酒石酸钾钠(PST)对纳滤处理重金属废水的强化效果

以酒石酸钾钠(PST)为络合剂,分别选取Cd、Zn、As和Pb 4种金属废水,探索络合纳滤工艺对金属离子去除率和膜通量的强化效果,测定纳滤膜表面接触角以表征膜通量变化规律,并研究了压力、金属浓度和溶液pH参数对络合纳滤过程的影响。结果表明,PST对4种金属去除的强化效果存在相似规律,分别有一个最佳PST添加浓度。随PST浓度的增加,金属离子去除率先增大后减小,而膜通量一直增大。研究发现,纳滤膜表面接触角与膜通量呈稳定的反比例关系,与金属离子种类和PST添加量无关。随着操作压力的增大,膜通量线性增加,去除率基本不变;金属离子浓度的增加对膜通量影响不大,金属去除率略有上升;pH在4~5之间变化时,As去除中膜通量和去除率均有所升高,而Cd、Zn和Pb 3种溶液处理效果基本不受pH影响。     

Effect of synthesis parameters on single gas permeation through T-type zeolite membranes

In this research, nanoporous zeolite T membranes were synthesized at three levels of synthesis temperature: 100, 120 and 140 °C and synthesis time: 15, 30 and 50 h and characterized by gas permeation. Effects of synthesis parameters on CO₂ and CH₄ permeances and CO₂/CH₄ ideal separation factors were studied. All experiments were conducted at 1 bar feed pressure and 30 °C module temperature. Normally, it is anticipated that increasing synthesis temperature and synthesis time increase gas permeances and consequently decrease ideal separation factor. This prediction was not observed in the case of synthesis temperature increase from 100 to 120 °C as well as synthesis time increase from 15 to 30 h, due to the dual effect of increasing synthesis temperature and synthesis time on gas permeances and ideal separation factor. More zeolites are deposited and larger crystals are formed at higher synthesis temperatures and times. Forming the larger crystals accelerates the rate of zeolite layer integration, which is responsible for gas separation, in one hand and reduces the density of deposited zeolite layer on the support, due to the formation of more voids, on the other hand. In terms of maximizing the CO₂/CH₄ ideal separation factor, medium synthesis temperature and synthesis time (120 °C and 30 h) can be selected, however, maximum gas permeances are obtained at low levels of synthesis temperature and time (100 °C and 15 h). According to the ranges of gas permeances (10⁻¹¹ to 10⁻⁶ mol/m² s Pa) and CO₂/CH₄ ideal separation factors (1.4–70.3), it is concluded that the zeolite T membranes synthesized at optimum conditions can be employed for membrane separation of CO₂/CH₄ mixtures.     

用盐桥支撑双分子层脂膜模拟研究锌离子跨细胞膜输运

采用盐桥支撑技术制备镶嵌胆固醇的双分子层卵磷脂(脑磷脂)膜,用以模拟细胞膜.用正辛烷做溶剂,对不同卵磷脂(脑磷脂)与胆固醇配比进行制膜,膜的稳定性均超过100h.实验发现,纯脂质体不能输运重金属离子,胆固醇能输运重金属离子.胆固醇与重金属离子之间存在吸附作用,无化学反应.采用电化学工作站对双分子层脂膜的稳定性、离子通透性、双层膜中胆固醇对离子通透性的影响等进行了研究,并利用实验制备的双分子层脂膜模拟研究锌离子跨细胞膜的输运过程,建立了锌离子跨细胞膜的吸附-扩散模型,该模型计算值与实验值基本吻合.     

纳滤膜技术在废水深度处理中的膜污染及控制研究进展

纳滤(Nanofiltration)膜技术是实现废水再生利用的有效途径,但膜污染是限制其推广应用的主要因素之一.本文总结了纳滤膜技术在废水深度处理过程中的膜污染研究现状,分析了膜污染分析方法研究进展,并探讨了纳滤膜污染的控制策略,最后对今后的工作重点进行了展望,以期为纳滤膜技术在不同废水深度处理过程中的膜污染调控提供参考.     

纳滤预处理测定景观水体中溶解性有机氮质量浓度及其分布特征

为了提高景观水体中DON测定的精确性,研究了纳滤(NF90、NF270)预处理前后水样中DON测定的变化,探讨了NF90、NF270对DIN的去除效果.结果表明,NF90和NF270预处理对NH4+-N、NO3--N和NO2--N的平均去除率分别为30.7%、55.9%、50.0%、73.1%、42.9%、72.0%,NF270对DIN的去除效果更好.常规方法测定DON的质量浓度范围为0.09～0.46 mg·L-1,采样点2处出现负值(-0.08 mg·L-1),DIN/TDN比率范围为85.3%～105%;NF90预处理测定DON的质量浓度范围为0.03～0.58 mg·L-1,DIN/TDN比率范围为76.1%～90.6%;NF270预处理测定DON的质量浓度范围为0.10～0.59 mg·L-1,DIN/TDN比率范围为47.5%～84.5%.这说明NF预处理能够有效去除水样中DIN,减少DON测定的标准偏差,增加了测定的精度.奥林匹克森林公园水体中DON分布的研究表明,水体DON呈现显著的季节性差异,并且南北园区也存在明显差异.北园11月、3月、5月DON较低,小于0.2 mg·L-1,7月质量浓度较高,南园5月DON较低,11月和3月较高,在0.40～0.65 mg·L-1之间.     

