中原油田开展清洁生产工作的几点体会

中原油田自2008年以来全面推行清洁生产工作,取得了丰硕的成果。文章结合中原油田实施清洁生产的实际,论述了中原油田有效开展清洁生产审核、建立清洁生产长效机制的一些经验和实际做法。中原油田经过努力,油区环境质量得到改善,为构建资源节约型、环境友好型企业奠定了基础。     

CFD分析在烟气脱硫中的实际运用与研究

为降低某公司烧结机干法脱硫装置烟道阻力,减少引风机出力,实现节能优化,运用计算流体力学软件,对引风机出口烟道内流场进行三维数值模拟,并根据分析结果进行烟道的优化改造。改造后,吸收塔入口负压由-200Pa提升至-560Pa,风机电流由328A降为301.4A,节能降耗显著。     

Temporal and Spatial Variability of Water Supply Stress in the Haihe River Basin,Northern China1

Ji, Yuhe, Liding Chen, and Ranhao Sun, 2012. Temporal and Spatial Variability of Water Supply Stress in the Haihe River Basin, Northern China. Journal of the American Water Resources Association (JAWRA) 48(5): 999‐1007. DOI: 10.1111/j.1752‐1688.2012.00671.x Abstract: Water resources are becoming increasingly stressed under the influence of climate change and population growth in the Haihe River Basin, Northern China. Assessing the temporal and spatial variability of water supply stress is urgently needed to mitigate water crisis caused by water resource reallocation. Water supply and use data were compiled for the time period of 1998‐2003 in this synthesis study. The Water Supply Stress Index (WSSI) as defined as Water Demand/Water Supply was used to quantitate whether water supply could meet the demand of human activities across the study region. We found a large spatial gradient of water supply stress in the study region, being much higher in the eastern subbasins (ranging from 2.56 to 4.31) than the west subbasins (ranging from 0.56 to 1.92). The eastern plain region not only suffered more serious water supply stress but also had a much higher interannual variability than the western hilly region. The uneven spatial distribution of water supply stress might result from the distribution of land use, population, and climate. Future climate change and rapid economic development are likely to aggravate the existing water crisis in the study region.     

Ti/BDD/PbO_2复合电极在化学需氧量测定中的应用

以钛基掺硼金刚石为基体,采用电沉积的方法制备了Ti/BDD/PbO2复合电极,并将其用于化学需氧量（COD）的测定。采用扫描电子显微镜（SEM）和X射线衍射谱图（XRD）表征了电极的微观形貌及结构,采用电化学工作站考察了电极对有机物响应特性。实验结果表明,在1.45 V的低电位条件下,线性范围为0.5～175 mg/L,检测限为0.3 mg/L（S/N=3）。采用Ti/BDD/PbO2复合电极测定法和重铬酸钾标准方法对市政污水、食品废水及印染废水的对比结果表明,2种方法的相对误差小于10%,具有良好的一致性。     

红斑顠体虫的污泥减量效果

为了实现红斑顠体虫捕食污泥减量化,对不同条件下红斑顠体虫的污泥减量效果进行实验研究。实验结果表明：红斑顠体虫的污泥减量速率随初始MLSS及温度的增大而增大,初始MLSS越高,污泥减量速率越大。污泥减量速率随红斑顠体虫密度变化率的增大而逐渐增大,当红斑顠体虫的密度增长率出现下降时,污泥减量速率也呈下降趋势。采用间歇曝气（12 h曝气,12 h停曝）方式,红斑顠体虫的污泥减量速率会显著下降。在污泥好氧消化时,红斑顠体虫能捕食污泥中的有机碎片和细菌,达到污泥稳定化的指标要求。     

