蓝藻厌氧消化产沼气技术研究

为了实现太湖蓝藻的资源化和无害化处置,本文在中温（35℃）条件下对蓝藻与猪粪厌氧发酵产沼气进行了研究。在蓝藻与猪粪发酵最佳接种比例1：2、最佳初始pH7．9、最适发酵液浓度2．9％条件下,通过对所产甲烷的分析,得到回归方程B：4885（1-e-0.034565t）,模型的决定系数R2为0．9819,均方差（RMSE）为123,达到收敛判断标准。蓝藻的生物降解率（BD值）为54．4％。pH的变化范围在6．6～7．9之间,能够较好地反应蓝藻与猪粪混合发酵的水解阶段、产酸阶段和产甲烷阶段。发酵结束后,TS去除率达到22．2％,VS去除率达到25．2％。对发酵过程中COD和氨氮变化的研究表明：反应结束后,COD的去除率达87．44％;高浓度的氨氮对厌氧细菌的生长有一定抑制作用,但是并不影响沼气的组份。各反应器所产生的沼气中甲烷和二氧化碳的含量均能保持在50％和35％左右,最高甲烷含量达到70％。     

锌污染对猪粪堆肥过程中氧化还原类酶活性的影响

以猪粪和秸秆为主要试验材料,添加不同浓度重金属Zn,采取发酵罐处理方法,在好氧高温条件下,研究了重金属锌污染对猪粪堆肥过程中多酚氧化酶、脱氢酶活性的影响,以及对堆腐过程堆体温度、堆料pH值、胡敏酸E4/E6值的影响.结果表明:①CK以及低量重金属Zn污染的堆料升温快,高温期持续时间长,达到无害化处理.②Zn含量为600mg·kg-1和900mg·kg-1的堆料E4/E6平均值小,有利于腐殖质的缩合和芳构化.③Zn含量为600mg·kg-1的堆料多酚氧化酶平均活性、脱氢酶平均活性最高,有助于堆料中木质素的降解及其产物的转化、微生物生长繁殖.④Zn含量为300mg·kg-1、600mg·kg-1、900mg·kg-1的堆料对pH有较强的控制能力,其脱氢酶活性均表现出一定的不稳定性,可能是重金属对脱氢酶活性有抑制作用的同时发生"抗性酶活性现象".     

苦咸水反渗透淡化中影响膜面的污染因素

由于苦咸水的化学组成和浓度分布在不同地区有着显著的差异,以及淡化工艺中普遍较高的浓缩因子(concentrate factor,CF)值(在4—10之间),苦咸水反渗透(brackish water reverse osmosis,BWRO)淡化过程中的膜污染现象、类型和程度较海水反渗透(seawater reverse osmosis,SWRO)淡化过程有明显的不同.目前,膜污染已成为BWRO大规模应用于苦咸水淡化领域的瓶颈之一,如何解决这一问题成为该领域的研究热点.本文详细综述了国内外BWRO淡化过程中影响膜面污染因素的应用研究进展,重点介绍了进水来源污染成分及污染倾向、进水水质优劣指标和进水物性对膜面污染的影响;按照分离技术的不同,分类讨论了常规预处理和膜法预处理工艺,指出后者不易受进水水质变化的影响,能够更好地降低膜面污染潜能,并针对目前的研究现状提出了建议.     

氨氮浓度对鸡粪中高温甲烷发酵的影响

为探究氨氮浓度对鸡粪中高温甲烷发酵的影响，采用固定水力停留时间（HRT，20d），提高进料总固体浓度（TS，5%、7.5%和10%）的方式增加氨氮浓度，通过265d的长期甲烷发酵试验，比较了不同氨氮浓度条件下鸡粪中高温甲烷发酵效果和污泥的比产甲烷活性.结果显示，TS由5%增至10%，中高温反应器中氨氮浓度由2.1~2.5g/L增至6.1~6.5g/L，对应的比产甲烷活性分别降低了44%和100%，中温反应器中挥发性脂肪酸由0.4g/L增至7.6g/L，甲烷产率由253mL/gTS降至203mL/gTS；高温反应器中挥发性脂肪酸由0.4g/L增至26.1g/L，甲烷产率由181mL/gTS降至18mL/gTS.氨氮浓度对高温甲烷发酵系统的抑制作用更加明显.     

