可靠性技术的发展与应用

本文介绍了可靠性标准体系与参数体系,可靠性的分析与设计方法,可靠性试验的发展趋势,指出可靠性管理是产品可靠性工作的核心,以及提高电子设备可靠性的发展策略。     

PHAST软件在丁腈反应釜定量后果分析中的应用

丁腈反应釜运行过程中若发生泄漏事故,不仅厂区内部,而且附近区域的人员生命与财产都将遭受巨大的损失和危害.过去对一些物质的泄漏后果,人们提出了一些可靠的数学模型,但模型计算量大,容易出错.而采用后果软件PHAST具有很强的操作性.以某化工厂1台丁腈反应釜为例,用DNV公司的PHAST软件预测反应釜中丙烯腈和1,3-丁二烯的混合物发生泄漏后,对周围环境造成的影响.分别讨论了火灾、爆炸和毒性的影响,预测事故危害程度和范围.可为识别主要危险因素,采取相应的安全对策措施,发生事故后的现场控制等提供科学的参考依据.     

电袋复合除尘器的应用研究

针对我国燃煤电厂的除尘现状,指出电袋复合除尘器的技术经济优势.电袋复合除尘器在新建及改扩建电厂的成功应用取得了良好的经济、环境效益,并有广阔的发展前景.其研究重点是静电除尘单元和布袋除尘单元之间的结合.     

吨量煤体的自燃过程实验模拟研究

为更好地弄清矿井实际的煤自然发火规律,利用装煤量达5吨的大型实验台对两种烟煤分别进行了自燃模拟实验。大煤量的实验能够很好地模拟煤矿中煤低温氧化和传热传质共同作用导致的发火过程,实验得到的自然发火期与煤矿实际发火期也是一致的。实验中煤样从缓慢氧化变为快速氧化的临界温度为100～110℃。当煤温低于,临界温度时,煤样的升温受到空气流带走热量和向外界散热的影响很大,因此夹层水的保温作用就很关键。当煤温超过临界温度后,反应加快,温度急剧上升,散热的影响明显降低,反应主要受限于氧气的供应情况。     

新疆阜康冶炼厂无污染工艺及环境治理

介绍了阜康冶炼厂无污染新工艺和环境治理的有关情况 ,从理论上阐述了无污染工艺和污水治理的技术原理 ,对有色金属冶炼工业逐步采用湿法精炼清洁工艺有一定的指导作用     

污染物排放总量监测存在问题和对策

指出了目前总量监测中存在问题,如技术规范不够完善、监测能力和人员素质难以满足变化的生产工况、企业的配合不到位以及环评预测总量与实际情况出入太大,且不合理等。提出,应尽快制定和完善相关监测技术规范;加强在线监测监控体系的建设;加强监测人员自身专业素质的建设,以提高总量监测质量,更好地为环境管理服务。     

海洋纤毛虫——巨大拟阿脑虫的实验生态研究Ⅲ.pH对种群生长的影响

就水环境中pH对巨大拟阿脑虫Paranophys magna（纤毛门,盾纤目）种群生长的影响及后者的应答与适应进行了探讨,结果表明,虫体生存的pH阈值约为5－9．6,最适范围为7.0-9.0;pH对巨大拟阿脑虫的种群生长有显著影响,种群自然增长率及种群所达最大种群密度均随pH的不同而明显改变。     

Experimental Study of the Criteria of Flow Laminarization in Two-Dimensional Dense Gas Plumes

Laminarization of flow in a two-dimensional dense gas plume was experimentally investigated in this study. The plume was created by releasing CO₂ through a ground-level line source into a simulated turbulent boundary layer over an aerodynamically rough surface in a meteorological wind tunnel. The bulk Richardson number (Ri_*), based on negative plume buoyancy, plume thickness, and friction velocity, was varied over a wide range so that the effects of stable stratification on plume laminarization could be observed. A variety of ambient wind speeds as well as three different sizes of roughness arrays were used so that possible effects of roughness Reynolds number (Re_*) on plume laminarization could also be identified. Both flow visualization methods and quantitative measurements of velocity and intermittency of turbulence were used to provide quantitative assessments of plume laminarization.Flow visualization provided an overall picture of how the plume was affected by the negative buoyancy. With increasing Ri_*, both the plume depth and the vertical mixing were significantly suppressed, while upstream propagation of the plume from the source was enhanced. The most important feature of the flow revealed by visualization was the laminarization of flow in the lower part of the plume, which appeared to be closely related to both Ri_* and Re_*.Measurements within the simulated dense gas plumes revealed the influence of the stable stratification on mean velocity and turbulence intensity profiles. Both the mean velocity and turbulence intensity were significantly reduced near the surface; and these reductions systematically depended on Ri_*. The roughness Reynolds number also had considerable influence on the mean flow and turbulence structure of the dense gas plumes.An intermittency analysis technique was developed and applied to the digitized instantaneous velocity signals. It not only confirmed the general flow picture within the dense plume indicated by the flow visualization, but also clearly demonstrated the changes of flow regime with variations in Ri_* and Re_*. Most importantly, based on this intermittency analysis, simple criteria for characterizing different flow regimes are formulated; these may be useful in predicting when plume laminarization might occur.     

垂直面绿化植物遮阳系数与叶面积指数研究

比较、分析了农业研究中提出的叶面积指数LAI与用于建筑节能领域的垂直面绿化植物叶片遮阳系数SCPVW两个概念的异同和各自的应用范围。指出城市绿化采用水平或垂直绿化方式时,由于下垫面差异,植物叶片的遮阳系数应当分别采用LAI和SCPVW进行计算。     

城郊土壤共存元素对土壤作物系统Cd、Pb迁移的影响分析——以白银市城郊区为例

通过共存元素对土壤小麦系统Cd、Pb行为影响的调查研究发现：大田条件下共存元素以正对数模式与根系Cd、Pb密切相关,同种元素间相关程度最高;根系Cd、Pb积累主要取决于土壤环境Cd、Pb的含量,共存元素也产生一定的影响,认为要防止重金属通过食物链对人类的危害,就必须降低土壤环境中重金属的总量。