大豆蛋白粉喷雾干燥塔尾气余热的回收与利用

针对大豆蛋白粉生产过程中喷雾干燥塔尾气温度较高,有回收利用价值的现实,也针对目前的节能需求,对现有的喷雾干燥塔的尾气排放部分进行改造,设计一个片状空气预热器,以利用高温的尾气与系统的进气做热交换,实现热量再利用,降耗和提高蛋白粉产率的目的,并对投资收益进行了分析。     

Performance on a Work-Simulating Firefighter Test Versus Approved Laboratory Tests for Firefighters and Applicants

Aim. Firefighters must meet minimum physical demands. The Norwegian Labour Inspection Authority (NLIA) has approved a standardised treadmill walking test and 3 simple strength tests for smoke divers. The results of the Trondheim test were compared with those of the NLIA tests taking into account possible effects of age, experience level and gender. Methods. Four groups of participants took part in the tests: 19 young experienced firefighters, 24 senior male firefighters and inexperienced applicants, 12 male and 8 female. Results. Oxygen uptake (V_O2) at exhaustion rose linearly by the duration of the treadmill test. Time spent on the Trondheim test was closely related to performance time and peak V_O2 on the treadmill test. Senior experienced firefighters did not perform better than equally fit young applicants. However, female applicants performed poorer on the Trondheim test than on the treadmill test. Performance on the Trondheim test was not closely related to muscle strength beyond a minimum. Conclusion. Firefighters completing the Trondheim test in under 19 min fit the requirements of the NLIA treadmill test. The Trondheim test can be used as an alternative to the NLIA tests for testing aerobic fitness but not for muscular strength. Women’s result of the Trondheim test were poorer than the results of the NLIA treadmill test, probably because of their lower body mass.     

从粉煤灰中提取多种微细氧化物的研究

将粉煤灰与Na2CO3按一定的比例混合后焙烧,采用酸碱联合法提取粉煤灰中氧化硅、氧化铝和氧化铁,分析了工艺条件对粉煤灰中氧化物提取率的影响。实验结果表明,从粉煤灰中提取氧化物的最佳条件是:碳酸钠与粉煤灰的比例0.6∶1.0,焙烧温度850℃、盐酸浓度4 mol/L,氢氧化钠浓度2.6 mol/L,浸取时间约6 h。在此条件下得出微细氧化硅、氧化铝、氧化铁的晶体,其平均粒度分别为氧化硅1.107μm,氧化铝1.334μm,氧化铁0.783μm。     

Relation of hepatic EROD activity and cytochrome P4501A level in Sebastiscus marmoratus exposed to benzo[a]pyrene

This study was designed to investigate the in vivo effects of benzo[a]pyrene （BaP） on hepatic ethoxyresorufin-O-deethylase （EROD） activity and its correlation with cytochrome P4501A （CYP1A） protein levels in Sebastiscus marmoratus, which were exposed through a water column to BaP （10, 100, 1000 ng/L, respectively） or were treated with intraperitoneal injections of BaP （0.5, 1, 5, 10 mg/kg, respectively） every 7 d. The results showed that after 25 d of waterborne exposure to 1000 ng/L BaP, fish hepatic CYP1A levels and EROD activity were significantly induced. In contrast, EROD activity was not altered 7 d after second intraperitoneal injections, whereas, CYP1A protein levels were increased. Dose-dependent increase of biliary BaP metabolites demonstrated that the catalytic activity of CYP1A was induced by treatment with BaP. The lowest observable effect concentration with regard to biliary BaP metabolites （100 ng/L） was much lower than that with reference to EROD activity （1000 ng/L）. The results suggest that biliary polycyclic aromatic hydrocarbon （PAH） metabolites were shown to better reflect the contamination gradients of PAHs than EROD activity. It appeared to be necessary to measure CYP1A protein levels to complement the EROD activity in relevant toxicological assessments.     

漂白粉用于治理石化企业硫化氢恶臭气体的研究

实验采用填料吸收塔对漂白粉用于石化企业硫化氢恶臭的治理进行了初步研究,系统研究了漂白粉投加量、硫化氢浓度、进气流量、吸收氧化温度、液气比等因素对处理效果的影响。结果表明：室温下,漂白粉投加量为0．2g／100mL,液气比20L／m^3,进气浓度控制在7800mg／m^3以内,调整适宜的进气量,对硫化氢恶臭的去除率可以达到99％以上。漂白粉吸收氧化硫化氢恶臭气体不仅技术可行,而且费用低廉,操作方便,可以进行深入的研究,进行工业化放大。     