饲料级磷酸氢钙生产中预中和渣的综合利用

介绍了用饲料级磷酸氢钙生产中的预中和渣制造复混肥，改性磷铵和磷酸钠等产品的具体方法。     

不同腐熟度猪粪、奶牛粪在小白菜和香瓜上施用的农学效应研究

进行猪粪和奶牛粪自然高温堆肥发酵,分别在15、25、35、50 d取样,获得了不同腐熟程度堆肥产物,分别进行了小白菜和香瓜种子发芽与田间应用试验,以期获得不同腐熟堆肥在蔬菜上施用的农学效应,旨在从堆肥农田施用的农学效应角度,为制订堆肥腐熟度标准提供科学依据。结果表明：牛粪堆肥过程中的最高温度高于猪粪,且高温期也长于猪粪;两种处理在35d有机碳含量均显著降低,全氮含量为先降低后升高趋势;两种堆肥在35d后,均达到无害化标准。不同腐熟程度堆肥对小白菜株高和主根长及香瓜苗重和主根长均没有明显抑制作用,对小白菜和香瓜出苗率、根系活力及小白菜单株鲜重和生物产量影响较大,尤其是猪粪腐熟25d,奶牛粪腐熟15d的堆肥表现出显著抑制作用。将堆肥理化参数与小白菜、香瓜生长指标进行相关分析表明：pH值、全氮含量和C/N这3种指标均与小白菜和香瓜各项生物性状无显著相关性;有机碳和DOC与各项生物性状指标均表现出显著或极显著相关性;铵/硝与小白菜和香瓜的GI和根系活力均表现极显著或显著的相关性,其结果与现行的堆肥腐熟度指标并不一致。因此,在制订堆肥腐熟度标准时,应关注堆肥产物农田施用后不同作物所表现出的不同农学效应。     

Determination of PCDDs and PCDFs in different animal feed ingredients

As result of a study to control feedstuff, analyses were carried out to evaluate the contamination caused by PCDDs and PCDFs in different animal feed ingredients. Thirty two samples were selected, including ingredients of animal and mineral origin. For samples of mineral origin, some additives widely employed as binder and anticaking agents, such as bentonite, damoline, kaolin, magnesite, sepiolite and zeolite were selected. And, for ingredients of animal origin, samples of hemoglobin, animal fat, fish oil, fish meal and meat and bone meal were analyzed. The levels ranged from 0.52 to 9.08 pg WHO-TEQ/g fat for samples of animal origin, and from 0.05 to 460.59 pg WHO-TEQ/g for samples of mineral origin. The higher concentrations were observed for the kaolin samples that presented high levels of dioxin contamination.     

Comprehensive study on dioxin contents in binder and anti-caking agent feed additives

Polychlorinated dibenzo-p-dioxins (PCDDs) and polychlorinated dibenzofurans (PCDFs) were determined in some additives widely employed as binder and anti-caking agents in feedstuffs, such as kaolin, bentonite, zeolite, etc. with an special attention on sepiolite samples. Owing to their physico-chemical properties, the little information of these materials reported in the literature, the variability of PCDDs/PCDFs found in a preliminary evaluation and the absence of reference materials highlighted further research needed. Therefore, an extensive study on the analytical procedures based on the classical methods was performed with sepiolite samples. The study includes evaluation of reproducibility and repeatibility. To this end, a series of intra-day and nine inter-day analysis were made. The methodolgy was also assessed against the sample size and series of 12.5, 25, 37.5 and 50 g were analyzed. In all cases, the results confirmed good correlation with the parameters evaluated.     

Proposal for an Indexical Method of Evaluating Risk of Hand Tool Operators’ Exposure to Mechanical Vibrations

The article presents proposals for an indexical evaluation of exposure of hand tool operators to vibrations. The presented indices have been developed on the basis of the results of laboratory tests. The examinations studied the effect of pressure force and grip force exerted by an operator on a hand tool as well as the amplitudes and frequencies of an exciting signal on vibrations transmitted in the hand-tool handle system.     

洞庭湖区芦苇和荻的饲用潜力及开发利用

洞庭湖区拥有丰富的芦苇和荻资源。两者鲜嫩时的化学与营养成分接近优良牧草黑麦草,适于饲喂牛。若于拨节中期收获２～４次,则可年产干草４．５～７．５×１０５ｔ,可为８．２２～２０．５５×１０４个黄牛单位提供全年用优质饲草;若再与湖区丰富的农副产品相配合,发展集约化商品性的养牛业是切实可行的。收获的牧草可通过青饲、青贮、调制干草、加工成草粉或颗粒配方饲料的方式加以利用。为保障秋季其他用途的收获及第二年的正常生长发育,必须要采取一系列行之有效的措施,其中人工促进再生复壮和加强宏观调控是最关键的环节。