差别不大,集中在2.10~3.10之间.鸡粪与Cu的结合能力最大,络合常数达到6.66.     

不同共代谢基质下厌氧生物降解间苯二酚的研究

分别用蔗糖、葡萄糖、丁酸盐和乙醇作为驯化好的厌氧污泥的共代谢基质,在厌氧序批式反应器(ASBR)中对间苯二酚的降解进行研究。结果表明:共代谢基质SCOD浓度在500～2000mg/L时,间苯二酚的降解速率很高;试验回归结果表明反应均符合一级动力学方程;反应速率常数大小依次为k丁酸盐>k蔗糖>k葡萄糖>k乙醇;当两种共代谢基质按比例1:1(SCOD)混合投加后,反应速率常数大小依次为k葡萄糖+丁酸盐>k乙醇+丁酸盐>k葡萄糖+乙醇,其中葡萄糖和丁酸盐的混合基质降解速率最高。     

蒽醌化合物的光解动力学及定量结构-性质关系

以高压汞灯为光源, 测定了15 种蒽醌化合物(ATQs)的光解速率常数(k), 讨论了取代基位置、数目及种类对ATQs 光解速率的影响.另外,选取9 种氨基蒽醌, 应用偏最小二乘(PLS)算法, 建立了关于k的定量结构-性质关系(QSPR)模型. 根据该模型, 决定k值大小的主要因素包括:分子生成热、H 原子所带最大正电荷、C 原子所带最大负电荷,以及分子最低未占据轨道与最高占据轨道能量差.     

Thermodynamics and kinetics of cadmium adsorption onto oxidized granular activated carbon

Cadmium sorption behavior of granular activated carbon oxidized with nitric acid was systematically studied by sets of the equilibrium and time-based experiments under various conditions.The cadmium adsorption capacity of oxidized granular activated carbon enlarged with an increase in pH,and reduced with an increase in ionic strength.Experimental data were evaluated to find out kinetic characteristics.Adsorption processes were found to follow pseudo-second order rate equation.Adsorption isotherms correlate well with the Langmuir isotherm model and the maximum sorption capacity of cadmium evaluated is 51.02μmol/g.Thermodynamic parameters were calculated based on Van't Hoff equation.Equilibrium constant Kd was evaluated from Freundlich isotherm model constants,Langmnir isotherm model constants,and isotherms,respectively.The average change of standard adsorption heatΔH~0 was -25.29 kJ/mol.NegativeΔH~0 andΔG~0 values indicate the adsorption process for cadmium onto the studied activated carbon is exothermic and spontaneous.The standard entropyΔS~0 was also negative,which suggests a decrease in the freedom of the system.     

高锰酸钾降解地下水中PCE的研究

以氯代有机污染物中常见的PCE为目标污染物,以自制高锰酸钾溶液为氧化剂,采用批实验方法,探讨了高锰酸钾降解PCE的反应动力学、影响因素以及反应机理。反应结果表明,高锰酸钾降解PCE的反应符合一级动力学方程,反应活化能E为57.119 kJ/mol,在30℃条件下,反应速率常数为0.0076 min^-1,半衰期为91.20 min。在pH在3～10,离子强度在0～0.1030 mol/L之间变化时,反应速率不受明显影响。     

Volatilization characteristics of organic solutes in stirred solution

The effects of turbulence intensity (velocity gradient, G (s⁻¹)), Henry's law constant (H), and molecular weight (M) on the volatilization rates of organic compounds are examined using changes in the mass transfer coefficients (K_OL (cm/min)) under specific liquid-mixing intensities. The selected compounds were divided into three groups according to their H values (mole in gas/mole in liquid, dimensionless), which ranged from 10² to 10⁻⁵. The relationship of the K_OL relative to G, H and M was obtained via multiple regression. The obtained values of these parameters indicate that the primary factor affecting the K_OL values of the high H compounds is their M values. The effects of the H values on the K_OL values of the high H compounds can be neglected. On the other hand, the H value is the major factor determining the K_OL values of the low H compounds. The changes in the K_OL values of the different H compounds exhibit different profiles as the liquid-mixing intensity increases. The M and H values of middle H compounds possibly affect their K_OL values. The effects of the liquid-mixing intensity on the K_OL values of the organic compounds increase with increasing H values. The variation in the K_OL values might be a result of the concentration of the organic compounds at the interface between the liquid and gas films. The empirical relationship between K_OL and some selected parameters, G, H and M, is examined in this study. The obtained results can help to estimate volatilization loss of organic solutes in wastewater treatment facilities.     

关于植物中氟化物测定结果的计算

针对植物中氟化物测定时由于绘制校准曲线的标准溶液体积与分析样品的定容体积不一样而引出的结果计算时的某些问题,提出了正确的计算方法和建议。