Effects of ion concentration and natural organic matter on arsenic(V) removal by nanofiltration under different transmembrane pressures

The removal of As(V) from synthetic water was studied using four different nanofiltration (NF) membranes (ESNA-1-K1, NF270, ESNA-1-LF, and HODRA-CORE). The influences of ion concentration, transmembrane pressure (TMP), and the presence of natural organic matter (humic acid, HA) on the arsenic removal efficiency and permeate flux were investigated. The arsenic rejection of ESNA- 1-LF was higher than those of the other membranes in all experiments (> 94%), and the HODRA-CORE membrane gave the lowest removal of arsenic (< 47%). An increase in the ion concentration in the feed solution and addition of HA decreased the arsenic rejection of the HODRA-CORE membrane. However, both increasing of the ion concentration and addition of HA made the rejection increased for the other membranes (ESNA-1-K1, NF270, and ESNA-1-LF). With increasing TMP, for all four NF membranes, increases in both arsenic rejection and permeate flux were observed. The permeate fluxes of the four NF membranes decreased to some extent after addition of HA to the solutions for operating time of 6 hr.     

光催化/活性炭/纳滤组合工艺处理二级出水及对膜污染的控制

污水的资源化与回用可作为城市和各类建筑的非传统水源,必须满足相关水质标准,其中有机物一直是广泛关注的重要指标.本文采用华北某市大型污水厂的二级出水,研究了二氧化钛光催化氧化(UV-TiO_2)和颗粒活性炭(GAC)技术对溶解性有机物的去除特性以及对纳滤(NF)的膜污染控制特性,构建了UV-TiO_2/GAC/NF组合工艺,评价了组合工艺的有机物去除效能和膜污染控制作用,解析了影响NF膜污染程度的有机物种类和相对分子质量分布特征.结果表明,UV-TiO_2和GAC技术均可不同程度地缓解NF膜的不可逆污染、降低膜通量衰减速率; UV-TiO_2/GAC联用的不可逆膜污染程度比单独UV-TiO_2或GAC技术分别降低了48. 7%或61. 4%.类蛋白质和类腐殖质等有机污染物是不可逆膜污染的主要组分;相对分子质量为小于3×10~3和30×10~3～100×10~3的有机物是造成纳滤膜通量下降的主要因素. UV-TiO_2/GAC/NF组合工艺的COD、DOC和UV_(254)去除率为45. 7%、74. 5%和89. 2%,出水中COD、DOC和UV_(254)等有机物指标均得到有效去除.研究成果为城市和各类建筑非传统水源的深度净化与多途径回用提供了技术支持.     

某微污染水源自来水厂的纳滤深度处理效果研究

采用一级四段纳滤组合工艺处理南方某微污染水源自来水厂的传统净水工艺段出水,考察了纳滤膜工艺对出水水质的提升效果.结果表明,纳滤对常规水质指标与微量有机物有较好的去除效果,对混凝沉淀池出水中TOC和UV_(254)的去除率在95%以上(出水TOC≤0.3 mg·L~(-1),UV254≤0.005 cm~(-1));对卤乙酸、三卤甲烷前体物、多环芳烃和有机氯农药的截留率分别在62%、85%、50%和95%左右,使用UMU-SOS测试的出水遗传毒性低于检出限,不同段纳滤膜对相对分子质量较大的消毒副产物前体物与有机氯农药的去除率未呈现明显差异,但对相对分子质量较小的多环芳烃去除效果呈现明显差异,表明纳滤主要依靠物理截留去除水中相对分子质量较大的有机物,对相对分子质量较小的有机物则存在较大的局限性.与之相比,水厂目前使用的双级臭氧-生物活性炭深度处理工艺对传统净水工艺出水中多环芳烃、有机氯农药、遗传毒性的去除截留率分别仅为17%、62%、80%左右,显示纳滤对微量有机物的去除效果更为理想.     

焦化废水纳滤浓水除氟试验研究

焦化废水采用纳滤工艺进行深度处理会产生大量高浓度的含氟纳滤浓水.针对高氟离子的纳滤浓水,对比考察了Ca(OH)2和CaCl2两种钙盐在焦化纳滤浓水中的除氟效果.研究了Ca(OH)2和CaCl2除氟药剂投加量,合适的pH值,以及纳滤浓水中氯离子、硫酸根离子对除氟的干扰作用.试验结果表明:采用CaCl2可将F-降至10 mg/L以下,最佳条件为初始pH调至10.0,CaCl2投加量为6 000 mg/L,出水pH呈弱碱性,出水中的氟离子低于10 mg/L,达到国家规定的废水排放标准,且采用工艺简便,运行稳定.