原位臭氧氧化污泥减量工艺的运行效能

采用ASBR/SBR原位臭氧污泥减量工艺,重点研究了原位臭氧氧化对SBR段污泥产率和出水水质的影响。两个相同的ASBR/SBR组合工艺同时运行,每隔3个周期向臭氧投加组SBR的曝气阶段原位间歇投加臭氧,臭氧投加量为0.027 g O3/g MLSS,连续运行40 d;对照组不投加臭氧作为对比。结果表明,原位臭氧氧化实现污泥减量约43.9%,臭氧投加组SBR段平均污泥产率系数为0.1447 g SS/g SCOD,而对照组为0.2580 g SS/g SCOD,投加组没有惰性污泥的累积,并且污泥沉淀性能得到改善。原位臭氧氧化对出水水质影响不大,投加组与对照组相比,臭氧投加3周期后的出水COD、NH4+-N、TN和TP平均值分别为47.8、0.76、14.1和6.4 mg/L,去除率分别下降了4%、2%、3%和7.7%,其中COD、NH4+-N和TN均能达到《城镇污水处理厂污染物排放标准》(GB18918-2002)一级A标准。     

印染废水污染物在曝气生物滤池中的沿程去除规律

主要研究了曝气生物滤池（BAF）对印染废水中污染物的沿程去除规律。研究表明：BAF对印染废水污染物的去除沿高程有着不同的变化规律：在BAF总高度为300 cm,填料层高度为200 cm,气水比3∶1,停留时间11.8 h,的情况下, BAF对COD的去除主要集中在<160 cm的填料层部分,在总的去除率为63.1%时,此区域去除率可达56.60%;对NH3N的去除主要集中在填料层100～160 cm段,在总NH₃-N去除率为85.09%时,此区域NH₃-N去除率达38.28%。BAF对浊度的去除主要集中在填料层小于100 cm的部分,在总去除率为94.04%,区域去除率达到61.90%。印染废水经过BAF的前100 cm填料层后,pH值由10降至7.6后基本维持不变。     

零价铁与厌氧微生物协同还原地下水中的硝基苯

通过间歇式实验,考察了零价铁与厌氧微生物协同还原地下水中硝基苯的效果。实验结果表明,由零价铁腐蚀为厌氧微生物提供H2电子供体还原硝基苯的效果明显优于零价铁和微生物单独作用,硝基苯去除率分别提高21.8%和57.0%。弱酸性条件有利于协同反应进行,当初始pH为5.0和6.0时,4 d后硝基苯去除率比初始pH为7.0时的提高74.4%和35.2%。增加零价铁投加量可提高协同还原的效果,零价铁最佳投加量为250 mg/L。零价铁腐蚀产生的Fe2+无法作为电子供体被微生物利用,但可作为无机营养元素促进协同过程。由于零价铁产H2速率受表面覆盖物影响不明显,在地下水修复过程中可保证协同效果并延长零价铁的使用寿命。     

Target Gap of Emission Reduction for China:Analysis based on Elastic Decoupling

The present paper analyzes historically the relationship between carbon emission and economic development by different stages through adopting elastic decoupling methods and Tapio evaluation criteria along with a comparison with the national Five Year Plans. The analysis shows that the influencing factors to the relationship between carbon emission and economy in China are different, and economic development and carbon emission have less connection in the recent 30 years of reform and opening-up in China. It is a difficult task to realize the promise that we will reduce carbon emission by 40%-50% in 2020 based on the data from historical experience and different expectations for economic development from economists. Through constructing the calcula- tion model of carbon emission intensity gap according to different development scenarios, the analysis shows that economic growth, infrastructure investment and further development of industrial-ization are the main drivers to the increase of carbon emission, technological progress, and particularly, the reduction of energy consumption is the primary means to reduce carbon emission in China. It is imperative to transform the economic growth pattern, and it is a grand task to perform and there is a long way to go for China to maintain economic growth and reduce carbon intensity.     

火电机组状态及性能全息诊断系统技术及应用

阐述了火电机组状态及性能全息诊断系统的技术原理、系统结构及应用情况。该系统以解决机组应用性能问题为目标,采用状态空间分析模型,具备多层次分析的运行操作指导,基于性能渐变特性的设备状态检修,包括分散度在内的运行指标考核以及定期的节能潜力诊断等功能,在10余家电厂44台近1500万kW机组上取得了供电煤耗平均降低1.5～3.5g（标煤）/kW.h的节能效果。