Bradford法测定土壤球囊霉素相关蛋白的影响因子

土壤球囊霉素相关蛋白(glomalin-related soil protein,GRSP)是评价土壤健康的重要指标。研究了土样粒径、贮存条件和高温提取后离心延误时间3个影响因子对采用Bradford法测定GRSP含量的作用效果。结果表明,土样粒径对易提取GRSP(EEG)的提取测定影响显著,过0.074 mm孔径筛土样中提取出的EEG含量高于过0.149、0.25、1 mm孔径筛的土样;总GRSP(TG)含量的测定结果对土样粒径的变化没有明显响应,测定TG含量可采用过1 mm孔径筛的土样。贮存条件影响EEG和TG含量的测定,有机质含量低的土样室温保存18个月条件下测得的EEG含量低于-20℃保存条件下;有机质含量高的土样室温保存条件下测得的EEG含量高于-20℃保存条件下;室温保存条件下3个有机质含量水平的土样TG含量均高于-20℃保存条件下。不同样品保存方式间3个有机质含量水平的土样EEG或TG含量差异均显著。为减小有机质降解等的影响,宜低温保存土样。提取后延误离心将导致EEG含量测定值降低,因此延误时间以控制在1 h之内为宜;离心延误2 h内不同延误时间之间测得的TG含量无显著差异。     

摩托车防盗器遥控引燃黑火药的实验研究

根据2013型铁将军牌摩托车防盗器工作原理,分析了连接左转向灯、起动继电器及电门锁的5条导线遥控引燃黑火药的方式.利用GOS-620型示波器,测得防盗器在设防、寻车、起动、振动1次、连续振动、解锁时这5根导线两两之间的电压.从60种组合中筛选出10种可能引燃黑火药的方式.通过引燃实验,验证了这10种引燃方式.以左转向灯...     

不同聚合度的聚磷酸铵灭火性能研究*

为考察聚磷酸铵（APP）干粉灭火剂的聚合度对其灭火性能的影响,选用3种不同聚合度的APP,结合其晶体结构、粒度分布及热性能测试,并通过粉体杯式燃烧器进行小尺寸灭火实验,对比3种样品的灭火性能及灭火机理,研究聚合度与其灭火性能的关系。热性能测试结果显示,聚合度的升高会导致APP的热稳定性下降,随着聚合度从80升至1 500,其初始分解温度从326.11 ℃降低至321.54 ℃,失重率从75.21%增加至79.66%。实验结果表明:随着APP聚合度的增加,火焰降温速率升高,最小灭火浓度（MEC）降低,灭火性能增强,当聚合度为1 500时,MEC为118.143 g/m3。聚合度的升高有助于APP在进入火场后更早、更充分地与火焰发生反应,从而使灭火性能得到提升。     

酸化大豆蛋白废水的厌氧处理

对有机质浓度高,成分单一,蛋白质、总氮浓度较高,易酸化,且已酸化程度较高的大豆蛋白废水,确定以新型内循环厌氧反应池为主的处理工艺,在原废水ρ(COD)为11809~15040mg/L时,总出水浓度192~350mg/L,去除率达到96.2%~97.5%。新的内循环厌氧反应池具有高度小、结构简单、污染物去除率高的特征,COD运行负荷达6.0~7.5kg/(m3.d),COD去除率达88%~93%。当COD运行负荷5.0~7.0kg/(m3.d)时,该池内循环管道形成了连续的较强内回流。     

2,3,7,8-四氯二苯并二噁英与Aroclor 1254单独与联合作用对大鼠外周血淋巴细胞DNA的损伤效应(Damage Effects of Individual and Combined Exposure to 2,3,7,8-Tetrachlorodibenzo-p-Dioxin and Aroclor 1254 on DNA in Peripheral Blood Lymphocyte of Rats)

为探讨2,3,7,8-四氯二苯并二噁英(TCDD)和多氯联苯(Aroclor 1254)联合染毒对大鼠外周血淋巴细胞DNA的损伤效应,将20只雄性Sprague-Dawley(SD)大鼠随机均分为4组,即对照组(橄榄油)、Aroclor 1254单独染毒组(10mg·kg-1)、TCDD单独染毒组(10μg·kg-1)和联合染毒组(TCDD 10μg·kg-1+Aroclor 1254 10 mg·kg-1).大鼠每天灌胃染毒1次,连续染毒6d.染毒过程中记录大鼠的体征和体重.末次染毒后24h取外周血,分离淋巴细胞,采用碱性单细胞凝胶电泳技术(彗星试验)检测外周血淋巴细胞DNA损伤,并采用CASP软件分析各组彗星的尾部DNA百分含量(Tail DNA%)、尾长(Tail Length)和尾矩(Tail Moment).结果表明,染毒结束时TCDD单独染毒和联合染毒组大鼠体重显著低于对照组,且联合染毒组表现更为明显.TCDD单独染毒组和联合染毒组大鼠外周血淋巴细胞DNA可见明显损伤,TailDNA%、Tail Length和Tail Moment均显著高于对照组(p<0.05),且联合染毒组大鼠细胞DNA损伤更为严重,但Arolor 1254单独染毒组大鼠未见明显DNA损伤.析因分析提示TCDD与Aroclor 1254对大鼠外周血淋巴细胞DNA损伤的联合毒性效应为协同作用.本研究结果表明TCDD与Aroclor 1254联合染毒可加重大鼠外周血淋巴细胞DNA损伤,在对PCBs与二噁英的混合暴露进行危险性评估时要注意这种联合毒性作用.